2024 Toyota Grand Highlander

When I turn to the left or right I hear a clicking/popping noise. Took it to the dealer and they said it was the CV axle. So they replaced the driver side. After the repair, it would make the same sound from time to time so I took it back in to the dealer(Northside Toyota in San Antonio, TX) they couldn't recreate the sound and notated my account. This was all when the car had less than 30k miles. The grand highlander now has 47k miles and it is making the noises alot more. Im on a grand highlander forum and a lot of other owners are having the same issues. Some are already on their 3rd set of cv axles.

The contact owns a 2024 Toyota Grand Highlander. The contact received notification of NHTSA Campaign Number: 25V595000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the instrument panel failed to show critical information as intended. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the failure was recall-related; however, the parts were not available for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

The defroster on the vehicle does not work properly. When starting the car and the window is frosting, the drivers side of the front window defrosts normally but the right side does not defrost properly and it lags by 15-20 minutes. You cannot operate the vehicle safely with your entire passenger side frosted over. I reported this to Toyota as well as dealer and they are advising that it is working normally. I have pictures that show that the passenger side does not defrost properly, it was reproduced by the dealer, and Toyota's thermal imaging scan confirms lack of heat on the far side. However, Toyota is standing by that it is working as designed despite their testing showing it isn't working properly.

My vehicle has been out of service since October 7, 2025 due to a complete failure of the instrument cluster (combination meter). This issue is related to SAFETY RECALL 25TA08. The instrument panel is fully non-functional, making the vehicle unsafe and inoperable. The vehicle has been at Toyota dealership for approximately three months, with no repair completed and no clear timeline provided. The dealership stated they are awaiting instructions from Toyota Corporate and cannot proceed independently.

I have taken my vehicle to Wilde Toyota (2 time) for the same issue . The car either moves/slids to the left or right. They adjusted the wheel alignment in November and now again I am having the same issue. Took the car again to Wilde Toyota and they are asking me for 185 USD for the wheel alignment. I told them this looks like a drive train or suspension issue but there were hesitant to check it.

Third row seating bottom (back side) has loose flap material end the bottom, when closing and opening the seat it’s can get stuck. It’s also possible the seat can probably even collapse while in use or in driving. The dealer tried to help but there doesn’t seem to be any solution for this from Toyota. This seems to be model wide issue as I was told by dealer. They had another one with same issue. The bottom back of the seat is literally loose flap material. The only solution was they replaced the cargo tray which was actually slightly BENT at front possibly due to seat struggling to close and opening due to faulty design. THIS IS A FAULTY DESIGN! ITS LITERALLY A LOSSE FLAP PLASTIC MATERIAL ON A SEAT BACK. The dealer told me to be careful when handling these seats bc the material can break easily and there isn’t solution from Toyota on this unless there is recall or safety notice.

I am filing a complaint regarding a safety recall on my Toyota vehicle. Toyota issued the recall notice on September 11, 2025, but as of today there is still no available remedy. Due to this recall, my vehicle has been deemed unsafe and undriveable and has been out of service since October 8, 2025. While a rental vehicle has been provided, I have been without my own car for several months with no clear timeline or resolution. I am concerned about the extended delay in providing a recall remedy for a safety-related defect and the lack of transparency regarding next steps. I am requesting that NHTSA review Toyota’s handling of this recall, including the prolonged lack of a remedy and the impact on vehicle owners. I believe this delay is unreasonable and warrants further oversight.

My Toyota Grand Highlander develops severe interior window fogging and condensation, affecting the windshield, front side windows, and occasionally rear windows. This occurs during normal driving, especially in cool or humid conditions. The fogging appears rapidly, and the HVAC/defrost system often fails to clear the windows effectively, even when set to full defrost with outside air intake. Interior moisture buildup is excessive compared to other vehicles I’ve owned, and the issue repeats regularly. This creates a significant visibility hazard, forcing me to adjust climate controls constantly while driving or pull over to clear the glass manually.

My car is a 2024 Grand Highlander I bought in May of last year. It currently has 20,000 miles on it. A few weeks ago I started hearing a knocking sound when I turned left or right. I looked at some Toyota forums and found that other people were having this issue and had to have both front axles replaced. I took my car to Toyota and sure enough, they said the parts they used to assemble the car were not machined properly and they replaced both of my front axles. Having said that, I have 2 issues. One, why hasn't a recall been issued on this. It seems as though quite a bit of people have had this problem and this is a big safety issue. There have been 2 other recalls, one about the screen going blank and airbags, but to me, axle is a much bigger safety issue, so why no recall on this? Also, the technician recommends an alignment after chaning the axles which I am expected to pay $150 for but this should be included since my axles should not need changing at 20,000 miles. They consider alignment normal wear and tear and not under warranty which I would normally agree with but I only need an aligmnent because they changed my axles.

On 11/24/25 I gave permission to my friend to drive my 2024 Toyota Grand Highlander SUV from my house to Newark international airport, while my friend was driving my 2024 Toyota Grand Highlander SUV on a New Jersey Turnpike , the vehicle suddenly dropped the speed and within moments caught fire. I live in Pennsylvania, but the incident occurred on New Jersey Turnpike . The fire started while the car was in motion, creating a serious safety hazard. The vehicle was properly maintained, and no prior warning lights or issues were noted before the incident. I have done vehicle inspections/ service this month, and they told everything is perfect. This poses a severe risk to driver and passenger safety, and I am reporting it for investigation. Whole car got burned out within 5-10 mins only