IllustrationMY 2005 PONTIAC GTO WAS PURCHASED WITH 53000 MILES AND MANUFACTURED WITH 245MM TIRES THAT ARE TOO WIDE AND RUB ON THE FRONT STRUT. THIS HAS CAUSED EXCESSIVE TIRE WEAR. OTHER 04-05 GTOS HAVE HAS THE SAME PROBLEM. THIS HAS CAUSED TIRE FAILURE AND ACCIDENTS IN OTHER GTOS. *JS
2005 Pontiac Gto
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Pontiac Gto do not stand out strongly from the model-year median of 154.
About this comparison →How this year compares
Owner complaints by model year
Compare all Gto years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
1925–50K
650–75K
475–100K
4100–150K
2150K+
122 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports4 injury reports
Tires complaints
44 reportsTIRES WEAR EXCESSIVELY ON MY 2005 GTO. TIRE FAILURE WAS DUE TO EXCESSIVE WEAR ON THE INSIDE EDGE. IT WAS NOT DETECTED BECAUSE IT ONLY OCCURS AT THE VERY INSIDE EDGE. TIRE FAILURE ON THE HIGHWAY OCCURRED AND WHEN TAKEN IN FOR SERVICE TO THE DEALER THEY NOTICED THE OTHER WAS SHOWING STEEL THROUGH AS WELL. THEY SAID IT WAS AN ALIGN…
Read full complaint
TIRES WEAR EXCESSIVELY ON MY 2005 GTO. TIRE FAILURE WAS DUE TO EXCESSIVE WEAR ON THE INSIDE EDGE. IT WAS NOT DETECTED BECAUSE IT ONLY OCCURS AT THE VERY INSIDE EDGE. TIRE FAILURE ON THE HIGHWAY OCCURRED AND WHEN TAKEN IN FOR SERVICE TO THE DEALER THEY NOTICED THE OTHER WAS SHOWING STEEL THROUGH AS WELL. THEY SAID IT WAS AN ALIGNMENT ISSUE. AFTER ALIGNMENT AND NEW TIRES THE CAR CONTINUES TO WEAR EXCESSIVELY. DEALER SAYS THEY DO NOT KNOW WHY. GM MUST DO SOMETHING ABOUT THIS BEFORE A FATALITY OCCURS. *TR
I BOUGHT A 2005 GTO AND WITH ONLY 27,000 MILES THE STOCK FRONT TIRES ARE RUBBING ON THE FRONT STRUT BRACKET. I WAS TOLD BY A SHOP NOT TO DRIVE IT AS THE TIRES ARE CLOSE TO A BLOWOUT. FIVE MINUTES ON THE INTERNET REVEALS THIS IS A VERY COMMON PROBLEM THAT HAS CAUSED MANY ACCIDENTS. *TR
I OWN A 2005 PONTIAC GTO AND THE EVENTS LEADING UP TO THE PROBLEM WAS I HAD NOTICED THAT MY TIRES WERE NOT HOLDING AIR SO I TOOK MY CAR TO A TIRE COMPANY TO HAVE THEM LOOK AT MY TIRES THEY TOLD ME THAT THE TREAD HAD BEEN RUBBED OFF DUE TO THE STRUTS ON THE FRONT END OF MY CAR. *TR
STRUTS RUBBING AGAINST TIRES ON 2005 PONTIAC GTO. TIRES ARE FACTORY RECOMMENDED SIZE. STEERING WHEEL SHAKES IMMENSELY FROM MANUFACTURER DEFECT, TIRES WORN OUT PREMATURELY, AND SAFETY ISSUE TO FAMILY. ACCIDENT WAITING TO HAPPEN!! *TR
JUST CHECKING THE TIRES NOTICE THE TIRE WEAR ON THE INSIDE SO TOOK THE TIRE OUT AND NOTICE THAT THE FRONT STRUT HAD A SHINE PART TO IT THAT INDICATES THAT THE FRONT TIRES WERE RUBBING AND CAUSE THE TWO FRONT TIRES TO WEAR OUT WITH THE WIRES COMING OUT DID SOME RESEARCH AND FIND OUT THAT I WASN'T THE ONLY ONE WITH THIS ISSUE SINC…
Read full complaint
JUST CHECKING THE TIRES NOTICE THE TIRE WEAR ON THE INSIDE SO TOOK THE TIRE OUT AND NOTICE THAT THE FRONT STRUT HAD A SHINE PART TO IT THAT INDICATES THAT THE FRONT TIRES WERE RUBBING AND CAUSE THE TWO FRONT TIRES TO WEAR OUT WITH THE WIRES COMING OUT DID SOME RESEARCH AND FIND OUT THAT I WASN'T THE ONLY ONE WITH THIS ISSUE SINCE THE DEALER WONT HELP I REPLACE THE FRONT TIRES AND IN THE PROCESS TO ALSO REPLACE STRUTS AND TIE RODS WHICH IT SEEMS TO BE THE PROBLEMS FOR EVERY GTO OWNERS THAT I CONTACT WITH THE 17 INCH WHEELS. *TR
2005 PONTIAC GTO WITH 18" PERFORMANCE TIRE/WHEEL PACKAGE. PREMATURE SUSPENSION BUSHING WEAR CAUSING PREMATURE TIRE WEAR AND ALIGNMENT ISSUES IN ONLY 14,000 MILES. TIRES ARE COMPLETELY WORN OUT ON THE INNER EDGE IN 14,000 MILES. FORTUNATELY, I CAUGHT THIS BEFORE THEIR WAS A BLOW OUT OF A STEERING AXLE TIRE WHICH COULD HAVE CAUSED…
Read full complaint
2005 PONTIAC GTO WITH 18" PERFORMANCE TIRE/WHEEL PACKAGE. PREMATURE SUSPENSION BUSHING WEAR CAUSING PREMATURE TIRE WEAR AND ALIGNMENT ISSUES IN ONLY 14,000 MILES. TIRES ARE COMPLETELY WORN OUT ON THE INNER EDGE IN 14,000 MILES. FORTUNATELY, I CAUGHT THIS BEFORE THEIR WAS A BLOW OUT OF A STEERING AXLE TIRE WHICH COULD HAVE CAUSED A LOSS OF VEHICLE CONTROL AND POSSIBLY A MVA. EVEN THOUGH THIS IS A WIDELY KNOWN PROBLEM GM HAS NOT ADDRESSED IT AND THE DEALERSHIP IS UNRESPONSIVE. FORTUNATELY THIS VEHICLE HAS THE 18" TIRE PACKAGE OR THE TIRE SIDE WALL WOULD BE RUBBING ON THE STRUT AS THEY DO ON THE VEHICLES WITH THE "STANDARD" 17" TIRE/WHEEL PACKAGE. *TR
HAVE HAD TO REPLACE THE FRONT TIRES TWICE NOW. THE FIRST TIME THE TIRES WERE SHOWING THE METAL CORDS ON THE INSIDE NEXT TO THE STRUTS. THE SECOND TIME THE CAR HAS HAD TWO BLOW OUTS, AGAIN THE FRONT TIRES (WHICH WERE NEWER TIRES, REPLACED AFTER THE FIRST SET WORE). CAR ONLY HAS 30000 MILES. BACK TIRES ARE STILL ORIGINAL WITH …
Read full complaint
HAVE HAD TO REPLACE THE FRONT TIRES TWICE NOW. THE FIRST TIME THE TIRES WERE SHOWING THE METAL CORDS ON THE INSIDE NEXT TO THE STRUTS. THE SECOND TIME THE CAR HAS HAD TWO BLOW OUTS, AGAIN THE FRONT TIRES (WHICH WERE NEWER TIRES, REPLACED AFTER THE FIRST SET WORE). CAR ONLY HAS 30000 MILES. BACK TIRES ARE STILL ORIGINAL WITH PLENTY OF TREAD LEFT ON THEM. *TR
2005 PONTIAC GTO 6/22/08 HAD LEFT TIRE REAR BLOWOUT WHICH RESULTED IN A FRONT END CRASH, THE AIRBAGS DIDN'T DEPLOY,AND INJURIES OCCURRED. ALSO DAMAGE RESULTED TO THE SIDES AND REAR OF THE CAR. INSURANCE DECIDED IT WAS A TOTAL LOSS DUE TO $17,000 IN DAMAGE. A BLOWOUT ALSO OCCURRED 12/2007 ON THE LEFT REAR TIRE WHILE ON THE INTERS…
Read full complaint
2005 PONTIAC GTO 6/22/08 HAD LEFT TIRE REAR BLOWOUT WHICH RESULTED IN A FRONT END CRASH, THE AIRBAGS DIDN'T DEPLOY,AND INJURIES OCCURRED. ALSO DAMAGE RESULTED TO THE SIDES AND REAR OF THE CAR. INSURANCE DECIDED IT WAS A TOTAL LOSS DUE TO $17,000 IN DAMAGE. A BLOWOUT ALSO OCCURRED 12/2007 ON THE LEFT REAR TIRE WHILE ON THE INTERSTATE WHICH DIDN'T RESULT IN A CRASH OR INJURIES. *TR
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. WHILE DRIVING AT ANY SPEED, BUT PARTICULARLY AT HIGHWAY SPEEDS, THE FRONT DRIVER SIDE STRUT RUBS AGAINST THE TIRE AND CAUSES PREMATURE WEAR AND TIRE SHREDDING. WHEN THE VEHICLE WAS INSPECTED BY A MECHANIC AND LIFTED UP ON A RACK, THE UNEVEN TIRE WEAR WAS VISIBLE. THE REAR WHEEL WELL HAS…
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC GTO. WHILE DRIVING AT ANY SPEED, BUT PARTICULARLY AT HIGHWAY SPEEDS, THE FRONT DRIVER SIDE STRUT RUBS AGAINST THE TIRE AND CAUSES PREMATURE WEAR AND TIRE SHREDDING. WHEN THE VEHICLE WAS INSPECTED BY A MECHANIC AND LIFTED UP ON A RACK, THE UNEVEN TIRE WEAR WAS VISIBLE. THE REAR WHEEL WELL HAS A METAL FOIL THAT GOES UNDERNEATH THE WHEEL WELL. WHEN TURNING TO THE LEFT OR RIGHT, THE METAL FOIL GRAZES AND SLICES THE TIRES. UPON REPLACING THE TIRE, THE CONTACT FOUND OTHER TIRES WITH PREMATURE WEAR AS WELL. THE CURRENT MILEAGE WAS 24,000 AND FAILURE MILEAGE WAS 21,000.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE07010 · Front Strut To Tire Interference
Opened Feb 16, 2007 · Closed Aug 8, 2007
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:macpherson Strut; Tires; Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Additional source detail variants (5)
Suspension:front
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension:front:macpherson Strut
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH