2021 Toyota Highlander

whine when accelerating. toyota has released a tsb 0008-21 indicating to replace transmission due to incorrect installation of a retaining clip on a nut securing differential in place. Nut can Become loose and stuck in gears of internals of transmission causing transmission to lock up while driving. this will cause loss of power and could result in an accident. Toyota is aware of the issue but refuses to make repairs due to vehicle being outside of powertrain warranty. Toyota has extended warranty to 10 years on 2017 and 208 model years however the problem still exist in 2017-2024 model years with the same transmission UA80E/UA80F

When our vehicle reached about 70,500 miles (10,000 miles past when the powertrain warranty expired), the vehicle started making high-pitched whining noises when the gas pedal was depressed. We brought it to the Toyota dealership and were advised that the vehicle's transmission needed to be replaced and were quoted $9,700. This is for a vehicle that was only 4 years old!! We do not feel that this is a repair/issue that a consumer must bear the cost of! When we shared this with the Toyota technician, he stated that unfortunately, the Highlander's powertrain warranty expired at 60,000 miles. We understand that Toyota was aware of this issue and this should have been escalated as a NHTSA recall where the manufacturer should be responsible for the cost of repair and/or replacement, not the consumer. Please assist us with obtaining a satisfactory resolution with this.

The sunroof glass on our 2021 Highlander unexplainably shattered on our ride home on 7/20/25 at approximately 12:30PM. Sky was overcast, and the temperature was in the mid 80's. We had just entered the highway and were still accelerating to highway speed. We were not near a pedestrian overpass where a rock could have been tossed from above. Broken glass edges are pointing upward. The sunroof was in the fully closed position and not tilted. Safety would have been at extreme risk if we did not have the inner slide closed. The vehicle has not yet been inspected by the Toyota dealership or insurance.

The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 23V720000(Structure); however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I purchased a 2021 Toyota Highlander in June of 2024 with about 45k miles. The transmission completely failed at 67k miles, when I brought it in to have checked in April of 2024. This is not covered under warranty and is costing 7-8k in repairs and over 3k in rental vehicles. I'm told the transmissions are on back order for 3-6 months. No lights went off in the car warning me of this. I smelled burning fumes on and off and reported it to the service dept around 59k (January 2024) miles. I did feel a jump at times, but didn't report that. After my routine oil change at the end of March of 2025, I heard a whining noise only when accelerating and would immediately stop when I released my foot. Two Toyota Service departments diagnosed my car with a failed transmission. I haven't been able to drive my car for 2 months now. My family's safety has been at risk while this issue with this transmission failure has been known and not reported to the consumers prior to my purchase in June of 2024. Potential consequences to a failed transmission while driving are as follows: -Sudden Stop or Coast to a Stop: The car might stop moving entirely, especially if internal components seize or it just loses power and I coast to a stop. -No Response to Acceleration -Pressing the gas has no effect, which is dangerous if I'd be in traffic or on a highway. -Locked-Up Transmission -Rare but possible, especially in catastrophic mechanical failure which could cause wheels to lock briefly. -Stranded