NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
9 reportsClear category filter57,000 miles · Sep 1, 2026
Electrical SystemEngine And Engine CoolingStructure
The contact owns a 2023 Toyota Tundra. The contact stated that while starting the vehicle, the check engine, Auto Start/Stop, and another unknown warning light illuminated. The message "Grill Shutter Malfunction Low Voltage" was displayed. The vehicle was taken to the dealer, who determined that the battery sensor, alternator, a…
Read full complaint
The contact owns a 2023 Toyota Tundra. The contact stated that while starting the vehicle, the check engine, Auto Start/Stop, and another unknown warning light illuminated. The message "Grill Shutter Malfunction Low Voltage" was displayed. The vehicle was taken to the dealer, who determined that the battery sensor, alternator, and ECU had short-circuited. The dealer replaced the battery sensor, alternator, and ECU; however, the failure persisted with the check engine and another unknown warning light illuminated. The vehicle was taken back to the dealer, who determined that the grill shutter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 57,000.
NHTSA ODI #11761331
Mileage unknown · Dec 23, 2025
Structure
Traveling on highwy bat 70 mph the fuel tank protection panel 77606/77641C came loose in the front after bracket support 77511 broke and the air pressure bent the protector down at the front and it hit the roadway and bounced up and banged against the tank area. I stopped, assessed damage, took picture and got off highway and dr…
Read full complaint
Traveling on highwy bat 70 mph the fuel tank protection panel 77606/77641C came loose in the front after bracket support 77511 broke and the air pressure bent the protector down at the front and it hit the roadway and bounced up and banged against the tank area. I stopped, assessed damage, took picture and got off highway and drove home slowly. The subsequent part inspection showns fabrication errors in the part with fatigue failure and contaminated material. This could have been catastrofic failure with ontinued impact to fuel tank.
NHTSA ODI #11706849
Mileage unknown · Jun 3, 2025
Electrical SystemStructure
Whenever it rains in DFW, vehicle emits a foul/musty odor from the HVAC system. Only happens when it rains. HVAC setting has always been the same, "Lo" temp, AC Mode ON, Recirculation mode ON, fan speed varies. Taken vehicle to two different dealerships and techs unable to duplicate. It doesnt rain much here in TX so it is h…
Read full complaint
Whenever it rains in DFW, vehicle emits a foul/musty odor from the HVAC system. Only happens when it rains. HVAC setting has always been the same, "Lo" temp, AC Mode ON, Recirculation mode ON, fan speed varies. Taken vehicle to two different dealerships and techs unable to duplicate. It doesnt rain much here in TX so it is hard to get it taken care of while still within warranty. My family and I use this vehicle primarily and I am concerned for my kids' lung health as they are [XXX], [XXX], and [XXX] years old as of writing. Running out of warranty time and hate to not get this fixed and be [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11664498
Mileage unknown · May 9, 2025
StructureUnknown Or Other
Rear passenger door trim, and accelerator pedal lag.
NHTSA ODI #11660095
Mileage unknown · Jun 26, 2024
Structure
The rear passenger window trim will come loose and could fly off and hit other vehicles. I have brought this back to the dealer twice and they claimed to have replaced it but it is still malfunctioning. Upon MY investigation it seems like the actual door was not hemmed properly thus not allowing the window trim to seat and st…
Read full complaint
The rear passenger window trim will come loose and could fly off and hit other vehicles. I have brought this back to the dealer twice and they claimed to have replaced it but it is still malfunctioning. Upon MY investigation it seems like the actual door was not hemmed properly thus not allowing the window trim to seat and stay seated. The driver's side rear door does not have this issue. Furthermore, I have checked new vehicles in the dealer's inventory and found the same issue on multiple NEW vehicles at North Park Toyota in San Antonnio, TX.
NHTSA ODI #11596858
Mileage unknown · Feb 16, 2024
StructureVisibility/wiper
This vehicle has tow mirrors that are located way too high for the driver to see over them - I'm 5'10" and my son is 6'0" and neither of us can see over these mirrors. Over the past year I have had multiple close calls because of the very large blind spot created by the tow mirrors on this vehicle. There is also excessive pl…
Read full complaint
This vehicle has tow mirrors that are located way too high for the driver to see over them - I'm 5'10" and my son is 6'0" and neither of us can see over these mirrors. Over the past year I have had multiple close calls because of the very large blind spot created by the tow mirrors on this vehicle. There is also excessive plastic around the mirror that excerbates the problem. It is only a period of time before a serious accident or a pedestrian collision will happen because of this manuracturing/design defect. Very concerned and disappointed. One specific incident was when I was turning onto a road at a slight and looked both ways and pulled out in front a car that was behind the blind spot and going 60 mph. Very close to a major accident.
NHTSA ODI #11572448
Mileage unknown · Jan 4, 2024
Structure
regarding my 2023 Toyota Tundra. The passenger side front window is non-operational, having come off the track and proving impossible to raise. Upon consulting the dealership, it was determined that the Regulator and Motor for the window require replacement. It has come to my attention that this issue is not isolated to my vehic…
Read full complaint
regarding my 2023 Toyota Tundra. The passenger side front window is non-operational, having come off the track and proving impossible to raise. Upon consulting the dealership, it was determined that the Regulator and Motor for the window require replacement. It has come to my attention that this issue is not isolated to my vehicle, as numerous reports on social media platforms highlight a recurring problem with faulty windows in this model. The prevalence of inoperable windows, whether stuck in the up or down position, poses a potential hazard. I urge the NHTSA to investigate and address this matter promptly to ensure the safety of all Toyota Tundra drivers and passengers.
NHTSA ODI #11563468
Mileage unknown · Aug 10, 2023
StructureUnknown Or Other
It has been over 5 months since receiving the recall notice of the 2023 tundra tonneau cover (23TA03). Dealer asked me to wait for a toyota fix multiple times and then did not respond to further requests for answers solutions or a refund for the part that I did not want. Additionally the bed rails had defects and rust that acc…
Read full complaint
It has been over 5 months since receiving the recall notice of the 2023 tundra tonneau cover (23TA03). Dealer asked me to wait for a toyota fix multiple times and then did not respond to further requests for answers solutions or a refund for the part that I did not want. Additionally the bed rails had defects and rust that accumulated inside of the rails and is all over my bed liner indicating potential future rusting issues on the best of the truck. I bought it in December of 2022. Rust was apparent after 3 Months. No reply via phone or email or social media from. Toyota. No solutions yet or refunds issued for an obviously defective and dangerous product. Simply fix is refund for tonneau cover and new bed rails.
NHTSA ODI #11537635
Mileage unknown · May 16, 2023
Structure
The contact owns a 2023 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 23V142000 (Structure) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the is…
Read full complaint
The contact owns a 2023 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 23V142000 (Structure) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11522337
Official recalls
13Nov 6, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2024 Toyota Tundra, Lexus LX, and 2024 Lexus GX vehicles equipped with a V35A engine. Debris from the manufacturing process may contaminate the engine and cause the main bearings to fail, which can result in an engine stall and loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an inspection on the #1 main bearing using vehicle inspection software and drive data, and if necessary, replace the engine. Repairs will be performed free of charge. Owner letters were mailed August 28, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB14 and 25TA14. Lexus' numbers for this recall are 25LB07 and 25LA07. This recall expands previous NHTSA recall number 24V381.
Oct 1, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2025 Tundra, Tundra Hybrid, and 2023-2025 Sequoia Hybrid vehicles. A software error may cause the rearview image not to display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the multimedia display software, free of charge. Owner notification letters were mailed November 19, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB10 and 25TA10.
May 15, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2025 Toyota Tundra and Tundra Hybrid vehicles. Moisture may enter the reverse light assemblies and cause a light failure.
Consequence & remedy
Consequence: Reverse light failure may reduce visibility, and not alert pedestrians and other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy: Dealers will replace both reverse light assemblies and repair the wire harnesses as necessary, free of charge. Owner letters were mailed May 23, 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331.Toyota's numbers for this recall are 24TB06 and 24TA06.
Jul 23, 2024
Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
Remedy: GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.
May 30, 2024
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Lexus LX600 vehicles equipped with a V35A engine. Debris from the manufacturing process may contaminate the engine and cause the main bearings to fail, which can result in an engine stall and loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the engine assembly, free of charge. Owner letters were mailed between December 17, 2024 and February 19, 2025. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TB07/24TA07 and 24LB04/24LA04.
Feb 21, 2024
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2024 Tundra, Tundra Hybrid, Lexus LX600, and 2023-2024 Sequoia Hybrid vehicles. Unexpected vehicle movement may occur when the vehicle is in neutral and the brakes are not applied.
Consequence & remedy
Consequence: Unexpected vehicle movement can increase the risk of a crash.
Remedy: Dealers will update the transmission control ECU software, free of charge. Owner notification letters were mailed April 8, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TA02 and 24LA02.
Nov 9, 2023
Southeast Toyota Distributors, LLC (SET) is recalling certain 2022-2024 Toyota Tundra vehicles. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: SET will mail a new modified label, free of charge. Owner notification letters were mailed December 18, 2023. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET23B.
Sep 13, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Tundra and Tundra Hybrid vehicles equipped with a spray-on bed liner accessory. The load carrying capacity modification label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Dealers will replace the load carrying capacity modification label, free of charge. Owner notification letters are expected to be mailed October 29, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA11.
Aug 10, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles. The plastic fuel tube routed near metallic brake lines may chafe against the brake lines and become damaged, possibly resulting in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Dealers will install protective materials and a clamp on the fuel tube, free of charge. Owner letters were mailed November 6, 2024. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 23TB09/23TA09.
Jul 7, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Tundra, Tundra Hybrid, and Sequoia Hybrid vehicles. The steel chain used to secure the spare tire to the underside of the vehicle may have been insufficiently welded.
Consequence & remedy
Consequence: Chains that are not welded sufficiently can break and allow the spare tire to detach, increasing the risk of a crash.
Remedy: Dealers will replace the spare tire carrier assembly, free of charge. Owner notification letters are expected to be mailed August 14, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TB06/23TA06.
Mar 3, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles that may be equipped with a Toyota genuine accessory tonneau cover. The tonneau cover attachment joints may come loose and allow the cover to detach.
Consequence & remedy
Consequence: A tonneau cover that detaches while driving can become a road hazard, increasing the risk of a crash.
Remedy: Owners of the subject vehicles will be notified by first class mail to return their vehicles to a Toyota dealer. Dealer will install new hardware (bolts, spacers, washers, nuts, rubber washers and cotter pins) to the existing bracket and tonneau cover. If the tonneau cover has tears or splits at the mounting holes to the extent that new hardware cannot be installed, it will be replaced with a new tonneau cover and hardware. Owners will receive a notice once the remedy becomes available. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TB03/23TA03.
Feb 22, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tundra and Tundra Hybrid vehicles. A software error in the combination meter's electronic control unit (ECU) may cause the Instrument Panel LCD display to go blank. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence & remedy
Consequence: A blank display will not show critical information such as the speedometer or warning lights, increasing the risk of a crash.
Remedy: Dealers will update the combination meter ECU software, free of charge. Owner notification letters are expected to be mailed April 17, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA02.
Nov 18, 2022
Gulf States Toyota, Inc. (GST) is recalling certain 2023 Tundra pickup trucks equipped with non-skid spray-on bed liners. The load carrying capacity modification label may indicate less weight than the actual total weight of accessories installed on the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Remedy: GST will mail replacement labels to owners, free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 22R2.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration