2023 Toyota RAV4

The contact owns a 2023 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 25V595000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the instrument panel failed to display critical safety information. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 21,000.

My wife was going at about 10 - 15 mph coming up about 2 car lengths to a small curve in a residential area when all of a sudden she heard a pop or snap and the Rav4 went to a super high speed by itself. The acceleration could not be stopped even though she had her feet on the brakes. She had both hands on the steering wheel to avoid hitting a house and ended up going through a wall in the yard. There were no warning sounds and no signals indicating a problem. it appeared that the display was blank. There was no pre-collision warning or braking except as my wife was pushing on the brakes. She also hit the right side into side wall. No air bags deployed even though Windshield and all door glass on sides shattered. My wife the driver was okay and not hurt, and the grandchild in the car seat behind my wife was fine also. Neither had injuries. There were checked by emt. The police looked but all would not try to get in except to remove my granddaughter. My wife was removed also because she could not get out the door was jammed against shed and rock, and handles broken off This happened after the recall work was done by toyota dealer on 12/04/2025. There were no problems prior to the recall. I've listed the recall below. 25TD01 Rear Traction Motor Cable Corrosion - Multiple Model & Model Year Toyota Hybrid (AWD) Vehicles NHTSA Recall ID AWAITING# Recall Date Dealer Reference ID 25TD01 Description The subject vehicles are equipped with a rear motor unit and an HV Floor Under Wire that provide high voltage to operate the motor. Mud, water, or road salt could potentially enter the HV Floor Underwire connector housing and could cause corrosion over time. Excessive corrosion could cause AM Radio Static during certain driving cycles, or the vehicle may not start. Status Remedy Available Remedy Any authorized Toyota dealer will apply a wire harness protector seal to the HV Floor Under Wire Connector. Toyota corporate engagement is looking into this.

I purchased my 2023 Toyota RAV4 new back on March 13,2023. 10 days later on March 23 it was raining as I pulled into BJ’s parking lot, I parked and began fumbling around getting my bag and keys together when my car started shaking and sputtering eventually shutting down with an error message engine stopped steering power low. After a call to the salesman I was able to get my car restarted after 15minutes and many failed attempts. Car was bought back to service the following week and I was told car was not properly programmed at delivery, it was now programmed correctly and this should not happen again. April 17,2023 my son pulling into Tractor supply , raining out, pulls into spot and car again shakes, sputters and shuts off, same message engine stopped steering power low. After many attempts car restarts approximately 20 minutes later. Car serviced codes ARE FOUND and cleared, road tested and told car was ok. May 31,2025 I was driving down Rt 80, pouring rain when traffic comes to a complete stop due to accident ahead. Car starts shaking, sputtering and shuts down. Same message code as always. I turned the car completely off as not to kill battery and started to goggle the RAV4. I attempted to restart the car numerous times. Called for a tow, prayed that I didn’t get killed once traffic started to move. Finally 1-1/2 hours later it started. Traffic began moving 15 minutes after I got it started. Took in for service, charged $199.61 only to be told there were no codes. Problem could not be duplicated and in the future to always disable the start/stop button while using the vehicle. October30, 2025 raining, I stopped at Panera drive thru. Placed an order waiting in line and car shuts down, same error code, couldn’t restart car for 20 minutes. Took to Toyota November 5th same response no codes and cannot replicate issue, car is ok. Please help rectify this before someone gets killed!

Vehicle shows multiple safety systems malfunction and display warning messages. The vehicle displays repeated alerts including LTA (Lane Tracing Assist) Malfunction, Pre-Collision System Malfunction, RSA (Road Sign Assist) Malfunction, and Headlight System Malfunction. These warnings occur while the vehicle is in motion or parking and cause the safety features to shut off unexpectedly.

The contact owns a 2023 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the passenger’s side blind spot warning system located on the exterior side mirror failed to function as intended. The light flashed on the side mirror; however, the beeping sound was inaudible. No warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. The contact stated that the failure had occurred the same month the vehicle was purchased. The manufacturer was notified of the failure. The failure mileage was approximately 20.

We discovered severe mold contamination and water intrusion in our 2023 Toyota RAV4 Hybrid. My wife, our [XXX] child, and I have been experiencing dizziness and nausea for months whenever we were inside the vehicle, but we did not know the cause until the dealer (DLL) showed us extensive mold throughout the cabin and standing water trapped inside the vehicle. The dealer confirmed that this was not normal wear and tear. The mold has spread into the floors, interior panels, and even the steering components. This is a serious health hazard. After doing research, we found many other RAV4 Hybrid owners reporting similar water leaks and mold growth issues. This raises the concern of a potential design or sealing defect in this model. This vehicle is unsafe to drive, especially with a young child. We are requesting a full safety investigation into the water intrusion, sealing integrity, and air quality risks associated with this model. Symptoms:     •    Dizziness     •    Nausea     •    Headache     •    Strong mold smell     •    Corrosion of interior components This is a serious safety and health issue, and we are asking NHTSA to investigate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving or idling, the pre-collusion, RSA malfunction, Headlight system malfunction, and LTA system malfunction will go off as well as my navigation on my screen. Its been going on and off for 7 months now. It works, then it doesn't. I don't want to take it in because I know they're famous for making me pay high dollar fees for anything and everything. Toyota is horrible for their services and just want the money. I never had any issues with my car until I got a nail in my tire that was an easy fix (that they also wanted to keep my car overnight for a patch).

Faulty instrument panel keeps going on and off. It will reset itself and then do it again like it’s trying to fix itself. But then we’ll go on and off again it’s been doing it for about six months now we’ve been putting off by telling someone because we thought it might straighten up and when we keep looking up recalls, it says there’s no recall on it.

Vehicle: 2023 Toyota RAV4 Hybrid Issue: Persistent brake noise, safety hazard, manufacturer negligence I leased a 2023 Toyota RAV4 Hybrid from Clermont Toyota (Florida). Well before reaching 5,000 miles, the brakes began squealing and grinding, posing a potential safety hazard. Multiple service visits failed to correct the issue. Toyota Motor Sales, U.S.A., Inc. and its distributor, Southeast Toyota Distributors LLC, have long been aware of this defect, as documented in Technical Service Bulletin TSB-0001-22 and numerous NHTSA consumer reports describing similar brake failures and noises in 2019–2023 RAV4 models. Despite repeated notice, Toyota refused to repair or replace the defective vehicle and denied my Lemon Law claim through an arbitration panel connected to manufacturer counsel. This unresolved brake defect creates danger to the driver, passengers, and others on the road. Toyota’s continued sale and lease of vehicles with known braking issues constitute a serious public safety concern. I request that NHTSA investigate Toyota’s knowledge of these defects, evaluate the adequacy of its response, and consider a recall to protect consumers nationwide. Contact: [XXX] – [XXX] – [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)