2021 Toyota RAV4

2021 Toyota RAV4 gas XXX Vehicle suddenly stopped while driving Busy roadway in [XXX] Wife and young children were passengers Dashboard displayed “ENGINE STOPPED” Dashboard displayed “STEERING POWER LOW” Police responded Police determined waiting for the insurance tow was unsafe Police arranged emergency towing Vehicle subsequently inspected by Beaver Toyota Dealer drove approximately 26 miles attempting to reproduce the issue No fault code/history found Problem could not be reproduced You remain concerned about a potentially recurring safety defect INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2021 Toyota RAV4 (gas model) has experienced a sudden, unexpected engine stall/shutdown on a public road. The incident occurred while shifting into Drive after backing up in reverse. The engine immediately died without any prior dashboard warning lights or mechanical symptoms. The information screen displayed a message stating "Put Car in Park" or "Shift into Park." The vehicle safely restarted immediately after shifting back into Park and pressing the ignition button. This intermittent stall has happened three times under the exact same directional shifting conditions over the last 1.5 years, creating a high-risk scenario for a rear-end collision in active traffic. After previous incident (one year ago) when the engine stopped when shifting from reverse to drive, I took it to Toyota service. Dealership diagnostics could not previously replicate the issue due to its intermittent nature and the absence of a permanent check engine code. checked battery and performed health check.

The contact owns a 2021 Toyota Rav4. The contact stated that while driving at approximately 30 MPH, the vehicle aggressively accelerated while the accelerator pedal was depressed. No warning light was illuminated. The vehicle was taken to a local dealer and remained with the dealer for additional diagnostic tests. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.

My 2021 Toyota RAV4 began experiencing intermittent shuddering and vibration at low speeds around May 2026. The condition occurred while accelerating from a stop or at slow speeds and became more frequent over time. Because the problem was intermittent, the dealership was initially unable to duplicate it. Independent inspection later found dark transmission fluid containing metal debris, indicating internal transmission failure. I was informed the transmission requires replacement or rebuild. My vehicle has approximately 94,000 miles, which is well below the expected service life of a modern transmission. The symptoms are consistent with numerous reported complaints involving Toyota’s UA80 automatic transmission and torque converter. An unexpected loss of smooth power delivery or hesitation during acceleration creates a potential safety risk, particularly when entering traffic or crossing intersections. I am submitting this complaint so NHTSA can investigate as this is a very dangerous and concearning issue.

Upon taking my 2021 Rav4 Hybrid in for the rear traction motor cable corrosion recall (25TD01) on 5/7/2026, I was told there are no parts, no estimated arrival time, and therefore not even a rough estimate for a timeframe of repair. I was told that no one would inspect or evaluate the part in question to indicate if the car was safe to drive. I expressed my extreme concern given the recall includes risk of power failure, even while driving. I received inconsistent, avoidant answers and an absolute denial to remedy the situation in any way. I was told the dealership is "Dolan" and not "Toyota". I again expressed my concerns about safety and the dealerships' denial to, at minimum inspect the recalled part and/or housing of the part. Emily, the Service manager stated that Toyota does not "allow" loaner vehicles for this particular recall. She could not provide any sources for this information. To summarize; the dealer with not provide an inspection of the recalled part and/or housing, or give an estimated timeline for repair given I am #125 on a waitlist. There is a complete lack of regard for mine or my children's safety as the dealer will not provide any assessment of how bad the damage could be. They suggested that I continue to drive the vehicle, acknowledging all of the safety hazards that could occur. I am terrified of the possibility of having an accident with my kids in the car due to this recalled part failing, not having a vehicle to get to and from work, and the potential additional costs that this unaddressed recall issue could cause. Please advise!

“Required Engine Maintenance- Visit Your Dealer” message came on the dash. After doing some research and troubleshooting; it appeared to be the coolant bypass valve that everyone has had issues with. The problem was then confirmed with a local provider who instructed us to contact the dealer to see if they’d cover the repair. Otherwise the repair by them would be $700. Toyota customer service told us that there is no TSB or Recall for this issue. We would need to have the issue diagnosed and then pay out of pocket for the repair. This is an issue that spreads throughout so many vehicles that it needs to be a recall.

The coolant bypass valve failed and the car is a 2021 Rav 4 LE. I called Toyota and according to the VIN it is not covered for this type of repair. I see quite a few cars have had this same issue, all Toyota's. It was inspected and repaired at a local Toyota Dealership but I had to pay out of pocket for the repair. There was a brief warning light that said "Engine Maintenance Required" See dealership or some such thing. Of course it's a safety issue if the coolant valve bypass failure causes the car to overheat.

While driving at highway speeds (approx. 65 MPH), the vehicle suffered a sudden and catastrophic loss of motive power. The "Hybrid System Malfunction" warning illuminated, followed immediately by a "Check Engine" light. The vehicle entered a fail-safe mode, then completely shut down. The steering wheel locked, making it extremely difficult to maneuver the vehicle to the shoulder in a dark, remote area with freezing temperatures. This presented an immediate life-safety risk to all occupants. Following the incident, the vehicle was presented to two separate authorized Toyota dealerships in the US for emergency assistance. Both failed to provide the standard of care required for a high-voltage safety failure. The first dealer refused to perform even a basic safety inspection or intake the vehicle, stating they had no hybrid technicians on weekends. They turned the vehicle away without safety warnings, forcing the operation of a chemically failing vehicle on public roads. The second dealer attempted to charge a diagnostic fee. However, when questioned, they admitted they also did not have a hybrid-certified technician on site. They attempted to bill for a diagnostic service they knowingly could not perform. This fraudulent charge was only rescinded after it was challenged. They subsequently refused further assistance, leaving the occupants stranded. The vehicle was eventually towed to a third dealer (in Canada) where it was diagnosed with severe corrosion of the High-Voltage Floor Under Wire Harness (MGR Cable), a known defect. The dealer confirmed the rear motor cable was corroded and required replacement. The repair involved replacing the cable and installing a "splash guard" cap. No prior warning signs occurred before the sudden highway shutdown. This failure is a result of the manufacturer's failure to adequately seal high-voltage components against corrosion and the dealer network's gross negligence in refusing emergency safety support.

The contact owns a 2021 Toyota Rav4. The contact stated that while her daughter was dropping her off, the daughter shifted to park(P), and the vehicle made an abnormal static sound. The contact stated that the failure recurred upon shifting to drive(D). There was no warning light illuminated. Additionally, the contact stated that there was an abnormal sound coming from the engine. An independent auto electrician was contacted and informed the contact that the abnormal sounds could be related to an engine failure; however, the vehicle was not diagnosed or repaired. The vehicle was taken to the dealer, where the contact was informed that no failure was found. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 67,314.