THE DRIVER AND PASSENGER SIDE BRAKE LIGHTS CONSTANTLY GO OUT. I HAVE SPOKEN TO A MECHANIC AND HE TOLD ME THAT IT IS VERY COMMON FOR GM VEHICLES IN THIS MODEL YEAR RANGE TO HAVE TO REPLACE THE LIGHTING BANK IN THE REAR OF THE VEHICLES ON BOTH SIDES. THE BANK WHICH CONTAINS THE BRAKE LIGHTS, THE BACK-UP LIGHTS, AND THE RUNNING L…
Read full complaint
THE DRIVER AND PASSENGER SIDE BRAKE LIGHTS CONSTANTLY GO OUT. I HAVE SPOKEN TO A MECHANIC AND HE TOLD ME THAT IT IS VERY COMMON FOR GM VEHICLES IN THIS MODEL YEAR RANGE TO HAVE TO REPLACE THE LIGHTING BANK IN THE REAR OF THE VEHICLES ON BOTH SIDES. THE BANK WHICH CONTAINS THE BRAKE LIGHTS, THE BACK-UP LIGHTS, AND THE RUNNING LIGHTS FAILS AND THE BRAKE LIGHTS SEEM TO BE MOST AFFECTED. I HAVE HAD TO REPLACE MY BRAKE LIGHTS APPROXIMATELY ONCE A MONTH FOR MULTIPLE YEARS. THERE HAVE BEEN MANY NEAR-COLLISIONS DUE TO BRAKE LIGHTS NOT OPERATING. THE THIRD BRAKE LIGHT AT THE TOP OF THE VEHICLE APPEARS TO NOT BE AFFECTED BY THIS. *TR
NHTSA ODI #10498563
96,000 miles · Apr 7, 2009
Exterior Lighting
THE BRAKE LIGHT ON MY VEHICLE DOES NOT WORK ALL THE TIME. I HAVE HAD PEOPLE ALMOST HIT ME BECAUSE OF THIS. *TR
NHTSA ODI #10264392
60,000 miles · Mar 3, 2009
Electrical SystemExterior Lighting
I BOUGHT 2002 PONTIAC MONTANA USED IN DEC. 2008. FIRST THE RADIO DISPLAY WENT COMPLETELY OUT. THEN AS I WAS PULLING INTO A PARKING LOT THE CAR SHUT OFF BY ITSELF... IT STARTED BACK UP AGAIN BUT I WAS IN TRAFFIC AND ALMOST CAUSED THREE CARS TO CRASH. THEN I NOTICED THAT MY DRIVER'S SIDE BRAKE LIGHT WENT OUT, AND A WEEK LATER THE…
Read full complaint
I BOUGHT 2002 PONTIAC MONTANA USED IN DEC. 2008. FIRST THE RADIO DISPLAY WENT COMPLETELY OUT. THEN AS I WAS PULLING INTO A PARKING LOT THE CAR SHUT OFF BY ITSELF... IT STARTED BACK UP AGAIN BUT I WAS IN TRAFFIC AND ALMOST CAUSED THREE CARS TO CRASH. THEN I NOTICED THAT MY DRIVER'S SIDE BRAKE LIGHT WENT OUT, AND A WEEK LATER THE PASSENGER SIDE BRAKE LIGHT WENT OUT. I HAVE BOUGHT REPLACEMENT BULBS AND IT STILL DOES NOT WORK (THE BAR ON TOP IS WORKING). THE RADIO/ CLOCK DISPLAY IS JUST AN INCONVENIENCE BUT BRAKE LIGHTS... THEY ARE IMPORTANT! I AM BRINGING TO THE DEALER TODAY TO INSPECT. I SEE THERE ARE MANY MANY COMPLAINTS FOR THIS AND SHOULD NOT BE OVERLOOKED!!! I HAVE MY FAMILY TO PROTECT! *TR
NHTSA ODI #10260549
Mileage unknown · Dec 19, 2006
Exterior Lighting
BRAKE LIGHT STOPS WORKING ON REAR DRIVER'S SIDE, THIS HAS HAPPENED THREE TIMES IN LESS THAN A YEAR SO FAR. THE BULB ITSELF DOES NOT BURN OUT BUT THE PLASTIC ON THE BULB MELTS ON THE ONE SIDE COVERING THE WIRES. WE STILL HAVE ALL THE BULBS THAT WE REPLACED IF NEEDED FOR VIEWING. *NM
NHTSA ODI #10176532
83,124 miles · Sep 15, 2006
Exterior Lighting
DT*: THE CONTACT STATED THE REAR BRAKE LIGHTS BURNED OUT CONTINUOUSLY, AND WERE REPLACED 20 TIMES. THE VEHICLE WAS NOT INSPECTED BY A MECHANIC.
NHTSA ODI #10168394
36,000 miles · Jun 27, 2006
Exterior Lighting
REAR BRAKE LIGHTS BEGAN WORKING INTERMITTENTLY, THEN FAILED ALTOGETHER. *JB
NHTSA ODI #10160901
Mileage unknown · Apr 5, 2006
Exterior Lighting
REAR BRAKES, REVERSE AND TURNING LIGHT ASSEMBLY SHORTS OUT LEAVING THE VEHICLE WITH NON WORKING LIGHTS IN THE REAR. IT HAS TO BE A MANUFACTURING DEFECT SINCE I SEE MANY VEHICLES ON THE ROAD USING THE SAME LIGHT ASSEMBLY WITH THE SAME PROBLEM. *NM
NHTSA ODI #10154587
56,000 miles · Mar 20, 2006
Exterior LightingVisibility
THERE ARE 2 MAIN SAFETY CONCERNS WITH MY 2002 PONTIAC MONTANA THUNDER MINIVAN. FIRST, THE REAR DRIVER'S SIDE BRAKE LIGHT HAS GONE OUT. EVEN WITH REPLACEMENT OF BULB AND FUSE, THE BRAKE LIGHT WILL NOT WORK. FROM RESEARCHING ON THE INTERNET, THIS SEEMS TO BE A DESIGN DEFECT AND A COMMON PROBLEM. THIS IS A MAJOR SAFETY ISSUE!!!…
Read full complaint
THERE ARE 2 MAIN SAFETY CONCERNS WITH MY 2002 PONTIAC MONTANA THUNDER MINIVAN. FIRST, THE REAR DRIVER'S SIDE BRAKE LIGHT HAS GONE OUT. EVEN WITH REPLACEMENT OF BULB AND FUSE, THE BRAKE LIGHT WILL NOT WORK. FROM RESEARCHING ON THE INTERNET, THIS SEEMS TO BE A DESIGN DEFECT AND A COMMON PROBLEM. THIS IS A MAJOR SAFETY ISSUE!!! SECOND, THE REAR WINDSHIELD WIPER DOES NOT WORK. AGAIN, THIS SEEMS TO BE A COMMON 2002 PONTIAC MONTANA PROBLEM, AND AGAIN, IS A SAFETY CONCERN. *JB
NHTSA ODI #10153220
65,000 miles · Mar 10, 2006
Exterior Lighting
CORROSION INSIDE TAIL LAMP ASSEMBLY HAS CAUSED BOTH REAR BRAKE LIGHTS TO FAIL. ONLY CENTER BRAKE LIGHT BAR IS FUNCTIONAL. *NM
NHTSA ODI #10152433
51,000 miles · Jul 20, 2005
Exterior Lighting
BACK TAIL/BRAKE LIGHTS ALLOW WATER TO RUN INTO THEM CAUSING LOSS OF BRAKE LIGHTS IN RAIN.
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
2002 Pontiac Montana Problems, Complaints & Recalls | Skip That Year
Illustration