2021 Toyota Highlander

Vehicle: 2021 Toyota Highlander XSE Approximate Mileage: 92,000 Location: Boerne, TX (Texas Hill Country) ⸻ 🔧 Summary of the Problem: My vehicle experienced serious electrical failure after heavy rainfall in the Texas Hill Country, where catastrophic flooding recently occurred. At a red light, the dashboard began flashing, power windows stopped working, and the electronic parking brake would not disengage. I was nearly rear-ended with my children in the car because the vehicle temporarily lost responsiveness. ⸻ 💧 Pattern of Issue: This problem only occurs after rain. Once the vehicle dries out, the systems return to normal. Toyota tested the battery and alternator and found no faults. The dealership and Toyota Corporate have been notified, but they have so far refused to approve a Goodwill Repair or perform deeper inspection for water intrusion into the fuse box, firewall harness, or Body Control Module (BCM). ⸻ 🧩 Suspected Cause: I believe there is water intrusion due to a design flaw, likely through the windshield cowl or firewall. Other Highlander XSE owners have reported nearly identical symptoms following rain exposure. Toyota has issued service bulletins in the past about water reaching electrical components in other models. ⸻ 📣 Safety Concern: This is a serious safety issue. A near-crash involving my children occurred. If Toyota does not resolve this issue and it leads to an accident, I will hold them fully accountable. I am reporting this so it can be formally investigated and linked with similar complaints.

The contact owns a 2021 Toyota Highlander. The contact stated that while driving on the highway at 65 MPH, the front bumper became detached. There was no warning light illuminated. The contact pulled over and zip-tied the bumper to the frame of the vehicle. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V720000 (STRUCTURE); as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 47,330.

[XXX] [XXX] [XXX] [XXX] [XXX] Vin # [XXX] 2021 Toyota Highlander 4DR AWD XLE I am writing to report a potentially dangerous transmission defect in my 2021 Toyota Highlander XLE, at approx. 60-70k miles. The vehicle recently developed a high-pitched whining noise while accelerating, which a certified Toyota service technician suspects is internal to the transmission. This exact issue is outlined in Toyota Technical Service Bulletin T-SB-0008-21, issued February 9, 2021, for 2021 Highlanders equipped with the UA80E or UA80F 8-speed automatic transmission. According to the TSB, the cause is worn pinion shafts in the front carrier assembly, and the prescribed repair is complete transmission replacement. Unfortunately, my vehicle was just outside the 60,000-mile powertrain warranty window, despite experiencing the failure consistent with a known manufacturer defect. Numerous other owners have reported identical symptoms between 60,000–80,000 miles, often facing repair costs over $8,000 and multi-week delays due to part availability. This is not a typical wear-and-tear issue. A failure of the transmission at highway speeds or during critical maneuvers could lead to loss of power or control, posing a real safety risk to drivers and passengers. I respectfully urge the NHTSA to investigate this issue further. I am happy to provide: Thank you for your commitment to driver safety. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There is a known defect with transmissions in certain model years of Toyota cars, mine being one of them, per this TSB: [XXX] The transmission can catastrophically fail but Toyota will not replace the defective part unless the vehicle is still under warranty. I had the Toyota dealer verify that the transmission is beginning to fail and requires replacement. The transmission has begun to emit a "whining" noise. Should the transmission fail catastrophically during operation, it could cause a sudden loss of power, seize a drive wheel, or another event causing a loss of vehicle control. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Yesterday, as I do a couple times a month, I went to switch parking places, putting my 2021 Toyota Highlander where my 2007 Mazda was parked, in order to drive it and keep the battery from dying. After starting both cars I first moved the Mazda to make room for the Toyota. As I was slowly steering the Toyota at (idle speed) into the now vacant parking spot, the car accelerated on it's own, prompting me to hit the brakes, but to no avail. The car jumped the curb hitting, knocking over and and damaging a large ceramic planter and small tree in my neighbor's yard. My split second reaction upon having no brakes and a run away car was to push it out of drive, which ended up putting the car into reverse, causing a harsh jolt, followed by the car accelerating again on it's own, in reverse towards another neighbor's garage. I live in a condo complex, so all of this took place within about 30 feet of forward/backward/forward motion. My second split second decision (with no brakes) to avoid smashing into the garage was throwing it back into drive, which sent it accelerating back towards the parking place again. This time I had the presence of mind to push the power button on the dash, allowing me to barely come to stop before jumping the curb again. Whole thing lasted about 15 seconds. I had an appointment to attend, so after a brief conversation explaining to my (now outside) neighbor what happened, I left in the older car. Returning later in the day I found damage to the front of my Toyota and wonder if my transmission is damaged as well. I'm reimbursing my neighbor today. I've not attempted to drive the Toyota since, and am seeking your advice on how best to proceed, whether I should initiate contact with Toyota regarding this incident, or is that something you should initiate? Please advise. Thank you.