2021 Toyota RAV4

Upon taking my 2021 Rav4 Hybrid in for the rear traction motor cable corrosion recall (25TD01) on 5/7/2026, I was told there are no parts, no estimated arrival time, and therefore not even a rough estimate for a timeframe of repair. I was told that no one would inspect or evaluate the part in question to indicate if the car was safe to drive. I expressed my extreme concern given the recall includes risk of power failure, even while driving. I received inconsistent, avoidant answers and an absolute denial to remedy the situation in any way. I was told the dealership is "Dolan" and not "Toyota". I again expressed my concerns about safety and the dealerships' denial to, at minimum inspect the recalled part and/or housing of the part. Emily, the Service manager stated that Toyota does not "allow" loaner vehicles for this particular recall. She could not provide any sources for this information. To summarize; the dealer with not provide an inspection of the recalled part and/or housing, or give an estimated timeline for repair given I am #125 on a waitlist. There is a complete lack of regard for mine or my children's safety as the dealer will not provide any assessment of how bad the damage could be. They suggested that I continue to drive the vehicle, acknowledging all of the safety hazards that could occur. I am terrified of the possibility of having an accident with my kids in the car due to this recalled part failing, not having a vehicle to get to and from work, and the potential additional costs that this unaddressed recall issue could cause. Please advise!

“Required Engine Maintenance- Visit Your Dealer” message came on the dash. After doing some research and troubleshooting; it appeared to be the coolant bypass valve that everyone has had issues with. The problem was then confirmed with a local provider who instructed us to contact the dealer to see if they’d cover the repair. Otherwise the repair by them would be $700. Toyota customer service told us that there is no TSB or Recall for this issue. We would need to have the issue diagnosed and then pay out of pocket for the repair. This is an issue that spreads throughout so many vehicles that it needs to be a recall.

The coolant bypass valve failed and the car is a 2021 Rav 4 LE. I called Toyota and according to the VIN it is not covered for this type of repair. I see quite a few cars have had this same issue, all Toyota's. It was inspected and repaired at a local Toyota Dealership but I had to pay out of pocket for the repair. There was a brief warning light that said "Engine Maintenance Required" See dealership or some such thing. Of course it's a safety issue if the coolant valve bypass failure causes the car to overheat.

I have a 2021 TYTA RAV4 HYBRID XLE PREMIUM AWD, the driver seat is very slow moving forward and backwards twisting and preventing to fully go forward and backwards. I need to get out and in of my vehicle. So I have to move in back and forth to get out and move it forward to see over the dash board. I am concerned it makes a load noise. What if it fails to move. This is a critical danger to me the driver. I have passengers to consider. This is absolutely unsafe. This is allowed? Where is the recall? This is unlike Toyota to do nothing. I have platinum coverage purchased at time of purchase of this brand new vehicle on 12/31/2021. Apparently, it causes it other damage to other components and parts. There is alot of other components and parts under the front driver seat. I went it to have it looked at on March 30, 2026. Service advisor states: They ordered the parts its a seat frame sub assembly with motor. $1785.92 Covered by platinum Coverage, not all the parts are covered that are damaged. it will cost me: $448.87 for components and parts damaged but are not covered plus labor for Shield (71812-0R140-C0) and Holder (7181B-0R010) After further investigation it is a symptom of a failed internal component within this assembly—most commonly a stripped plastic gear or a bent drive shaft. So looking it up many Toyota Brand owners are experiencing the same thing and are having to replace other parts caused by this. This is a dangerous situation for me and others. What if it fails to move forward or reverse or motor stops? A partial repair is unacceptable. Leaving damaged trim and holders creates a risk of wire-chaffing and further mechanical stress on the new assembly. For the safety of the driver and the longevity of the vehicle, the repair must be 100% complete. This would be out of pocket monies families don't have. $2,234.79 total repair cost acts as a "safety tax" that prevents families from fixing this critical defect. I can not afford: $448.