2011 Toyota RAV4

TL* THE CONTACT OWNS A 2011 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DECELERATING FOR A TRAFFIC STOP, THE ENGINE RPMS BEGIN TO RACE, CAUSING THE VEHICLE TO ACCELERATE INDEPENDENTLY. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL AND BEGAN TO SMELL SMOKE. THE VEHICLE WAS TURNED OFF AND TOWED TO A DEALER. THE DEALER STATED THAT THEY COULD NOT REPLICATE THE FAILURE NOR FIND A PROBLEM. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT THAT THERE WAS NO HISTORY OF SUDDEN ACCELERATION WITH THE MODEL VEHICLE AND OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 10,500.

I WOULD LIKE TO NOTIFY THE INCIDENT, ON JULY 11TH 2012 I WAS DRIVING ON I-40 W HIGHWAY AT 65 MPH SPEED, THE RAVA 4 VEHICLE SIDE AIR BAG (DRIVER SIDE) COMPARTMENT OPENED BUT AIR BAGS NOT DEPLOYED, IT'S LOOK LIKE A MANUFACTURER ASSEMBLY ISSUE, I WOULD LIKE TO SHARE THIS INCIDENT WITH YOU, THIS MAY LEAD SERIOUS INJURY OR ACCIDENT ON ROAD WAYS. MY OBSERVATIONS : NO PATH HOLES, NO ACCIDENT, IT HAPPENED JUST LIKE THAT. I TOOK MY VEHICLE TO TOYOTA DEALER, THE DEALER REPLACED SIDE AIR BAG PANEL WITH NEW ONE. *TR

PROBLEM 1 - I HAVE BRAKE NOISE AND BRAKE DOES NOT STOP PROPERLY. SPOKE TO TOYOTA DEALER AND THEN CREATED A CASE NUMBER WITH TOYOTA CUSTOMER EXPERIENCE. TOYOTA VERIFIED AND THEY SAY NO PROBLEM IN BRAKE. WHAT TOYOTA SAYS AFTER INSPECTION - *INSPECT BRAKE LININGS AND CHECK PARKING BRAKE ADJUSTMENT ~|~*INSPECT BRAKE LININGS AND CHECK PARKING BRAKE ADJUSTMENT ~|~ ~|~COULD NOT VERIFY BRAKE NOISE.FRONT BRAKES HAVE 5 MM REMAINING AND REAR BRAKES STILL HAVE 7 MM.ALL GOOD AND NO TSB PERTAINING PROBLEM 2 - THE VEHICLE HAS A WIND LIKE NOISE WHEN DRIVING THE FREEWAY, WHICH TOYOTA SAYS THEY FIXED AND THE PROBLEM WAS "SECURE LOOSE ROOF RACK BAR". *TR

THERE IS A HESITATION AT LOW SPEEDS, CAUSING ENGINE TO INTERMITTENTLY LOOSE POWER FOR 1.5-2.5 SECONDS. THIS IS AN EXTREMELY DANGEROUS WHEN ACCELERATING ONTO INTERSTATE HIGHWAYS WHERE CARS GOING IN THE SAME DIRECTION ARE ALREADY TRAVELING 70-75 M.P.H. AND WHERE MAKING TURNS AT INTERSECTIONS WITH ONCOMING TRAFFIC AND OTHER SITUATIONS WHERE POWER IS NECESSARY TO AVOID A COLLISION. THIS CONDITION HAS ALREADY RESULTED IN SEVERAL NEAR MISS ACCIDENTS MAKING THE VEHICLE UNSAFE AND NOT SUITABLE FOR NORMAL DRIVING. THIS HESITATION ALSO SEEMS TO BE NOTED IN THE RELATED NHTSA REPORT EXAMINING THE TOYOTA ELECTRONIC THROTTLE CONTROL THAT MAY HAVE RESULTED IN UNINTENTIONAL ACCELERATION AND AT THE TOYOTA DEALER WHERE THE CAR HAS BEEN SERVICED, THEY HAVE ADVISED ME THAT I AM NOT THE ONLY ONE COMPLAINING ABOUT THIS ISSUE. THE PROBLEM SEEMS TO BE ONE THAT DOES INVOLVE THE PROGRAMMING OF THE ETC AND SELECTION OF A FORWARD GEAR. *TR

THE THIRD ROW SEAT HEADRESTS ONLY HAVE TWO POSITIONS.(ALL THE WAY UP OR ALL THE WAY DOWN) NEITHER COVERS THE HEAD OF A CHILD. IN THE DOWN POSITION MY CHILD'S HEAD IS ABOVE THE HEADREST. IN THE UP POSITION, HIS HEAD IS BETWEEN THE TWO METAL BARS. THE THIRD ROW SEATS ARE VERY TIGHT AND CERTAINLY NOT DESIGNED TO HOLD ADULTS COMFORTABLY. HOWEVER THE HEADRESTS ONLY FIT AN ADULT SIZE BODY. *JS

I HAVE A SERIOUS CONCERN OVER THE DESIGN OF THE BRAKE AND GAS PEDAL WIDTH ON MY 2011 TOYOTA RAV. MY PROBLEM IS THAT MY DRESS SHOES AND RECREATION BOOTS ARE GETTING CAUGHT ON THE BRAKE PEDAL WHEN I SWIVEL FROM THE GAS TO THE BRAKE PEDAL. ON MULTIPLE OCCASIONS, I CAME CLOSE TO SERIOUS ACCIDENTS. I AVOIDED THE ACCIDENTS BY QUICKLY SLIDING MY RIGHT FOOT TO THE RIGHT AND COMPLETELY LIFTING MY FOOT UP AND OVER TO THE BRAKE PEDAL. DURING ONE OF THESE MANEUVERS, MOVING MY RIGHT FOOT QUICKLY TO THE RIGHT RESULTED IN THE LIP OF THE SOLE ON THE RIGHT SIDE HITTING THE GAS PEDAL AND CAUSING ACCELERATION OF THE VEHICLE. THIS PROBLEM DOES NOT OCCUR WHEN I WEAR SNEAKERS, AS THE SOLE OF THE SNEAKER DOES NOT HAVE AN APPROXIMATE HALF-INCH LIP ON THE SIDES. ALSO AND MOST IMPORTANT, I DRIVE A TOYOTA HIGHLANDER AND THIS PROBLEM DOES NOT HAPPEN. I ALSO DID NOT HAVE THIS PROBLEM WITH MY CAMRY, WHICH I TRADED IN FOR THE RAV. THE ABOVE VEHICLES HAS CLOSE TO A FIVE INCH WIDTH SEPARATION BETWEEN THE BRAKE AND GAS PEDALS. I'VE BROUGHT THIS TO THE ATTENTION OF MY TOYOTA DEALER AND THE MAINTENANCE MANAGER. THEY HAVE BEEN RESPONSIVE OF MY CONCERN, FORWARDING MY COMPLAINT TO THE AREA MAINTENANCE MANAGER. I MET WITH THE AREA MANAGER EXPLAINING THE PROBLEM. HE PROCEEDED TO TAKE PICTURES OF MY SHOES AND THE 3 INCH WIDTH BETWEEN THE BRAKE AND GAS PEDALS. THAT MEETING ENDED WITH THE AREA MANAGER OPENING A CASE AND THE PROMISE HE WOULD REFER MY PROBLEM TO HIS APPROPRIATE MANAGEMENT. TO DATE, MY CASE IS STILL WITH TOYOTA. MY LOCAL TOYOTA DEALER MAINTENANCE MANAGER HAS CONTACTED ME ADVISING THAT THE CASE IS BEING HANDLED AT A HIGHER LEVEL. *JS

I EXPERIENCED A SUDDEN VEHICLE ACCELERATION EVENT ON APRIL 6TH. I FOLLOWED TOYOTA'S INVESTIGATION PROCEDURE AND EVEN MET WITH A TECHNICAL EXPERT AND WE AGREE ON THE FOLLOWING POINTS: THE EVENT WOULD HAVE SHOWN UP AS TWO SEPARATE EVENTS IN THE ABS HISTORY QUEUE. AN INITIAL VSC EVENT (SUDDEN ACCELERATION) CLOSELY FOLLOWED BY THE ABS EVENT (MY PRESSING ON THE BRAKE PEDAL HARDER IN RESPONSE TO THE SUDDEN ACCELERATION) IF A CHECK OF THE ABS HISTORY QUEUE WOULD HAVE BEEN DONE IMMEDIATELY, BOTH EVENTS WOULD STILL HAVE BEEN STORED IN THE ABS HISTORY QUEUE. THE SMALL CAPACITY OF THE ABS HISTORY QUEUE, COUPLED WITH THE RECORDING OF MANY FREQUENT TRACTION CONTROL (TRAC) EVENTS PUSHED THE RECORD OF MY ABS- AND VSC EVENTS OUT OF THE ABS HISTORY QUEUE. THE ABS SYSTEM SHOULD NOT ENGAGE WHEN THE VEHICLE IS STOPPED OR MOVING SLOWLY AS IN MY INCIDENT. SO, THERE WAS A MALFUNCTION OF THE CONTROL SYSTEM THAT REMAINS UNRESOLVED. TOYOTA REFUSES TO ACKNOWLEDGE THE EXISTENCE OF THE PROBLEM. BECAUSE THE ABS SYSTEM SHOULD NOT HAVE ENGAGED WHEN THE VEHICLE WAS EITHER STOPPED OR MOVING SLOWLY, THERE IS ABSOLUTELY CLEAR EVIDENCE THAT THERE IS SOMETHING WRONG WITH MY VEHICLE. I THINK TOYOTA IS ENGAGED IN A COVER-UP REGARDING THE SUDDEN ACCELERATION PROBLEM. I REQUEST THAT THE US FEDERAL GOVERNMENT ORDER TOYOTA TO DO THE FOLLOWING SINCE THEY REFUSE TO DO IT VOLUNTARILY OR AT MY REQUEST: INCLUDE AN IMMEDIATE EXAMINATION OF THE ABS HISTORY QUEUE IN THE HEALTH CHECK. CREATE, AND INSTALL IN MY RAV4, A NEW VERSION OF ELECTRONIC CONTROL SOFTWARE THAT IMPLEMENTS THE FOLLOWING CHANGES: A.SEPARATE QUEUES FOR EACH FOR EACH OF THE THREE TYPES OF ABS HISTORY EVENTS: ABS, TRAC, AND VSC B.INCREASED ABS HISTORY QUEUE CAPACITY TO ENSURE THAT 90 DAYS OF EACH OF THE THREE TYPES OF EVENTS ARE STORED. C.ALL ABS HISTORY EVENTS ARE TIME-STAMPED AND DATE-STAMPED. *TT

TL* THE CONTACT OWNS A 2011 TOYOTA RAV4. THE CONTACT CRASHED INTO A VEHICLE THAT FAILED TO YIELD THE RIGHT OF WAY. THE CONTACT STATED THE AIR BAG FAILED TO PROTECT HIM WHEN THE IMPACT WAS HARDER THAN NORMAL AND CREATED A SMOKE THAT SMELLED LIKE FIRE. THE DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED, CAUSING THE PASSENGER INTERNAL BRUISING AND A CRACKED RIB. THE CONTACT RECEIVED INJURIES TO THE CHEST, WHICH CAUSED BREATHING DIFFICULTIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE 18,000.

THIS IS AN INCIDENT INVOLVING SUDDEN VEHICLE ACCELERATION. I WAS STOPPED WITH MY FOOT ON THE BRAKE IN THE WHERE GREAT MALL PARKWAY TURNS ONTO EASTBOUND MONTAGUE EXPWY IN MILPITAS, CA. DESPITE HAVING MY FOOT ON THE BRAKE, THE VEHICLE BEGAN TO CREEP FORWARD. I RESPONDED BY PRESSING THE BRAKE PEDAL HARDER. THIS CAUSED THE VEHICLE STABILITY CONTROL SYSTEM TO ENGAGE AND THE BRAKE PEDAL PUSHED THROUGH THE RESISTANCE POINT AS IS TYPICAL WHEN THE VEHICLE STABILITY CONTROL ENGAGES. THE VEHICLE BEGAN TO ACCELERATE SO I QUICKLY MOVED THE TRANSMISSION SELECTOR FROM DRIVE INTO PARK IN ORDER TO STOP THE VEHICLE. I REPORTED THE FAILURE TO TOYOTA MOTOR SALES USA AND THE COMPLAINT WAS ASSIGNED CASE NUMBER [XXX]. I FOLLOWED THE RECOMMENDED PROCEDURE OF HAVING THE VEHICLE INSPECTED BY THE LOCAL TOYOTA DEALER, PIERCEY TOYOTA, ON APRIL 13, 2012. THE SERVICE MANAGER COMPLETED AN INSPECTION AND SUBMITTED A REPORT TO TOYOTA TECHNICAL SERVICES. TODAY, MAY 2, 2012, I FOLLOWED UP WITH BOTH THE PIERCEY TOYOTA SERVICE MANAGER AND WITH TOYOTA MOTOR SALES. ANTHONY OF TOYOTA TOLD ME, ESSENTIALLY, THAT TOYOTA REFUSES TO ACKNOWLEDGE THE FAILURE AND REFUSES TO GIVE ME A FORMAL WRITTEN RESPONSE. ANTHONY CONTINUED BY SAYING THAT IF THIS RESPONSE WAS NOT SATISFACTORY TO ME, THEN I SHOULD GET AN OUTSIDE COUNSEL. I SUBMIT THAT THE SUDDEN UNINTENTIONAL ACCELERATION PROBLEM STILL EXISTS WITH TOYOTA--AT LEAST WITH MY VEHICLE--AND THAT IT NEEDS TO BE FIXED. IT IS MY OPINION THAT TOYOTA IS 'GIVING THE FINGER' TO THE PROBLEM AND TO THE UNITED STATES AND THAT TOYOTA'S FAILURE TO PROPERLY ADDRESS THE PROBLEM WILL LIKELY KILL INNOCENT PEOPLE IF TOYOTA DOES NOT FIND A REAL SOLUTION. I AM PREPARED TO SUBMIT MORE DOCUMENTS AND DETAILS REGARDING THIS INCIDENT AND THE PROBLEM. I WOULD LIKE TO BE PUT DIRECTLY IN TOUCH WITH AN OFFICER AT YOUR OFFICE SO THAT I CAN ENTER A FULL AND FORMAL COMPLAINT. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)