2025 Toyota RAV4

SUPPLEMENTAL TO COMPLAINT ID: 11728745. My 2025 RAV4 failed at 39,919 miles. Toyota Corporate is acting in bad faith to deny the 60,000-mile Powertrain Warranty. The Case Manager repeatedly calls only after 6:30 PM when the dealership is closed to avoid resolution. Furthermore, the representative is now using "legal threats"-directing me to their legal department-as a tactic to stop me from pursuing this valid warranty claim. This is a safety hazard and a violation of federal warranty law.

My 2025 Toyota RAV4 (39,919 miles) has a permanent "Check Engine" light. On March 18, 2026, diagnostic codes P24517F and P214502a were found, indicating a failure in the switching valve and fuel tank pressure sensor. Toyota USA and the dealer are refusing to honor the 60,000-mile Powertrain Warranty and Federal Emissions Warranty. I am reporting this as a safety defect because the vehicle may lose power or stall on the highway, creating an immediate crash risk. The manufacturer's refusal to repair a known emission/fuel defect in a new 2025 model has left me with an unsafe vehicle for over 15days.

1)I purchased my car during daylight hours. A few days later I drove my car in the evening and could not see street signs or the road 1/3 of the way up through my windshield. There is a definitive line where the windshield turns black. It is extremely dangerous. The Toyota engagement center told me to take my car to the dealership where it was purchased. I also took photos of what I could not see while driving. The dealership said there is nothing they can do and this is normal. The engagement center called back after they received the photos and told me their head technician could not see the street signs looking at my photos either. I was told to take the car back again to the dealership and once again told " there is nothing that can be done." They told me to put on my automatic brights. This feature does not help. The dealership also told me I could just put on my brights manually. This blinds other drivers on the road and then they put on their brights driving towards me, which decreases my ability to see while driving. the Toyota engagement center dropped the ball after 3 months of trying to report how dangerous this situation is. I am now reaching out to your department because of serious safety issues. I did not buy a car to be placed in a dangerous situation where I can't see to drive at night up. It is very dangerous driving up and down hills. 2)I also want to report - most of the time my gas milage ranges between 18 - 22 mph. This is way below the stats that were given to me when the car was purchased. 3)The phone table does not charge my phone and is a complete fail. 4)The visors are too short and hardly serve a purpose.

Check engine light came on as well as hybrid malfunction message. While on the highway could not accel or go past 60 mph, gas pedal would then not work and speed went down, I pulled car over to breakdown lane and car abruptly stopped and would not move. Many warnings flashed and car needed to be towed. Temperature rose and ignition messages came up, steering wheel locked and car was not drivable.