Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
440–25K
3225–50K
3250–75K
4675–100K
52100–150K
31150K+
237 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports5 fire reports15 injury reports
What owners actually said
276 reports
35,000 miles · Sep 24, 2025
Electrical SystemSuspension
The contact owns a 2004 Saturn Vue. The contact stated that the light on the instrument panel was abnormally dim. The contact stated that while driving at various speeds over a bumpy road surface, the rear end of the vehicle was swaying from side to side. Additionally, the contact stated that the vehicle made an abnormally loud …
Read full complaint
The contact owns a 2004 Saturn Vue. The contact stated that the light on the instrument panel was abnormally dim. The contact stated that while driving at various speeds over a bumpy road surface, the rear end of the vehicle was swaying from side to side. Additionally, the contact stated that the vehicle made an abnormally loud sound at start up, and it was difficult to remove the key from the ignition switch after turning off the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 35,000.
NHTSA ODI #11689505
Mileage unknown · Aug 28, 2025
Unknown Or Other
The ignition (key) has stopped working again after being recalled a few years ago, and being replaced. The key will not turn and start the car.
NHTSA ODI #11683762
Mileage unknown · Nov 5, 2023
Power TrainCrashInjury
Transmission has Lube issues for Honda and TRANSGO HONDALK fixes that but requires several hours labor pulling transmission. Transmission and torque converter overheat causing failure. Mine overheated and stalled crossing traffic, wouldn't go into gear. Caused accident.
NHTSA ODI #11553676
Mileage unknown · Jan 20, 2023
Electrical System
My Father's car key can be taken out of the ignition when it is not in the off position but his specific VIN is not listed as part of the recall.
NHTSA ODI #11502848
193,500 miles · Oct 12, 2020
Unknown Or Other
RUSTED FRONT SUBFRAME/ ENGINE CRADLE I CARRIED MY SATURN VUE TO HAVE THE CATALYTIC CONVERTERS REPLACED AND MY MASTER-MECHANIC DISCOVERED THE RUSTED SUBFRAME AND BROUGHT IT TO MY ATTENTION. HE SHOWED IT TO ME AND EXPLAINED THE THE DANGER IN OPERATING THIS VEHICLE.
NHTSA ODI #11364004
107,406 miles · Oct 2, 2020
Electrical System
MY 2004 VUE HAD A RECALL IN 2014 FOR THE IGNITION KEY COULD BE REMOVED WITHOUT BEING IN THE OFF POSITION, I HAD THIS REPAIRED ON 12/11/14. RECENTLY MY IGNITION KEY CAN AGAIN BE REMOVED WITHOUT BEING IN THE OFF POSITION.
NHTSA ODI #11362451
160,000 miles · Aug 31, 2020
StructureUnknown Or Other
THE IGNITION BROKE AFTER MANY OF TIMES THE KEY COMING OUT.
NHTSA ODI #11352361
145,790 miles · Jun 27, 2019
Electrical System
I HAVE ALL READY TAKEN MY SATURN VUE TO THE DEALER IN HEMET CA. ( GOSCH CHEVROLET). THE IGNITION SWITCH BROKE AGAIN A WEEK LATER. I TOOK IT BACK BUT GOSCH WOULD NOT FIX IT AGAIN. THE REASON WAS BECAUSE THE HOUSING HAD DAMAGE AROUND IT. NOW THE REASON FOR THAT WAS BECAUSE I WAS STRANDED 20 MILES FROM NOTHING WHEN THE IGNITION WOU…
Read full complaint
I HAVE ALL READY TAKEN MY SATURN VUE TO THE DEALER IN HEMET CA. ( GOSCH CHEVROLET). THE IGNITION SWITCH BROKE AGAIN A WEEK LATER. I TOOK IT BACK BUT GOSCH WOULD NOT FIX IT AGAIN. THE REASON WAS BECAUSE THE HOUSING HAD DAMAGE AROUND IT. NOW THE REASON FOR THAT WAS BECAUSE I WAS STRANDED 20 MILES FROM NOTHING WHEN THE IGNITION WOULD NOT TURN MY VEHICLE ON, I WAS ALONE FOR 2 DAYS BEFORE I HAD TO MESS WITH IT TO GET IT STARTED. THIS HAS BEEN AN ONGOING PROBLEM FOR ME. I'VE MISSED AN AIR FLIGHT. AND 2 JOBS FIRED ME BECAUSE I COULD NOT GET TO WORK. ITS BEEN A DOWNWARD SPIRAL EVER SINCE. SATURN'S ARE GREAT CARS OTHERWISE.
NHTSA ODI #11223006
248,000 miles · May 16, 2019
Electrical System
TL* THE CONTACT OWNS A 2004 SATURN VUE. WHILE OPERATING THE VEHICLE, THE KEY CAME OUT OF THE IGNITION SWITCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. VALLEY CHEVROLET (525 HWY 7E, HUTCHINSON, MN) AND THE MANUFACTURER WERE NOTIFIED AND STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM)…
Read full complaint
TL* THE CONTACT OWNS A 2004 SATURN VUE. WHILE OPERATING THE VEHICLE, THE KEY CAME OUT OF THE IGNITION SWITCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. VALLEY CHEVROLET (525 HWY 7E, HUTCHINSON, MN) AND THE MANUFACTURER WERE NOTIFIED AND STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V490000 (ELECTRICAL SYSTEM); HOWEVER, THE PART WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 248,000.
NHTSA ODI #11208063
Mileage unknown · May 2, 2019
Unknown Or Other
THERE WAS A RECALL BACK IN OCTOBER 20TH, 2014 REGARDING AN ISSUE WITH THE IGNITION. WHERE YOU CAN PULL THE KEY OUT WHILE ITS RUNNING. I'VE NEVER GOTTEN A CALL FROM NHTSA REGARDING THE ISSUE. MAY I HAVE IT DONE FREE OF CHARGE. THE VEHICLE WAS STATIONARY
General Motors LLC (GM) is recalling certain model year 2002-2004 Saturn Vue vehicles manufactured September 11, 2001, to April 6, 2004. In the affected vehicles, it may be possible for the key to be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: GM will notify owners, and dealers will inspect the vehicle to see if the key can be pulled out when the ignition is off. If it can, dealers will replace the ignition cylinder and keys, free of charge. The recall began in October 2014. Owners may contact Saturn customer service at 1-800-553-6000. GM's number for this recall is 14506. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5L V6 (L66) ENGINES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT AND REAR WHEEL RIM SIZE SPECIFICATIONS ON THE TIRE/CERTIFICATION LABEL ARE NOT CORRECT. THE PRINTED WHEEL RIM DESIGNATION SPECIFIED A 16-INCH WHEEL WHEN A 17-INCH WHEEL DESIGNATION WAS REQUIRED.
Consequence & remedy
Consequence: IF THE WHEEL RIM SIZE IS INCORRECTLY PRINTED ON A TIRE/CERTIFICATION LABEL, A SERVICE TECHNICIAN WHO SOLELY USES THE TIRE/CERTIFICATION LABEL FOR SERVICE INFORMATION MAY ATTEMPT TO REPLACE A DAMAGED WHEEL WITH AN INCORRECT WHEEL.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04052 · Rear Suspension Toe Control Link
Opened Jul 22, 2004 · Closed Nov 1, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Additional source detail variants (2)
Suspension
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
Suspension:rear
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED. ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
2004 Saturn Vue Problems, Complaints & Recalls | Skip That Year
Illustration