2025 Toyota RAV4

UNKNOWN - On XXX, at just 7,741 miles, my 2025 Toyota RAV4 XLE Premium AWD (VIN: [XXX]) suffered a catastrophic and life-threatening complete mechanical and hydraulic transmission failure. The vehicle completely lost forward propulsion when placed in Drive mode, rendering it entirely immobile. When placed in Reverse gear, the transmission violently over-pressurized, causing the vehicle to suddenly surge and jump uncontrollably. Simultaneously, the dashboard displayed 6 critical safety system failures: 1. Check Engine — electronic control malfunction 2. Vehicle Stability Control System (VSC/TRAC) malfunction 3. Secondary Collision Brake System malfunction 4. Pre-Collision System malfunction 5. Parking Brake System malfunction 6. Advanced Ultrasonic Detecting and Ranging System malfunction Ourisman Toyota Chantilly (RO# XXX) has confirmed complete transmission failure. Fault codes found: P28167F — Pressure Control Solenoid H Actuator Stuck Off, P08BA7F — Pressure Control Solenoid L Actuator Stuck Off. Estimated repair cost: $11,347.42. While this failure fortunately occurred on a local road, had it occurred while merging onto I-66 or I-95 at highway speeds, it would have inevitably caused a catastrophic high-speed collision. This represents an extreme manufacturing defect and life-threatening safety hazard. Toyota Corporate Cases opened: #XXX (original case) and #XXX (full replacement request). I am requesting full vehicle replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2025 Toyota RAV4 XLE 4 door utility 2.5L 4 Cyl Gas A AWD unexpected sudden acceleration My safety as well as other vehicles and occupants as could have been at risk. National Transportation Safety Boaed has confirmed 57 cpmplaints of same issue. Vehicle determined total loss by insurance inspector, Va State Police. No warning lamps, messages, or other symptoms proir to the problem.

SUPPLEMENTAL TO COMPLAINT ID: 11728745. My 2025 RAV4 failed at 39,919 miles. Toyota Corporate is acting in bad faith to deny the 60,000-mile Powertrain Warranty. The Case Manager repeatedly calls only after 6:30 PM when the dealership is closed to avoid resolution. Furthermore, the representative is now using "legal threats"-directing me to their legal department-as a tactic to stop me from pursuing this valid warranty claim. This is a safety hazard and a violation of federal warranty law.

My 2025 Toyota RAV4 (39,919 miles) has a permanent "Check Engine" light. On March 18, 2026, diagnostic codes P24517F and P214502a were found, indicating a failure in the switching valve and fuel tank pressure sensor. Toyota USA and the dealer are refusing to honor the 60,000-mile Powertrain Warranty and Federal Emissions Warranty. I am reporting this as a safety defect because the vehicle may lose power or stall on the highway, creating an immediate crash risk. The manufacturer's refusal to repair a known emission/fuel defect in a new 2025 model has left me with an unsafe vehicle for over 15days.

I have owned this new vehicle for only approximately 2 months and have had at least 4 instances where the vehicle does not respond immediately to my foot on the accelerator when attempting to restart from a stop. Three times I was at a stop light and when I attempted to go as the light turned green there was no acceleration response from the gas pedal for a couple of seconds, and in two of the instances because I had my foot pressed far on the gas attempting to get power, there was a sudden acceleration and lurch forward. Most recently, on the fourth occasion I was turning out into traffic from a parking lot after being at a standstill and got no response and instead rolled slowly out in front of an oncoming car until after a few seconds the accelerator finally responded and I could go. I believe this is a safety risk as it could happen when I was attempting a left turn in traffic, which would subject me and my passengers/children to an extreme risk of being hit. I took the car into the dealership after the first two instances and they were not able to reproduce the incidents and offered no help. There are no warning lamps or indicators that appear when this occurs. The first incident occurred about three weeks into my ownership of the vehicle.

When remote starting the vehicle. The vehicle allows you to put the vehicle in gear from inside and turn off the parking brake allowing the vehicle to roll freely. The vehicle does shut off 1-2 seconds after but the vehicle is already in gear. To reproduce the defect you must remote start the vehicle using either the Toyota app or smart key fob. You then must be sitting in the vehicle once the vehicle is started you quickly depress the brake pedal shift into gear and turn off the parking brake quickly. The vehicle then shuts off while in gear allowing the vehicle to roll freely. This increases the risk of accident as the driver may not be in the vehicle and a child or other person may accidentally put the vehicle in gear while remote started. I believe this issue affects many other Toyota and Lexus vehicles as many share the same platforms and systems. You may contact me at my email address listed for more information or a video recording of the defect. Thanks.