IllustrationTL*THE CONTACT OWNS A 2005 PONTIAC GTO WITH BF GOODRICH TIRES (MODEL UNKNOWN). WHILE DRIVING 15 MPH, THE FRONT PASSENGER TIRE WAS FLAT. THE CONTACT FELT THAT THE FRONT TIRES RUBBED AGAINST THE STRUTS AND CAUSED A FLAT. THE CURRENT AND FAILURE MILEAGES WERE 19,774. *UPDATED 12/12/2007 *BF UPDATED 12/12/07 *TR
2005 Pontiac Gto
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Pontiac Gto do not stand out strongly from the model-year median of 154.
About this comparison →How this year compares
Owner complaints by model year
Compare all Gto years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
1925–50K
650–75K
475–100K
4100–150K
2150K+
122 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports4 injury reports
What owners actually said
154 reportsTHE IGNITION LOCK CYLINDER IS BAD. THIS IS AN ONGOING PROBLEM WITH THE PONTIAC GTO'S. GM NEEDS TO STAND UP AND TAKE RESPONSIBILITY TO THIS PROBLEM. I'M BEING TOLD MY PART WONT BE IN INTO DECEMBER THIS IS UNACCEPTABLE. PLEASE INVESTIGATE I DO BELIEVE THIS IS A SAFETY ISSUE AS WELL. THANKS. *JB
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. THE CONTACT STATED THAT THE TIRES ARE LEANING AGAINST THE STRUTS OF THE VEHICLE. HE NOTICED THAT ALL FOUR TIRES WERE COMPLETELY BALD AND WERE WEARING UNEVENLY IN THE INNERSIDE. THE VEHICLE WILL BE TAKEN IN FOR INSPECTION ON AUGUST 21, 2007. NO TIRE INFORMATION WAS PROVIDED. THE CURREN…
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. THE CONTACT STATED THAT THE TIRES ARE LEANING AGAINST THE STRUTS OF THE VEHICLE. HE NOTICED THAT ALL FOUR TIRES WERE COMPLETELY BALD AND WERE WEARING UNEVENLY IN THE INNERSIDE. THE VEHICLE WILL BE TAKEN IN FOR INSPECTION ON AUGUST 21, 2007. NO TIRE INFORMATION WAS PROVIDED. THE CURRENT AND FAILURE MILEAGES WERE 15,904.
AT APPROX. 18,000 MILES MY INNER TREAD OF ALL FOUR TIRES HAS PREMATURE WEAR. WOULD HAVE NEVER NOTICED THIS WEAR HAD IT NOT BEEN FOR THE FAULTY WORK ON THE REAR COIL SPRING HOUSING TO THE AXLE (LEFT SIDE) BEEN MAKING CLICKING SOUNDS. IT REQUIRED AN INSPECTION ON A LIFT AND IT WAS NOTICED THE MANUFACTURER FAILED TO WELD THE HOUSIN…
Read full complaint
AT APPROX. 18,000 MILES MY INNER TREAD OF ALL FOUR TIRES HAS PREMATURE WEAR. WOULD HAVE NEVER NOTICED THIS WEAR HAD IT NOT BEEN FOR THE FAULTY WORK ON THE REAR COIL SPRING HOUSING TO THE AXLE (LEFT SIDE) BEEN MAKING CLICKING SOUNDS. IT REQUIRED AN INSPECTION ON A LIFT AND IT WAS NOTICED THE MANUFACTURER FAILED TO WELD THE HOUSING TO THE AXLE WHICH IN MY OPINION SEEMS DANGEROUS TOO. *JB
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. WHILE DRIVING 55 MPH THE FRONT OF THE VEHICLE AND THE STEERING WHEEL WOULD SHAKE. THE CONTACT STATED THAT THE VEHICLE WOULD SHAKE MORE AS THE MPH INCREASED. THE DEALER STATED THAT THE STRUTS WERE RUBBING AGAINST THE INSIDE OF THE TIRES. THE CONTACT HAS REPLACED THREE SETS OF TIRES IN TW…
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. WHILE DRIVING 55 MPH THE FRONT OF THE VEHICLE AND THE STEERING WHEEL WOULD SHAKE. THE CONTACT STATED THAT THE VEHICLE WOULD SHAKE MORE AS THE MPH INCREASED. THE DEALER STATED THAT THE STRUTS WERE RUBBING AGAINST THE INSIDE OF THE TIRES. THE CONTACT HAS REPLACED THREE SETS OF TIRES IN TWO YEARS. THE CURRENT AND FAILURE MILEAGES WERE 46,000.
STRUT RUB ON FRONT TIRES. *TR
FRONT TIRES RUBBING AGAINST THE STRUTS. *TR
2005 PONTIAC GTO, FRONT TIRE FAILURE, UNUSUAL WEAR ON INSIDE SHOULDER. 26,880 MILES ON TIRES, HAD CAR SINCE NEW. STEEL BELTS SHOWING ON INSIDE OF RIGHT FRONT, LEFT FRONT SHOWING SIMILAR WEAR. HAD TO REPLACE BOTH. VERY LUCK TO AVOID BLOWOUT. LOVE CAR'S PERFORMANCE AND HANDLING BUT THIS HAS CAUSE A CONCERN. *TR
STRONG VIBRATION DEVELOPED FROM THE FRONT OF THE VEHICLE. INSPECTION OF THE FRONT END REVEALED THE INSIDE EDGE OF MY RIGHT FRONT TIRE WAS CUT PAST THE STEEL BELTS DUE TO IT RUBBING ON THE STRUT. I HAD TO REPLACE ALL THE TIRES ON THE CAR. *TR
FRONT TIRE TREAD CAME OFF DUE TO PREMATURE WEAR OF PASSENGER SIDE TIRE. DRIVER SIDE TIRE READY TO FAIL. CAUSE SEEMED TO BE CURRENTLY UNDER INVESTIGATION FROM NHSTA. DEALER ROTATED THE TIRES IN THE PAST AND HAS NOT COMMENTED. WAS DENYING ANY PROBLEM WITH CAR. EXTREMELY DANGEROUS. ODOMETER READING AT TIRE FAILURE 25515 MILE…
Read full complaint
FRONT TIRE TREAD CAME OFF DUE TO PREMATURE WEAR OF PASSENGER SIDE TIRE. DRIVER SIDE TIRE READY TO FAIL. CAUSE SEEMED TO BE CURRENTLY UNDER INVESTIGATION FROM NHSTA. DEALER ROTATED THE TIRES IN THE PAST AND HAS NOT COMMENTED. WAS DENYING ANY PROBLEM WITH CAR. EXTREMELY DANGEROUS. ODOMETER READING AT TIRE FAILURE 25515 MILES. CURRENTLY GOING BACK TO DEALER TO SEE IF THEY WILL RESOLVE ISSUE AS WAS EXPECTED. *AK
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE07010 · Front Strut To Tire Interference
Opened Feb 16, 2007 · Closed Aug 8, 2007
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:macpherson Strut; Tires; Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Additional source detail variants (5)
Suspension:front
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension:front:macpherson Strut
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH