IllustrationDRIVESHAFT CAME LOOSE 6-28-2007 FOR THE 4TH TIME. *TR
2005 Pontiac Gto
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Pontiac Gto do not stand out strongly from the model-year median of 154.
About this comparison →How this year compares
Owner complaints by model year
Compare all Gto years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
1925–50K
650–75K
475–100K
4100–150K
2150K+
122 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports4 injury reports
What owners actually said
154 reportsTL*THE CONTACT OWNS A 2005 PONTIAC GTO. WHILE DRIVING 20 MPH, THE CONTACT HEARD A CLICKING NOISE COMING FROM THE FRONT PASSENGER SIDE TIRE. HE NOTICED THAT THE TREAD HAD SEPARATED. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE STRUTS WEARING INTO THE TIRES, WHICH WAS DUE TO A DESIGN FLAW WITH THE VEHICLE. THERE IS A D…
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. WHILE DRIVING 20 MPH, THE CONTACT HEARD A CLICKING NOISE COMING FROM THE FRONT PASSENGER SIDE TIRE. HE NOTICED THAT THE TREAD HAD SEPARATED. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY THE STRUTS WEARING INTO THE TIRES, WHICH WAS DUE TO A DESIGN FLAW WITH THE VEHICLE. THERE IS A DEFECT INVESTIGATION OPEN (NHTSA ACTION # PE07010) FOR THE MCPHERSON STRUT. THE DEALER STATED THAT THEY WOULD CONTACT A GENERAL MOTORS REPRESENTATIVE AND ADVISED THE CONTACT TO NOT DRIVE THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 17,760.
DRIVER FRONT TIRE RUBBING ON STRUT INSIDE 3 INCHES WARN DOWN PAST THE WEAR INDICATORS WHILE 3/16 TREAD STILL LEFT ON REST OF TIRE. TIRE WENT FLAT WHILE TRAVELING DOWN RESIDENTIAL ROADS, DAMAGE TO THE RIM RESULTED. DRIVER'S SIDE CAMBER WAS ADJUSTED TO ALLOW TIRE NOT TO CONTACT STRUT, THROWING ALIGNMENT OUT, TIRE REPLACED. PASS…
Read full complaint
DRIVER FRONT TIRE RUBBING ON STRUT INSIDE 3 INCHES WARN DOWN PAST THE WEAR INDICATORS WHILE 3/16 TREAD STILL LEFT ON REST OF TIRE. TIRE WENT FLAT WHILE TRAVELING DOWN RESIDENTIAL ROADS, DAMAGE TO THE RIM RESULTED. DRIVER'S SIDE CAMBER WAS ADJUSTED TO ALLOW TIRE NOT TO CONTACT STRUT, THROWING ALIGNMENT OUT, TIRE REPLACED. PASSENGER SIDE NOTICED HAVING THE SAME PROBLEM ONLY 2 INCHES WARN AWAY ON INSIDE OF TIRE MONTHS LATER. PROBLEM NOTICED AFTER TIRE WENT FLAT ON STATE HIGHWAY, CAUSING RIM TO BE SCUFFED. TIRE REPLACED, NO SUSPENSION WORK DONE TO FIX ISSUE. *AK
I HAVE A 2005 PONTIAC GTO. WITH LESS THAN 18,000 ON THE CAR, THE STEERING WHEEL STARTED TO SHAKE VERY ROUGH. I TOOK IT IN FOR A FRONT END ALIGNMENT AND DISCOVERED THE THREAD ON THE INSIDE RIM OF THE FRONT TIRES WAS COMPLETELY WORN DOWN. I HAD TO REPLACE THE TIRES WITH LESS THAN 18,000 MILES DUE TO EXCESSIVE WEAR. I HAVE SINCE LE…
Read full complaint
I HAVE A 2005 PONTIAC GTO. WITH LESS THAN 18,000 ON THE CAR, THE STEERING WHEEL STARTED TO SHAKE VERY ROUGH. I TOOK IT IN FOR A FRONT END ALIGNMENT AND DISCOVERED THE THREAD ON THE INSIDE RIM OF THE FRONT TIRES WAS COMPLETELY WORN DOWN. I HAD TO REPLACE THE TIRES WITH LESS THAN 18,000 MILES DUE TO EXCESSIVE WEAR. I HAVE SINCE LEARNED THROUGH THE NEWS THAT APPARENTLY THERE IS A DEFECT IN THE FRONT END WHERE THE TIRES ARE RUBBING AGAINST THE STRUTS. IT COST ME OVER $600 IN TIRES. I AM NOW CONCERNED ABOUT THE POSSIBLE DANGERS OF TIRE BLOW OUTS AND AT MINIMUM HAVING TO PLACE THE TIRES AGAIN VERY SOON. *TR
LOOKED AT MY FRONT TIRES ON MY 2005 PONTIAC GTO AND NOTICED THAT THEY ARE WORN DOWN ON THE INSIDE STRUT SIDE ALMOST TO THE STEEL BELT. I LOOKED ON THE REAR WHEELS AND NOTICED A SIMILAR WEAR ON THE INSIDE OF THE TIRE FROM WHEN THOSE TIRES WERE ON THE FRONT. IF I WOULDN'T HAVE NOTICED THIS, I COULD HAVE HAD A BLOW OUT. THE WEAR IS…
Read full complaint
LOOKED AT MY FRONT TIRES ON MY 2005 PONTIAC GTO AND NOTICED THAT THEY ARE WORN DOWN ON THE INSIDE STRUT SIDE ALMOST TO THE STEEL BELT. I LOOKED ON THE REAR WHEELS AND NOTICED A SIMILAR WEAR ON THE INSIDE OF THE TIRE FROM WHEN THOSE TIRES WERE ON THE FRONT. IF I WOULDN'T HAVE NOTICED THIS, I COULD HAVE HAD A BLOW OUT. THE WEAR IS TERRIBLE. THE VEHICLE IS NEW WITH LOW MILES. THE VEHICLE NOW HAS 21,000 MILES AND APPARENTLY HAS BEEN DOING THIS SINCE I BOUGHT IT OVER A YEAR AGO. NOTHING HAS BEEN DONE YET TO CORRECT THIS ISSUE. I AM IN LINGO ON WHAT TO DO. THE OLD PARTS ARE DEFINITELY STILL AVAILABLE AND CAN BE MADE AVAILABLE UPON REQUEST. *TR
FRONT TIRES RUB THE STRUT CAUSING PREMATURE EXCESSIVE WEAR TO INSIDE OF TIRE REVEALING THE CORDS. *TR
MY 2005 GTO HAS STRUT RUB WITH 20,000 MILES ON IT. AFTER MANY COMPLAINTS TO MY DEALERSHIP I CAN SEE THAT THEY ARE NOT CONCERNED FOR MINE OR MY WIFE'S LIVES. THEY KEEP PUTTING OUR SERVICE DATE BACK WEEK AFTER WEEK. BOTH OF THE FRONT TIRES ARE WORN DOWN TO THE METAL BELTS ON THE INSIDE WALL. WE ARE STILL TRYING TO GET ASSISTANCE F…
Read full complaint
MY 2005 GTO HAS STRUT RUB WITH 20,000 MILES ON IT. AFTER MANY COMPLAINTS TO MY DEALERSHIP I CAN SEE THAT THEY ARE NOT CONCERNED FOR MINE OR MY WIFE'S LIVES. THEY KEEP PUTTING OUR SERVICE DATE BACK WEEK AFTER WEEK. BOTH OF THE FRONT TIRES ARE WORN DOWN TO THE METAL BELTS ON THE INSIDE WALL. WE ARE STILL TRYING TO GET ASSISTANCE FOR THIS ISSUE FROM ANYONE WHO WILL HELP BEFORE WE ARE KILLED OR SOMEONE ELSE IS. *TR
FRONT TIRES ARE SHREDDING, RUBBING ON STRUTS. STEEL BELTS ON TIRES EXPOSED. MUST BUY NEW TIRES AND GET FRONT CAMBER SET AND ALIGNMENT. *TR
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. THE MECHANIC NOTICED THAT THE PASSENGER SIDE FRONT TIRE SIDEWALL WAS WORN DOWN TO THE STEEL BELT. THE FAILURE WAS NOTICED WHILE THE VEHICLE WAS ON A LIFT RECEIVING AN OIL CHANGE. THE TIRE HAS NOT BEEN REPLACED. THE VEHICLE HAS NOT BEEN DIAGNOSED. THE PURCHASE DATE, ENGINE SIZE, CORREC…
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. THE MECHANIC NOTICED THAT THE PASSENGER SIDE FRONT TIRE SIDEWALL WAS WORN DOWN TO THE STEEL BELT. THE FAILURE WAS NOTICED WHILE THE VEHICLE WAS ON A LIFT RECEIVING AN OIL CHANGE. THE TIRE HAS NOT BEEN REPLACED. THE VEHICLE HAS NOT BEEN DIAGNOSED. THE PURCHASE DATE, ENGINE SIZE, CORRECT VIN, AND TRANSMISSION TYPE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 11,073.
IN MY 2005 PONTIAC GTO THERE IS A PROBLEM WITH THE FRONT TIRES RUBBING THE STRUT ASSEMBLY. THE MARKS ON THE STRUTS ARE VERY VISIBLE AND THEY HAVE WORN DOWN TO THE BARE METAL. I NOTICED THE PROBLEM WHEN ROTATING MY TIRES. AN ALIGNMENT HAS BEEN DONE IN ORDER TO INCREASE THE CAMBER, HOWEVER, THE INITIAL SPECS WERE WELL WITHIN MANU…
Read full complaint
IN MY 2005 PONTIAC GTO THERE IS A PROBLEM WITH THE FRONT TIRES RUBBING THE STRUT ASSEMBLY. THE MARKS ON THE STRUTS ARE VERY VISIBLE AND THEY HAVE WORN DOWN TO THE BARE METAL. I NOTICED THE PROBLEM WHEN ROTATING MY TIRES. AN ALIGNMENT HAS BEEN DONE IN ORDER TO INCREASE THE CAMBER, HOWEVER, THE INITIAL SPECS WERE WELL WITHIN MANUFACTURER'S SPECIFICATIONS. THE DEALERSHIP DID NOT PERFORM THE ALIGNMENT. THE PONTIAC DEALERSHIP HAD NO REAL SOLUTION TO THE PROBLEM NOR WERE THEY VERY WILLING TO FINDING ONE. I AM NOT SURE THAT THE ALIGNMENT HAS FIXED THE ISSUE. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE07010 · Front Strut To Tire Interference
Opened Feb 16, 2007 · Closed Aug 8, 2007
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:macpherson Strut; Tires; Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Additional source detail variants (5)
Suspension:front
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension:front:macpherson Strut
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH