Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1600–25K
1725–50K
850–75K
175–100K
7100–150K
2150K+
195 reports with mileage · 439 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 180 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports5 fire reports11 injury reports
What owners actually said
634 reports
Mileage unknown · Jan 4, 2024
Engine
Vehicle displayed Engine Maintenance Required light at 54,000 miles. As issue was described from dealer, "Engine code was P268115 for an engine coolant bypass valve circuit short to battery or open. Found Coolant valve intermittently sticking." Was told by technician that if the part was not replaced, the issue could lead to eng…
Read full complaint
Vehicle displayed Engine Maintenance Required light at 54,000 miles. As issue was described from dealer, "Engine code was P268115 for an engine coolant bypass valve circuit short to battery or open. Found Coolant valve intermittently sticking." Was told by technician that if the part was not replaced, the issue could lead to engine overheating and that after they made the fix, they were going to check to see if a gasket was possible blown from the issue resulting from overheating that may have gone overlooked.
NHTSA ODI #11563563
Mileage unknown · Dec 30, 2023
Engine
Engine bypass coolant valve… Engine maintenance required pops up intermittently. Per dealer there is a short circuit in valve/ bypass part. The dealer had already known this was issue prior to car being diagnosed. They stated they are aware and this is a known issue.
NHTSA ODI #11562783
Mileage unknown · Dec 19, 2023
Engine
2020 RAV4 with 47,589 miles. The engine maintenance light came on. It turns off once I shut off the vehicle and start it up again. It only comes back on when I put the air conditioner or heater on. I was told it's the heater control valve/coolant bypass valve and would cost around $900+ to repair. I did some research and see tha…
Read full complaint
2020 RAV4 with 47,589 miles. The engine maintenance light came on. It turns off once I shut off the vehicle and start it up again. It only comes back on when I put the air conditioner or heater on. I was told it's the heater control valve/coolant bypass valve and would cost around $900+ to repair. I did some research and see that this problem is occurring alot.
NHTSA ODI #11560982
Mileage unknown · Dec 7, 2023
Engine
Coolant bypass valve failed vehicle warning lights came on for this 2020 Toyota Rav4 at 31,641 miles. This is absolutely available for inspection on request. Safety as this can potentially cause overheating, coolant leaking, a cracked cylinder. The manufacturer (Local Toyota dealership - "Ed Morse Delray Toyota" inspected an…
Read full complaint
Coolant bypass valve failed vehicle warning lights came on for this 2020 Toyota Rav4 at 31,641 miles. This is absolutely available for inspection on request. Safety as this can potentially cause overheating, coolant leaking, a cracked cylinder. The manufacturer (Local Toyota dealership - "Ed Morse Delray Toyota" inspected and suggested replacement of the coolant bypass valve for this 2020 toyota rav4 for a price around 800$. the technician say they see a load of these newer model Rav4's needing new coolant bypass valves. I opted not to immediately replace the valve due to it being a vehicle model-wide issue that should likely be a recall. These appeared the day before I brought it in to the dealer so withing 5-10 miles of the 31,641 miles for this 2020 Toyota Rav4. Warning just says "error please take in to dealership for service".
NHTSA ODI #11558972
Mileage unknown · Dec 4, 2023
Electrical SystemUnknown Or Other
Engine bypass valve sensor is faulty. Many users have reported this past 40k miles on RAV4 2019-2021
NHTSA ODI #11558462
Mileage unknown · Dec 2, 2023
Electrical System
2020 RAV4 hybrid. Vehicle doesn't start; requires a jump, which is inconvenient or unsafe, depending on where it happens. Intermittent occurrence, ~ 3 times/year. Toyota checked 12V battery, pronounced OK, of course the car was driven to the shop for the check, so was operating at the time. I've checked the battery when the …
Read full complaint
2020 RAV4 hybrid. Vehicle doesn't start; requires a jump, which is inconvenient or unsafe, depending on where it happens. Intermittent occurrence, ~ 3 times/year. Toyota checked 12V battery, pronounced OK, of course the car was driven to the shop for the check, so was operating at the time. I've checked the battery when the car wouldn't start and found it to be a little low (11.5V) but by no means fully discharged. Not associated with leaving components on (we are careful to turn everything off) or weather; the vehicle is garaged in the winter. I turned off the "Bluetooth" system which we never used and haven't had this issue over the past year. Suspect that the "Bluetooth" system was operating even when the vehicle was off?
NHTSA ODI #11558087
Mileage unknown · Nov 30, 2023
Unknown Or Other
Coolant bypass valve less than 40k miles and there is hundreds of them going bad this needs to be a recall issue
NHTSA ODI #11557699
Mileage unknown · Nov 22, 2023
Engine
My coolant bypass valve in the engine malfunctioned and shorted at a mere 27,300 miles on the vehicle and I had to bring it into the dealership to be replaced. A coolant bypass valve failing or malfunctioning can cause the engine to overheat, catch fire, or cause complete seizure. Can also cause the vehicle to stall and possibly…
Read full complaint
My coolant bypass valve in the engine malfunctioned and shorted at a mere 27,300 miles on the vehicle and I had to bring it into the dealership to be replaced. A coolant bypass valve failing or malfunctioning can cause the engine to overheat, catch fire, or cause complete seizure. Can also cause the vehicle to stall and possibly cause a crash or wreck. Toyota has acknowledged the problem in the RAV4’s but no recalls have been issued. Dealer knew exactly what the problem was when I mentioned that the ‘engine maintenance required’ light came up on my dashboard BEFORE mechanic diagnosed it and confirmed which tells me they are aware of the issue in these cars.
NHTSA ODI #11556456
Mileage unknown · Nov 21, 2023
Engine
In September 12,2023 I took my 2020 Toyota Rava 4 vehicle in to Cobb Toyota for a coolant by pass valve to be replaced after my check engine light kept coming on. I only had 25 790 miles on my vehicle at the time. Anthony Sullivan was my service rep. at the time And he stated that this something has been common with this type of…
Read full complaint
In September 12,2023 I took my 2020 Toyota Rava 4 vehicle in to Cobb Toyota for a coolant by pass valve to be replaced after my check engine light kept coming on. I only had 25 790 miles on my vehicle at the time. Anthony Sullivan was my service rep. at the time And he stated that this something has been common with this type of vehicle. But could not explain why. I just wanted to report this to Toyota. They need to know about this. And I need to be reimbursed for $99.30 for what I paid for this repair under warranty. Thank you,
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.
Consequence & remedy
Consequence: An air bag that does not deploy during a crash increases the risk of injury.
Remedy: Dealers will inspect and replace the sensor as necessary, free of charge. Interim letters notifying owners of the safety risk were mailed in February 2024. Some final remedy owner letters were mailed October 31, 2024. Letters will continue to be mailed in phases through January 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB15/23TA15 Lexus 23LB03/23LA03.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Additional source detail variants (2)
Air Bags:frontal
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Steering:column
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence & remedy
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence & remedy
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗