IllustrationPower sliding door on driver side cable snapped. After closing door and trying to use the door without power unable to open or close the door at all. Passengers forced to use alternate door for exit of vehicle.
2020 Toyota Sienna
Owner reports · Recalls · Investigations
Fewer warning signs than most model years
Owner complaints for the 2020 Toyota Sienna are lower than the model-year median of 183.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sienna years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 38 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
Structure complaints
4 reportsThe power sliding door assembly failed, and the driver side rear sliding door was bound shut, and could not be opened. Disabling the power door system did not resolve the issue. The cable for the power door mechanism was hanging below the rear vent windows; but for some reason the door still would not open. I ultimately with …
Read full complaint
The power sliding door assembly failed, and the driver side rear sliding door was bound shut, and could not be opened. Disabling the power door system did not resolve the issue. The cable for the power door mechanism was hanging below the rear vent windows; but for some reason the door still would not open. I ultimately with a lot of gentle force was able to get the door open enough to see the retract side of the cable was bound up, and was able to cut it with wire cutters, and ultimately get the door to work normally as a non-powered manual sliding door. Since the original NHTSA BULLITIN on this was published in 6/2019 before my 2020 Sienna was manufactured, and Toyota did not change the mechanism until the 2021 model redesign, I believe that RECALL should be extend to all 2019 and 2020 vehicles. This seems dangerous that the door does not default to manual operation in error.
Hinge rust on fuel door causing it to break and not let rear passenger door auto open (because switch won't make up) hinge is very weakly built
The passenger side rear door unlocked and opened by itself in the middle of the night, no warning messages were given previously, doors were locked that night. Keys were not accidentally pressed on. It seems that others have had similar problems with Toyota Siennas in the past as well.
Official recalls
220V682000 · Fuel System, Gasoline:delivery:fuel Pump
Nov 4, 2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
19V532000 · Steering
Jul 16, 2019
Braun Corporation (Braun) is recalling certain modified 2017-2020 Toyota Sienna vehicles. The steering shaft extensions may have been improperly manufactured, possibly causing the extensions to fracture.
Consequence & remedy
Consequence: If the steering shaft extension completely fractures, it can cause a loss of steering, increasing the risk of a crash.
Remedy: Braun has notified owners, and dealers will replace the steering shaft extensions, free of charge. The recall began July 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.