2021 Toyota RAV4

The contact owns a 2021 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the front driver’s seat became stuck. No warning lights were illuminated. The failure reoccurred on several occasions. The contact stated that water was leaking into the vehicle from the front driver’s and passenger sides, causing puddles of water in the front driver’s and passenger’s seats with an abnormal odor. The contact stated that the leak was near the bolts and screws. The failure reoccurred on several occasions. The vehicle was taken to an independent mechanic, who advised that the water leak could not be repaired and that the condition was unsafe. The vehicle was not repaired. The vehicle was taken to a dealer where it was diagnosed and determined that the A/C system and several other unknown components needed to be replaced. The dealer stated that the vehicle was out of warranty. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

My 2021 Toyota RAV4 Hybrid exhibits significant vibration in both exterior rear-view mirrors beginning at approximately 30 MPH, worsening at highway speeds of 50–70 MPH. Toyota has acknowledged this as a known manufacturing defect via TSB T-SB-0079-20, which identifies the original mirror mounting studs and reinforcement brackets as inadequate from the factory. The condition was confirmed by my local Toyota dealership, who verified TSB applicability but declined to cover the repair due to my vehicle being outside the 36-month/36,000-mile warranty window. I am currently at 127,000 miles. The safety risk is active and ongoing. Constant mirror vibration creates two compounding hazards: it directly distorts rear visibility, and it conditions the driver to mentally filter out mirror movement as background noise. This habituation means a motorcyclist or small vehicle appearing in the mirror may not register as a distinct threat. The component is available for inspection upon request. No warning lamps accompany this condition. The vibration has been present since early ownership and has not improved over time.

The contact owns a 2021 Toyota Rav4. The contact stated while driving 65 MPH, the contact heard a loud bang and then heard wind entering the cabin of the vehicle. The contact stated that the sunroof had shattered without impact. Neither an independent mechanic nor a dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be inspected or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 56,413.

The outer rear-view mirrors on my 2021 Toyota RAV4 vibrate all times, and excessively at highway speeds (approximately 50–70 mph), creating a shaky and distorted image of surrounding vehicles. This failure of the mirror mounting system makes it difficult to accurately judge the position and speed of other cars when changing lanes, merging, or reacting to traffic. The mirrors remain installed on my vehicle and are available for inspection. This issue poses a serious safety hazard. Because the mirrors do not provide a stable, undistorted view, my ability to monitor blind spots and adjacent lanes is compromised, putting myself, my passengers, and others on the road at increased risk of collision. The problem has been reproduced and confirmed by Toyota through Technical Service Bulletin T-SB-0079-20, which instructs dealers to install longer mounting studs, reinforcement brackets, and bonding adhesive to correct the defect. Toyota currently limits the repair to vehicles under the 3-year/36,000-mile warranty, leaving many unsafe vehicles unrepaired. I recently purchased the vehicle outside the warranty coverage. There were no dashboard warning lights or system messages to indicate the defect. The only symptom is the visible vibration of the mirrors, which first appeared shortly after purchase and persists across normal driving conditions. Because the defect directly impacts driver visibility and compliance with FMVSS 111, I believe this should be escalated from a Technical Service Bulletin to a mandatory safety recall.

The side mirrors shake heavily especially on highways. It puts my safety at risk and others as I am unable to properly focus on the road ahead of me when I am trying to clearly see if there are cars behind me while I am changing lanes. It causes me to take extra time looking at the mirror that I shouldn't have to in order to change lanes safely. This is a known issue and a Technical Service Bulletin has been created for it, but it requires a payment of over $1,000 to fix when this is an issue caused by the maker of the vehicle. It has been inspected by the maker at a dealership and was agreed that the issue I am facing aligns with the TSB. There were no warnings, as it has been noticed to have gotten worse in the last couple of months.

The contact owns a 2021 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the contact stated that the front driver’s side window became inoperable. The contact stated that the power button would not function properly, and the contact could not get the front window off track. The vehicle was taken back to the dealer, where it was diagnosed that the window regulator had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 32,804.

The sideview mirrors vibrate - the part that vibrates is the actual glass inside. I have read that many other 2021 RAV4 owners have complained about the same issue. The car was taken to a Toyota dealership and they reported not being able to locate a repair kit for this issue. The vibration makes it difficult to use the mirrors when driving at higher speeds on the interstate. It puts myself and others at risk because it makes it more challenging to safely change lanes.

Purchased a 2021 Toyota Rav4 Limited and the side mirrors vibrate while driving to the point it is unsafe to use them as their intended purpose. Nationally, Toyota seems to have acknowledged the problem via T-SB-0079-20 and only covers them on vehicles with 36k miles or 36,000 miles. Our vehicle was on the dealer lot for a year and the coverage for this TSB expired in February 2024 and has over 36k miles so my local dealer has told me it does not qualify to be repaired but recognized that the issues meets the issues described in the above TSB. My complaint is that it should be made a recall and should not be something only quietly covered. No engine or warning lights to indicate this issue and no public notice from Toyota. I only discovered this TSB via online forums, Facebook groups, and reddit groups dedicated to this 2019+ model years of the Rav4 and this seems to be a rampant issue that Toyota does not want to tell people about!

The contact owns a 2021 Toyota Rav4. The contact stated that while her husband was driving approximately 75 MPH, there was an abnormally loud booming sound heard. After stopping to inspect the vehicle it was discovered that the glass sunroof had exploded. The contact stated that during the failure, there was no other vehicles or objects were nearby. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet contacted. The failure mileage was 50,000. Repairs were made but the contact paid out of pocket for them. Their claim for reimbursement from the manufacturer was denied due to there being no evidence of a factory defect or an outstanding recall.