NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
849 reportsMileage unknown · Jul 22, 2023
Forward Collision AvoidanceService BrakesStructureCrashInjury
Our braking system on this car failed us, and is probably crushed by now at no fault of my own. My safety was at–risk when the brakes lost pressure and if it wasn’t for our seatbelts, I could’ve been thrown through the windshield. I hereby declare that [XXX] deliberately caused our accident and lied about being blinded. [XXX…
Read full complaint
Our braking system on this car failed us, and is probably crushed by now at no fault of my own. My safety was at–risk when the brakes lost pressure and if it wasn’t for our seatbelts, I could’ve been thrown through the windshield. I hereby declare that [XXX] deliberately caused our accident and lied about being blinded. [XXX] lost her son—[XXX]—and was jealous of my opportunity to do what he couldn’t. Her other son—[XXX]—choose not to attend college and contraband drugs among other things. [XXX] and his mother [XXX] were also jealous of me for having an opportunity that [XXX] chose not to take. They blame me for Chastity [XXX] & [XXX] turning their parental rights over to the Commonwealth of Kentucky. How their oldest daughter being raped by her paternal grandmother’s husband has to do me is absurd and childish in my opinion. Murray Police Department was called on October 23, 2014 at 7:23 am in reference to 2 vehicle collisions to inspected and verified by law in the Commonwealth of Kentucky. [XXX] and his sister [XXX] their colleagues at Seacrest Rehabilitation—Healthcare Center and [XXX] or [XXX] Consolidated Schools with the latter allegations. Ma and I later went to Dr. [XXX] chiropractic center for evaluation, he can verify her back or knee problems as they related to this incident. [XXX] can verify us suffering from medicalised homelessness, despite state law in the Commonwealth of Pennsylvania declaring residential leases cannot exceed three years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11533840
Mileage unknown · Jun 3, 2023
Electrical SystemFuel/propulsion SystemVehicle Speed Control
The gas gauge will show full then without warning quickly drop to “E” and the low fuel indicator will ding and the light will come on then just as quickly as it started it will go back to full or 2/3rds the slow creep back to the full position. (The tank was not full) While driving all the electrical components start going wild…
Read full complaint
The gas gauge will show full then without warning quickly drop to “E” and the low fuel indicator will ding and the light will come on then just as quickly as it started it will go back to full or 2/3rds the slow creep back to the full position. (The tank was not full) While driving all the electrical components start going wild, everything goes on and off quickly. The accelerator will rev(while foot is on or off accelerator) and drop over and over (as if there were bad gas in it) then go back to normal. This happens while I’m on the road and is a massive hazard. I’m so afraid this will cause an accident that leads to loss of life.
NHTSA ODI #11525143
268,500 miles · Jul 26, 2019
Air BagsCrashInjury
TL* THE CONTACT OWNED A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING ABOUT 60 MPH, THE VEHICLE CRASHED INTO A CONCRETE BARRIER THAT WAS PUSHED OVER TO THE CONTACT'S LANE, FOLLOWING AN ACCIDENT THAT INVOLVED TWO TRUCKS. THE PASSENGER'S AIR BAG DEPLOYED. NO OTHER AIR BAG DEPLOYED, INCLUDING THE DRIVER'S. THERE WAS …
Read full complaint
TL* THE CONTACT OWNED A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING ABOUT 60 MPH, THE VEHICLE CRASHED INTO A CONCRETE BARRIER THAT WAS PUSHED OVER TO THE CONTACT'S LANE, FOLLOWING AN ACCIDENT THAT INVOLVED TWO TRUCKS. THE PASSENGER'S AIR BAG DEPLOYED. NO OTHER AIR BAG DEPLOYED, INCLUDING THE DRIVER'S. THERE WAS NO WARNING. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED MINOR ABRASIONS ON THE UPPER LEFT SHOULDER AND A BIG BUMP ON THE BACK. THE CONTACT WOULD BE GOING TO THE DOCTORS ATA A LATER POINT IN TIME. THE VEHICLE WAS TOTALED AND WAS TOWED TO A TOW YARD. THE DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 268,500.
NHTSA ODI #11235024
149,300 miles · Jul 2, 2016
Unknown Or Other
WINDSHIELD AND REAR WINDOW WERE BROKE AND BOTH HAVE BROKE INTO SHARDS. WINDSHIELD WAS APPROXIMENTLY 3" IN DIAMETER AND HALF INCH WIDE AND REAR WINDOW WAS APPROXIMENTLY 5" AND QUARTER IN WIDE.
NHTSA ODI #10882222
120,000 miles · Jun 15, 2016
Engine
THE OIL PRESSURE SWITCH WENT OUT CAUSING ME TO LOSE A MASSIVE AMOUNT OF OIL.
NHTSA ODI #10874327
125,000 miles · Jun 15, 2016
Exterior Lighting
THE HAZARD SWITCH MAKES A NOISE LIKE THE HAZARD LIGHTS ARE FLASHING WHEN THEY AREN'T EVEN ON. TO GET MY BLINKERS TO WORK I HAVE TO PUSH THE HAZARD BUTTON ON AND OFF SEVERAL TIMES.
NHTSA ODI #10874326
Mileage unknown · May 24, 2016
Unknown Or OtherVisibility/wiper
TO START WITH I READ THE COMPLAINTS AND WAS WONDERING HOW MANY COMPLAINTS DOES IT TAKE FOR SOMETHING TO BE RECALLED. THE DRIVER SIDE WINDOW FALLS, PASSENGER SIDE WINDOW HAS SCRATCHES ON IT FROM I AM GUESSING THE REGULATOR, THE DASH IS SEPARATED FROM THE WINDSHIELD, THE STRUTS, AND SPRINGS HAVE BEEN REPLACED, ABS LIGHT STAYS ON, …
Read full complaint
TO START WITH I READ THE COMPLAINTS AND WAS WONDERING HOW MANY COMPLAINTS DOES IT TAKE FOR SOMETHING TO BE RECALLED. THE DRIVER SIDE WINDOW FALLS, PASSENGER SIDE WINDOW HAS SCRATCHES ON IT FROM I AM GUESSING THE REGULATOR, THE DASH IS SEPARATED FROM THE WINDSHIELD, THE STRUTS, AND SPRINGS HAVE BEEN REPLACED, ABS LIGHT STAYS ON, THE SUSPENSION FEELS LIKE THE CAR IS FALLING APART THROUGH EVERY BUMP IN THE ROAD, THE HEADLIGHTS ARE FOGGED UP AND POINT DOWN. SIDE MIRROR HAS BEEN REPLACED AND WE VISITED SEVERAL AUTO YARDS TO TRY TO FIND A DASH AND SIDE MIRROR AND WOULDN'T YOU KNOW IT ALL THE MODELS OF THE GRAND AM WAS MISSING THE PASSENGER SIDE MIRROR WHERE IT HAD BROKE OFF AND ALL OF THEM THE DASH WAS SEPARATED FROM THE WINDSHIELD. I AM NOT SURE AS TO WHAT WILL HAPPEN IF THE DASH COMES COMPLETELY OFF BUT I DON'T WANT TO BE IN THE CAR WHEN IT DOES HAPPEN. AND I DON'T WANT TO DRIVE A CAR THAT HAS THIS MANY ISSUES AND NO ONE IS RESOLVING THE PROBLEMS. NOW THE CV BOOT HAS TO BE REPLACED. I AM SO FRUSTRATED RIGHT NOW SEEING THE AMOUNT OF COMPLAINTS AND ONLY SIX RECALLS THAT IS A PROBLEM. I AM SORRY TAKE RESPONSIBILITY FOR THE PRODUCT YOU PUT OUT. I GUESS IT WILL TAKE SOMEONE GETTING HURT OR KILLED TO RESOLVE THE PROBLEMS AND I HOPE YA'LL CAN SLEEP GOOD AT NIGHT KNOWING ALL THESE PROBLEMS HAVE EXISTED FOR THIS LONG AND NOTHING IS BEING DONE. TIRED OF PUTTING MONEY INTO SOMETHING THAT IS GOING TO CONTINUE WITH THE SAME ISSUES.
NHTSA ODI #10870578
149,000 miles · May 20, 2016
Steering
CLOCK SPRING HAS A DISK THAT IS NOT A UNIFORM DESGINE DUE TO IT SPLITTING AND BOWING OUT. STEERING WHEEL STICKS WHEN TURNED EITHER DIRECTION AND HORN IS SET OFF AS WELL. THE AIRBAG LIGHT IS ALSO ON AND WOULD ASSUME THAT IT WOULD NOT INFLATE IN THE EVENT OF A FRONTAL COLLISION. PONTIAC FEELS THAT THE DISK THAT SHOULD BE ONE SOLID…
Read full complaint
CLOCK SPRING HAS A DISK THAT IS NOT A UNIFORM DESGINE DUE TO IT SPLITTING AND BOWING OUT. STEERING WHEEL STICKS WHEN TURNED EITHER DIRECTION AND HORN IS SET OFF AS WELL. THE AIRBAG LIGHT IS ALSO ON AND WOULD ASSUME THAT IT WOULD NOT INFLATE IN THE EVENT OF A FRONTAL COLLISION. PONTIAC FEELS THAT THE DISK THAT SHOULD BE ONE SOLID PIECE THAT I BELIEVE IS TWO PIECES, IM RESPONSIBLE FOR THEIR DEFECTIVE CRAFTSMANSHIP.
NHTSA ODI #10865918
149,000 miles · May 12, 2016
Air BagsSteeringUnknown Or Other
IGNITION FROZEN, UNABLE TO MOVE VEHICLE WITHOUT TOW. NO SHIFT REALEASE, AND UNSAFE IN THE EVENT OF ENGINE STALL ON OPEN ROADWAYS. VEHICLE IS DEAD ONCE YOU SHIFT INTO PARK TO RESTART.
NHTSA ODI #10864610
174,000 miles · Mar 17, 2016
Electrical System
I BOUGHT THIS CAR FROM A FRIEND ABOUT 2WEEKS AGO AND HE TOLD ME THAT THERE WAS A RECALL ON THE IGNITION BUT HE TOOK IT UP THERE. BUT HE JUST DONE THIS ABOUT A WEEK BEFORE I BOUGHT THE CAR , SO NOW THE KEY WON'T EVEN TURN THE IGNITION TO START. WHAT CAN YOU DO FOR ME?THE CAR WAS IN MY DRIVEWAY WHEN I WENT OUT TO LEAVE AND NOTICE …
Read full complaint
I BOUGHT THIS CAR FROM A FRIEND ABOUT 2WEEKS AGO AND HE TOLD ME THAT THERE WAS A RECALL ON THE IGNITION BUT HE TOOK IT UP THERE. BUT HE JUST DONE THIS ABOUT A WEEK BEFORE I BOUGHT THE CAR , SO NOW THE KEY WON'T EVEN TURN THE IGNITION TO START. WHAT CAN YOU DO FOR ME?THE CAR WAS IN MY DRIVEWAY WHEN I WENT OUT TO LEAVE AND NOTICE THAT I COULD NOT.
NHTSA ODI #10850293
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Illustration