TL*THE CONTACT OWNS A 2000 PONTIAC GRAND AM. THE CONTACT STATED THE MOTOR MOUNT HAD FRACTURED AND FELL INTO THE ENGINE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE MOTOR MOUNT WAS REPLACED. IN ADDITION, THE VEHICLE ALSO HAD FAILURES WITH THE RACK AND PINION AND WHEN TAKEN TO THE DEALER, IT WAS FOUND THAT THE SCREWS WERE LOOSE …
Read full complaint
TL*THE CONTACT OWNS A 2000 PONTIAC GRAND AM. THE CONTACT STATED THE MOTOR MOUNT HAD FRACTURED AND FELL INTO THE ENGINE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE MOTOR MOUNT WAS REPLACED. IN ADDITION, THE VEHICLE ALSO HAD FAILURES WITH THE RACK AND PINION AND WHEN TAKEN TO THE DEALER, IT WAS FOUND THAT THE SCREWS WERE LOOSE AND NEEDED TO BE TIGHTENED TO CORRECT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,932 AND THE CURRENT MILEAGE WAS 150,000. UPDATED 11/03/10. *LJ UPDATED 11/29/10 *CN THE CONSUMER STATED THE MOTOR MOUNT FAILED WHICH LED INTAKE GASKET NEEDING TO BE REPLACED. THE WINDOWS WOULD STICK ON OCCASIONS AND A TIMES WOULD FALL DOWN INSIDE THE DOOR. THE OIL FROM THE ENGINE BECAME MIXED WITH THE ANTI-FREEZE. UPDATED 11/30/10
NHTSA ODI #10326685
Mileage unknown · Nov 8, 2009
Visibility
MY PROBLEM STARTED SUMMER OF 2008,I WAS DRIVING ON HIGHWAY12 TRAVELING 55MPH. I FELT AS IF MY CAR WAS LIFTING ITSELF OFF THE GROUND SEVERAL MINS LATER I HEARD A LOUD BOOM. AND WAS SLIGHTLY BLINDED BY THE SUNLIGHT. I THOUGHT I WAS HIT BY ANOTHER CAR. BUT IT WAS MY SUNROOF THAT CAME OFF. IT HAS BEEN WELL OVER A YEAR I STILL HAVE …
Read full complaint
MY PROBLEM STARTED SUMMER OF 2008,I WAS DRIVING ON HIGHWAY12 TRAVELING 55MPH. I FELT AS IF MY CAR WAS LIFTING ITSELF OFF THE GROUND SEVERAL MINS LATER I HEARD A LOUD BOOM. AND WAS SLIGHTLY BLINDED BY THE SUNLIGHT. I THOUGHT I WAS HIT BY ANOTHER CAR. BUT IT WAS MY SUNROOF THAT CAME OFF. IT HAS BEEN WELL OVER A YEAR I STILL HAVE NOT BEEN ABLE TO HAVE SUNROOF REPAIRED. MOST REPAIR SHOPS REFER ME TO THE PONTIAC DEALER AS THEY HAVE NEVER HEARD OF A SUNROOF COMING OFF UNLESS DEFECTED. I CALLED THE PONTIAC DEALER IN STOCKTON, CA TWICE EACH TIME I WAS TOLD SUNROOFS FLY OFF ALL THE TIME, I COULD TAKE IT TO ANY REPAIR SHOP OF MY CHOICE OR SEE IF INSURANCE WILL COVER REPAIRS. I ASKED WHAT SHOPS THEY USED OR RECOMMEND EACH TIME AGENTS COULD NOT RECALL ANYTHING. I CALLED MY INSURANCE THEY TOO HAVE NEVER HEARD OF THIS, SINCE NOT FROM AN ACCIDENT OR NATURAL DISASTER I WOULD BE RESPONSIBLE FOR COST OF REPAIRS. I HAVE TWO SMALL CHILDREN WHO I TRANSPORT IN VEHICLE DRIVING WITHOUT A SUNROOF WAS VERY STRESSFUL AND NOT SAFE FOR THE HEALTH OF MY CHILDREN NOR MYSELF. AFTER THE RUN AROUND, TRYING TO TAPE DOWN EXPOSED AREA TO NO AVAIL, LOST OF HEARING. I DECIDED TO GO TO TAPS, THERE, THEY WERE ABLE TO CUT A PIECE OF HARD PLASTIC TO COVER TEMPORARILY. I FEEL AS A CONSUMER I HAVE BEEN GIVEN THE RUN AROUND AND I 'M AT A LOST FOR WHERE I CAN TAKE MY CAR LOCALLY TO HAVE SUNROOF REPAIRED PERMANENTLY. MY SECOND ISSUE IS WITH MY IGNITION LOCKS UP ON ME AND WILL NOT LET ME DRIVE.A SECURITY LIGHT THAT IS LIT UP AS WELL, AS I DO NOT HAVE A SECURITY SYSTEM, I CALLED DEALER I WAS TOLD IT MAY HAVE TO DO WITH MY KEY REMOTE, I STATED I DON'T HAVE KEY, I WAS THEN TOLD IT MAY BE I COPIED KEYS AND THE COPY IS NOT BEING READ BY CAR. I INFORMED THEM I USE THE ORIGINAL KEY FOR CAR I WAS GIVEN WHEN I PURCHASED CAR. THE DEALER DID NOT KNOW WHY AND REFERRED ME TO HAVE CAR CHECKED. I HAD MAINTENANCE DONE, EACH SHOP COULD NOT FIND ANYTHING OUT OF THE ORDINARY FOR THE PROBLEM. I'M DISAPPOINTED AND FRUSTRATED. *TR
NHTSA ODI #10291402
Mileage unknown · Apr 9, 2009
Visibility
I OWN A PONTIAC 2000 GRAND AM SE POWER WINDOWS. IT STARTED WITH DRIVERS SIDE WINDOW. PLASTIC PIECE THAT HOLDS WINDOW UP CRUMPLED UP AND WINDOW FELL THROUGH. HAD IT REPAIRED REPLACED PLASTIC PIECE. DID NOT WORK. THIS IS 4/2009 ALL THE WINDOWS HAVE DONE THE SAME THING. 300.00 DOLLARS TO REPLACE EACH WINDOW REPLACEMENT MOTOR. I HA…
Read full complaint
I OWN A PONTIAC 2000 GRAND AM SE POWER WINDOWS. IT STARTED WITH DRIVERS SIDE WINDOW. PLASTIC PIECE THAT HOLDS WINDOW UP CRUMPLED UP AND WINDOW FELL THROUGH. HAD IT REPAIRED REPLACED PLASTIC PIECE. DID NOT WORK. THIS IS 4/2009 ALL THE WINDOWS HAVE DONE THE SAME THING. 300.00 DOLLARS TO REPLACE EACH WINDOW REPLACEMENT MOTOR. I HAVE A 4 DOOR. *TR
NHTSA ODI #10264837
175,348 miles · May 5, 2008
Visibility
THE POWER WINDOW REGULATORS IN MY 2 DOOR 2000 PONTIAC GRAND AM. CONTINUE TO FAIL. I HAVE REPLACED FOUR OF THE REGULATORS SINCE I HAVE BOUGHT THE CAR IN 2003. THESE WINDOW REGULATORS COST $112.00 EVERY TIME THEY FAIL. DEPENDING ON HOW AND WHEN, THESE WINDOW REGULATORS FAIL THERE IS A POSSIBILITY OF THE GLASS FALLING INTO THE DOO…
Read full complaint
THE POWER WINDOW REGULATORS IN MY 2 DOOR 2000 PONTIAC GRAND AM. CONTINUE TO FAIL. I HAVE REPLACED FOUR OF THE REGULATORS SINCE I HAVE BOUGHT THE CAR IN 2003. THESE WINDOW REGULATORS COST $112.00 EVERY TIME THEY FAIL. DEPENDING ON HOW AND WHEN, THESE WINDOW REGULATORS FAIL THERE IS A POSSIBILITY OF THE GLASS FALLING INTO THE DOOR AND BREAKING THE GLASS. WHEN THE FIRST ONE FAILED, I HAD TO REPLACE THE WINDOW GLASS, IN RETURN MADE AN ADDITIONAL COST OF $120.00. I HAVE SPOKEN WITH OTHER LOCAL OWNERS AND THEY ALL HAVE HAD THE SAME TROUBLES WITH THESE WINDOW REGULATORS. I FEEL THAT THIS ISSUE SHOULD BE ADDRESSED AND SOLVED WITH A REDESIGN OF THE WINDOW REGULATOR SYSTEM AT THE COST OF GENERAL MOTORS. *TR
NHTSA ODI #10226692
Mileage unknown · Feb 28, 2008
Visibility
2000 GRAND AM I HAVE PROBLEMS WITH MY MOTOR TO MY WINDOWS I HAVE REPLACED 1 ON THE PASSENGER FRONT SIDE... NOW THE 1 ON THE DRIVERS FRONT AND THE PASSENGERS SIDE IN THE BACK ARE OUT ! THIS IS COSTING ME $300.00 A WINDOW. CAN I GET SOME TYPE OF DISCOUNT OR SOME TYPE OF HELP WITH THIS PROBLEM ! THE CAR HAS BEEN OWNED BY A DMV …
Read full complaint
2000 GRAND AM I HAVE PROBLEMS WITH MY MOTOR TO MY WINDOWS I HAVE REPLACED 1 ON THE PASSENGER FRONT SIDE... NOW THE 1 ON THE DRIVERS FRONT AND THE PASSENGERS SIDE IN THE BACK ARE OUT ! THIS IS COSTING ME $300.00 A WINDOW. CAN I GET SOME TYPE OF DISCOUNT OR SOME TYPE OF HELP WITH THIS PROBLEM ! THE CAR HAS BEEN OWNED BY A DMV AS A GOFFER TYPE CAR FOR A COUPLE OF YEARS (SO NOT DROVE TOO MUCH), THAN I BROUGHT IT 4 YRS (?) AGO AND I'M SINGLE (NO KIDS)... SO IT ISN'T THAT THE WINDOWS HAVE HAD ABUSE ! *TR
NHTSA ODI #10219641
Mileage unknown · Jan 18, 2008
Visibility
POWER WINDOWS FAIL TO FUNCTION. THE FRONT AND REAR DRIVERS-SIDE WINDOWS MADE A POPPING NOISE AND NOW WILL NOT ROLL UP. THE FRONT PASSENGER WINDOW WILL NOT ROLL DOWN AT ALL. WHEN THE FIRST WINDOW STOPPED WORKING I WAS TOLD THAT THEY WOULD HAVE TO REPLACE THE ENTIRE MOTOR SYSTEM WHICH I COULD NOT AFFORD. NO WINDOW PARTS HAVE…
Read full complaint
POWER WINDOWS FAIL TO FUNCTION. THE FRONT AND REAR DRIVERS-SIDE WINDOWS MADE A POPPING NOISE AND NOW WILL NOT ROLL UP. THE FRONT PASSENGER WINDOW WILL NOT ROLL DOWN AT ALL. WHEN THE FIRST WINDOW STOPPED WORKING I WAS TOLD THAT THEY WOULD HAVE TO REPLACE THE ENTIRE MOTOR SYSTEM WHICH I COULD NOT AFFORD. NO WINDOW PARTS HAVE BEEN FIXED OR REPLACED. *TR
NHTSA ODI #10215398
140,000 miles · Jan 20, 2007
Visibility
THE FAN ONLY WORKS IN 3,4 AND 5 SETTINGS. 1 & 2 DO NOT WORK. I SEE THIS IS GETTING TO BE A COMMON PROBLEM. *JB
NHTSA ODI #10179225
85,000 miles · Aug 2, 2006
Visibility
DRIVER SIDE MIRROR FELL OFF WHILE WE WHERE ON A ROAD TRIP. IT WAS STILL HANGING BY THE WIRES BUT THE SCREW BRACKETS CRACKED. *JB
NHTSA ODI #10164172
28,613 miles · Dec 9, 2005
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
DT: THE CONTACT'S VEHICLE SUDDENLY ACCELERATED. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP SEVERAL TIMES FOR DIAGNOSTIC TESTING, NO CODES HAVE BEEN DETECTED. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *AK THE ABS LIGHT HAD ILLUMINATED, THE DEALER FOUND LACK OF VOLTS FOR EBCM, THE PROBLEM WAS TRACED TO A FAULTY RELA…
Read full complaint
DT: THE CONTACT'S VEHICLE SUDDENLY ACCELERATED. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP SEVERAL TIMES FOR DIAGNOSTIC TESTING, NO CODES HAVE BEEN DETECTED. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *AK THE ABS LIGHT HAD ILLUMINATED, THE DEALER FOUND LACK OF VOLTS FOR EBCM, THE PROBLEM WAS TRACED TO A FAULTY RELAY. THE LOWER INTAKE GASKET HAD RUPTURED. THE HORN HAD STOPPED WORKING DUE TO A BLOWN FUSE. THE LEFT POWER WINDOW WAS SLOW TO ROLL UP. THE REAR DEFOGGER GRID SHORTED OUT. UPDATED 01/11/06. *JB
NHTSA ODI #10144824
32,000 miles · Aug 26, 2005
Visibility
2000 PONTIAC GRAND AM SE1 SEDAN ... POWER WINDOW REGULATORS FAILED BECAUSE OF SUBSTANDARD PLASTIC BRACKET THAT BREAKS AND CAUSES THE MOTOR TO SEIZE. BECAUSE OF THIS FAILURE, I CANNOT ROLL DOWN ANY OF MY WINDOWS. I LIVE IN THE MIDDLE OF THE DESERT AND LIKE TO HAVE MY WINDOWS DOWN. THE DEALERSHIP QUOTED ME $250.00 FOR EACH WIND…
Read full complaint
2000 PONTIAC GRAND AM SE1 SEDAN ... POWER WINDOW REGULATORS FAILED BECAUSE OF SUBSTANDARD PLASTIC BRACKET THAT BREAKS AND CAUSES THE MOTOR TO SEIZE. BECAUSE OF THIS FAILURE, I CANNOT ROLL DOWN ANY OF MY WINDOWS. I LIVE IN THE MIDDLE OF THE DESERT AND LIKE TO HAVE MY WINDOWS DOWN. THE DEALERSHIP QUOTED ME $250.00 FOR EACH WINDOW PLUS THE COST OF LABOR AND WAS TOLD THAT IT WOULD TAKE 2 WEEKS FOR THE PARTS AND THEN THEY WOULD HAVE MY CAR FOR APPROX 3 DAYS. I ASKED ABOUT A RENTAL AND THEY SAID THAT I WOULD HAVE TO PAY OUT OF POCKET FOR IT IF I WANTED ONE. I HAVE RESEARCHED THIS AND FOUND UPWARDS OF 40 SOME ODD COMPLAINTS ON DIFFERENT WEB SITES PERTAINING TO 1998-2004 MODELS WITH THIS SAME ISSUE. I HAVE FOUND AFTER MARKET PARTS TO REPAIR THEM MYSELF AND IT WILL STILL COST ME $400.00 BECAUSE I HAVE TO REPLACE THE ENTIRE POWER WINDOW REGULATOR AND MOTOR FOR EACH DOOR. MY BROTHER HAS A 2001 MODEL WITH THE SAME PROBLEM. *JB
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BOLT THAT ATTACHES THE REAR SUSPENSION TRAILING ARM TO THE LEFT REAR KNUCKLE MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATIONS DURING ASSEMBLY.
Consequence & remedy
Consequence: THE BOLT COULD BACK COMPLETELY OUT OF THE JOINT AFFECTING VEHICLE CONTROL.
Remedy: DEALERS WILL TIGHTEN THIS BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration