IllustrationWHILE DRIVING MY CAR ON STREET I WAS STRUCK ON THE PASSENGER SIDE IN A INTERSECTION WHEN A CHEVY MAXI VAN STRUCT ME WHEN RUNNING A RED LIGHT. MY AIRBAG DID NOT DEPLOY AND MY VEHICLE WAS TOTALLED. I SUSTAINED BODY INJURIES SUCH AS BACK AND NECK AND FINANCIAL HARDSHIP. I HAVE NEVER RECOVERED FROM THESE INJURIES.
2006 Pontiac Grand Prix
Owner reports · Recalls · Investigations
More warning signs than most Grand Prix years
Owner complaints for the 2006 Pontiac Grand Prix are substantially higher than the model-year median of 88.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Prix years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
2225–50K
3150–75K
3775–100K
46100–150K
40150K+
188 reports with mileage · 51 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports21 fire reports16 injury reports
Structure complaints
4 reportsABOUT 6 MONTHS AFTER PURCHASING MY CAR I NOTICED MY DASH BOARD STARTING TO CREAK AND MAKE NOISES, WITHIN 2 MONTHS THE LEFT DASH BOARD SPLIT AND NOW 2 YEARS LATER SO HAS THE RIGHT SIDE OF THE DASH BOARD CRACKED. MY HUSBAND DETAILS MY CAR AND KEEPS THE DASH PROTECTED BUT TO NO AVAIL I AM DRIVING AROUND WITH A CREAKING AND CRACKED …
Read full complaint
ABOUT 6 MONTHS AFTER PURCHASING MY CAR I NOTICED MY DASH BOARD STARTING TO CREAK AND MAKE NOISES, WITHIN 2 MONTHS THE LEFT DASH BOARD SPLIT AND NOW 2 YEARS LATER SO HAS THE RIGHT SIDE OF THE DASH BOARD CRACKED. MY HUSBAND DETAILS MY CAR AND KEEPS THE DASH PROTECTED BUT TO NO AVAIL I AM DRIVING AROUND WITH A CREAKING AND CRACKED DASH BOARD. *TR
I AM WRITING A COMPLAINT REGARDING MY CAR. I PURCHASED THE VEHICLE IN 2006. I HAD TO REPLACE THE STABILIZER PIN, WHEEL BEARINGS, FRONT BRAKES AND IT SEEMS LIKE SOMETHING IS WRONG IN THE STEERING WHEEL. PARTS INSIDE OF THE CAR ARE FALLING OFF. I'VE HAD TO BUY NEW TIRES DUE TO ALL THESE FRONT END PROBLEMS WITH THE CAR AND NOT KNOW…
Read full complaint
I AM WRITING A COMPLAINT REGARDING MY CAR. I PURCHASED THE VEHICLE IN 2006. I HAD TO REPLACE THE STABILIZER PIN, WHEEL BEARINGS, FRONT BRAKES AND IT SEEMS LIKE SOMETHING IS WRONG IN THE STEERING WHEEL. PARTS INSIDE OF THE CAR ARE FALLING OFF. I'VE HAD TO BUY NEW TIRES DUE TO ALL THESE FRONT END PROBLEMS WITH THE CAR AND NOT KNOWING UNTIL IT HAS CAUSED A PROBLEM SOMEWHERE ELSE. NOW THE TIRES THAT I PURCHASED ABOUT A 1 1/2 YEAR AGO IS NOW VERY WORN FROM THESE FRONT END PROBLEMS WITH THE CAR. I AM VERY UPSET BECAUSE I FEEL LIKE, I HAVE BEEN ROBBED. I AM A SINGLE PARENT WORKING 2 FULL-TIME JOBS JUST TO PAY FOR A CAR THAT SEEMS TO BE BREAKING DOWN ON ME NO MATTER HOW MUCH I TRY TO TAKE TOTAL CARE OF IT. PAYING A VERY COSTLY CAR NOTE, INSURANCE, AND WARRANTY. I TELL MYSELF IS THIS WHAT I AM WORKING SO HARD TO PAY FOR. THIS CAR OUT WEIGHS WHAT I PAY FOR RENT EACH MONTH. I REMEMBER A TIME THAT PONTIAC MADE GOOD CARS THAT WAS BUILT TO LAST AS LONG AS YOU TAKE CARE OF IT. NOW IT SEEMS THAT IT IS BUILT TO BREAK DOWN BEFORE YOU COULD PAY THERE VEHICLES OFF. I AM REALLY FURIOUS AND OUTRAGED WITH THIS CAR THAT I CAN'T REALLY RELY ON. *TR UPDATED 06/02/09.*JB
I HAVE A 2006 PONTIAC GRAND PRIX, AND IT SEEMS TO HAVE PAINT PROBLEMS. IT IS A BLUE COLORED CAR AND THE LEAST LITTLE SCATCH SHOWS UP. NOT ONLY THAT, THERE SEEMS TO BE NO BOTTOM COAT OF PAINT, THEREFORE EXPOSING THE METAL. ALSO, THE WINDSHIELD CRACKED WITHOUT FORCE OR HIT...IT STARTED FROM THE BOTTOM..ALSO THE WINDSHIELD WIPER…
Read full complaint
I HAVE A 2006 PONTIAC GRAND PRIX, AND IT SEEMS TO HAVE PAINT PROBLEMS. IT IS A BLUE COLORED CAR AND THE LEAST LITTLE SCATCH SHOWS UP. NOT ONLY THAT, THERE SEEMS TO BE NO BOTTOM COAT OF PAINT, THEREFORE EXPOSING THE METAL. ALSO, THE WINDSHIELD CRACKED WITHOUT FORCE OR HIT...IT STARTED FROM THE BOTTOM..ALSO THE WINDSHIELD WIPERS OUTER LAYER MELTED. *TR
Official recalls
114V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
PE09025 · Power Steering Fluid Leaks - Fires
Opened May 13, 2009 · Closed Oct 2, 2009
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Steering:hydraulic Power Assist:hose, Piping, And Connections
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Steering:hydraulic Power Assist:power Steering Fluid
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Steering:hydraulic Power Assist System
GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE, MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.