2021 Toyota Highlander

The transmission has a whining, grinding noise and occasional jerks vehicle. I had dealership look at the vehicle and they said it's a problem with this model but Toyota has not done a recall they issued a service bulletin. I was told it needs replacement but Toyota has been reluctant to work with owners outside of the service manufacturers warranty. This proved true, I was denied any goodwill assistance, and after several days of requesting why they denied any assistance, I'm not able to get an answer. This is a safety issue that they are aware of and not taking proper acceptance and assistance in rectifying. We carry our new born and toddler grandchildren in this vehicle as well as elderly parents. The thought of a total transmission failure on a busy highway or street is terrifying, I asked the dealership service manager about the safety of driving the vehicle and he recommended not operating it until it's replaced. In my[XXX] I haven't asked the government for anything, but I am asking you to look into this matter and if called for mandate a recall.. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Toyota Highlander Hybrid has a braking issue identified in Toyota Service Bulletin T-SB-0059-23, Hybrid Regenerative Brake Transition Feeling Improvement. When going downhill and applying the brake, the vehicle lurches forward temporarily as the braking system transitions from regenerative to hydraulic braking. The first time my vehicle did this, it was very alarming and I had to take additional measures to slow my vehicle as I was driving downhill. My vehicle frequently demonstrates this problem, however, I did not report it to my local Toyota dealer because I read in an online chat group that it was a characteristic of this vehicle. Although the TSB recommends a Reprogram of the Brake Actuator Assembly Control Module, the repair is only covered under the Toyota Basic Warranty which is in effect for 36 months or 36k miles, whichever occurs first. My vehicle is past the warranty limit, and because I did not report it to my dealer previously, this repair is not covered under the TSB or the Toyota Basic Warranty. Toyota Highlander Hybrid model years 2020-2022 are affected. The Technical Service Bulletin was issued August 29, 2023, so if a 2020 model Highlander Hybrid has this problem, 2020 models would have already passed the warranty limit by the time the TSB was issued and thus would not be covered. This is a safety risk as drivers can lose control of the vehicle when braking, particularly when going downhill. The Warranty should be extended, or this problem should be elevated to a RECALL so that older affected vehicles, or those with higher mileage can be covered under warranty. Drivers should not have to pay for a recognized problem that affects the safety of this vehicle and has been identified in a Technical Service Bulletin. This problem puts drivers at risk of losing control of the vehicle and the problem can be mediated with a software reprogram. T-SB-0059.23 should be elevated to a RECALL, or extended regardless of age or mileage.

My transmission started whining at 63,000 miles and my mechanic said it needs to be replaced. However, there is a nationwide backorder on Toyota transmissions. That should be a sign to NHTSA that this is a widespread issue and needs a recall! Of course this was right after the 60,000 mile Toyota warranty. I have extended warranty but it doesn't cover consultations or taxes.

I have a 2021 Toyota highlander platinum. The car makes whining noise when accelerating my car has 70k miles and according to Toyota my warranty expired at 60k miles it’s a common issue with these cars and Toyota knows that but they won’t help with the fix. This affected a lot of people and they want almost 11k for a trans replacement. If it’s a common issue with all their cars then they should take full responsibility and fix the cars. I hope you guys could be of help and hold they accountable.

My 2021 Toyota Highlander, purchased with 16k miles, has a leak in the AC system in the rear of the vehicle (as of May 2025, at 3 years 10 months into the vehicle's service, with 28k miles). This pipe runs the length of the car and costs $2000-$3000 to repair. This was confirmed at an independent service center that used leak detection dye to identify the problem. I am finding multiple reports of people having this problem in young Toyota vehicles (<4 years old) and with low miles. I believe this is a design flaw and not indicative of normal corrosion, as the vehicle does not exhibit corrosion elsewhere in the under carriage.

This is a supplemental complaint to add more detail to a prior submission. I am the original owner of a 2021 Toyota Highlander with 10,000 miles at the time of the issue worsening to the point that I finally broke down and was forced to pay the Toyota dealership's hefty diagnostic fee. The air conditioning system has failed due to a refrigerant leak in the rear A/C lines, specifically near the exhaust area under the vehicle. The dealership diagnosed the issue and quoted me over $3,000 to replace “all necessary components in the rear.” They offered no coverage or goodwill repair despite the vehicle’s age and mileage. Upon researching the issue for longer than a year at this point, I discovered far too many similar complaints from other Highlander owners (years 2019–2021) describing identical failures — typically rear A/C lines corroding, cracking, or leaking prematurely. In some cases, customers were told Toyota is aware of the issue but not issuing a TSB or recall. In other cases, dealers said no permanent fix exists. These repairs are prohibitively expensive and, in some reports, recurring due to poor line placement or dissimilar metal corrosion near heat sources. This significantly impacts safety in several ways: Impaired Visibility: The AC system is integral to effective defogging and defrosting of the windshield, especially in humid or cold conditions. Without it, visibility is severely compromised, increasing the risk of an accident. Driver Impairment: In extreme temperatures, lack of climate control can lead to driver fatigue, distraction, and reduced concentration, posing an indirect safety risk. I am reporting it to request NHTSA monitor the trend. This seems to reflect a possible engineering or design flaw, and the number of similar owner reports suggests it may warrant further review by Toyota and NHTSA. Customers should not be facing multi-thousand-dollar repairs on near-new vehicles with basic systems failing. Thank you for tracking this issue.

Premature AC refrigerant leak and failure in system in the 2021 Toyota Highlander due to corroded/defective rear AC lines located near the exhaust/spare tire, observed at very low mileage and upon official inspection at the nearest Toyota dealership. Noticed early in ownership and decided to have the vehicle scanned when air being released only continued to grow warmer in the sweltering summer months. Reporting due to advice from friends and owners in my exact situation with the very same issue as well as the pricey three-thousand dollars and upwards quote to have this work done from Curry Toyota, 3026 E Main St, Cortlandt, NY 10567. Vehicle purchased new to avoid these very issues.