Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports1 fire reports6 injury reports

What owners actually said

126 reports

15,000 miles · Jul 10, 2003

Tires

WHILE DRIVING, THE BACK LEFT TIRE TREAD SEPARATED, WHICH CAUSED THE TIRE TO BLOWOUT. CONSUMER HAD TO PULL OVER. GENERAL XP2000GT, SIZE# P21570R/15, DOT#ACM3KN12801. *AK PH *JB

NHTSA ODI #10022032

17,000 miles · Jun 11, 2003

Latches/locks/linkagesInjury

AUTOMATIC SLIDING DOOR RELEASED AND CLOSED A SMALL CHILD'S HAND IN IT. AS A RESULT, CHILDS HAND WAS STUCK IN DOOR, AND DOOR WOULD NOT OPEN. CONSUMER HAD TO OPEN DOOR FROM THE INSIDE. *AK

NHTSA ODI #10022852

8,000 miles · Mar 21, 2003

Power TrainService Brakes, Hydraulic

WHILE DRIVING AT ANY SPEED THE ABS BRAKE LIGHT AND THE 4 WHEEL DRIVE LIGHT ILLUMINATED. CONSUMER STATED THAT AS A RESULT THE VEHICLE WAS STUCK IN THE SNOW. *NLM WHEN THE ABS IS NOT WORKING PROPERLY, THE VEHICLE WILL NOT BRAKE SAFELY, AND THE FOUR/ALL WHEEL DRIVE WILL NOT WORK. THE VEHICLE WILL NOT HAVE THE TRACTION TO GO U…

Read full complaint

NHTSA ODI #10012239

Mileage unknown · Mar 6, 2003

Service Brakes, Hydraulic

INTERMITTENTLY THE ABS LIGHT BECAME INOPERATIVE AND DISABLED THE FOUR WHEEL DRIVE. *JB *TS

NHTSA ODI #10010091

Mileage unknown · Dec 10, 2002

Structure

CONSUMER STATES THAT WITH NO WARNING THE REAR SLIDING DOOR WILL STICK AND IT WILL BE HARD TO OPEN FOR THE CONSUMER TO ENTER OR EXIT THE VEHICLE. DEALER NOTIFIED. TS

NHTSA ODI #8024068

Mileage unknown · Nov 20, 2002

Structure

DRIVER SIDE POWER SLIDING DOOR ALARM GOES OFF WHILE BEING CLOSED. THE DOOR WILL NOT ALWAYS OPEN. THE DOOR DOES NOT SHUT AND THE VEHICLE ALLOWS YOU TO DRIVE WITH IT IN THE OPEN POSITION. ALL 4 TIRES HAD BUBBLES ALL 4 TIRES WERE REPLACED. DT

NHTSA ODI #769947

Mileage unknown · Sep 19, 2002

Power Train

CONSUMER CAN SHIFT VEHICLE FROM PARK WITHOUT APPLYING BRAKE PEDAL.*AK

NHTSA ODI #8019063

Mileage unknown · Sep 4, 2002

Latches/locks/linkages

WHILE DRIVING AT ANY SPEED AND WITH NO WARNING REAR SLIDING PASSENGER'S DOOR WILL OPEN, AND CONSUMER WILL HAVE TO PULL OVER TO CLOSE THE DOOR. DEALER NOTIFIED.*AK

NHTSA ODI #8017886

Mileage unknown · Aug 29, 2002

Equipment

Read full complaint

CAR DID NOT COME WITH AN ASHTRAY AND NONE ACCORDING TO THE DEALER IS AVAILABLE IN THAT MODEL THIS YEAR. WHAT THE DEALER OFFERED WAS A PLACE IN ASHTRAY TO GO IN THE CUPHOLDER. THIS I TOOK AS A REPLACEMENT TO THE UN-OFFERED AND NOT AVAILABLE ASHTRAY. HOWEVER SEVERAL WEEKS AFTER GETTING THIS NEW CAR I WAS DRIVING AT NIGHT AND WENT TO PUT OUT MY CIGARETTE. BECAUSE THERE WAS NO LIGHT AND THE DASHBOARD HAS NO LIGHTS IN THAT AREA MY CIGARETTE HEAD HIT THE FRONT OF THE CUPHOLDER DROPPING THE LIT HEAD ON THE FLOOR. IMMEDIATE PANIC ENSUED RESULTING IN ME REMOVING MY EYES FRON THE ROAD TO RECOVER THE LIT HEAD OF THE CIGARETTE. I ASKED THE DEALER IF PONTIAC OFFERED A LIGHT FOR THAT AREA AND THE ANSWER WAS NO,. I VERIFIED THAT WITH PONTIAC CUSTOMER ASSISTANCE AND THEY SAID THERE IS NOT EVEN A SMOKERS PACKAGE AVAILABLE. I WOULD HAVE NOT UPGRADED FROM MY 1998 MONTANA WHICH HAD AN ASHTRAY IF I KNEW IT DIDN'T BEFORE TAKING DELIVERY. THIS IS NOT ONE OF YOUR MAJOR CASES BUT SHOULD BE LOOKED AT AS A POSSIBLE FIRE OR SAFETY HAZARD. *AK

NHTSA ODI #766416

Mileage unknown · Jul 9, 2002

Service Brakes, Hydraulic

WHILE DRIVING ON WET PAVEMENT CONSUMER STEPPED ON BRAKES AND THERE WAS NO RESPONSE FOR AT LEAST 10 SECONDS. CONSUMER HAD TO CONSTANTLY PRESS BRAKE PEDAL TO GET VEHICLE TO SLOW DOWN. *AK CONSUMER ADDS DEALERSHIP AND MANUFACTURER FOUND NOTHING WRONG. *TT

NHTSA ODI #8013487

Official recalls

07V349000 · Fuel System, Gasoline:storage

Aug 8, 2007

ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Consequence & remedy

Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.

04V597000 · Latches/locks/linkages:doors:latch

Dec 22, 2004

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence & remedy

Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

02V222000 · Air Bags:frontal

Aug 9, 2002

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence & remedy

Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE04064 · POWER-SLIDING Door

Opened Sep 17, 2004 · Closed Dec 22, 2004

Status: closed (inferred from source dates) · Structure:body:door

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.