NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
849 reportsMileage unknown · Jun 22, 2006
Power TrainSteeringUnknown Or Other
1999 GRAND AM TRACK LIGHT ILLUMINATED, C-3 LIGHT ILLUMINATED, WATER LEAKED ON THE PASSENGER REAR FLOOR BOARD, THERE WAS A CLUNKING NOISE WHEN TURNING. *TS THE DEALER REFLASED THE PCM AT 3560 MILES. THE TRACK LIGHT ILLUMINATED AGAIN AT 3790 MILES. THIS TIME THE DEALER . THE BLOWER MOTOR SMELL BAD AND ONLY WORKED ON HIGH SPEE…
Read full complaint
1999 GRAND AM TRACK LIGHT ILLUMINATED, C-3 LIGHT ILLUMINATED, WATER LEAKED ON THE PASSENGER REAR FLOOR BOARD, THERE WAS A CLUNKING NOISE WHEN TURNING. *TS THE DEALER REFLASED THE PCM AT 3560 MILES. THE TRACK LIGHT ILLUMINATED AGAIN AT 3790 MILES. THIS TIME THE DEALER . THE BLOWER MOTOR SMELL BAD AND ONLY WORKED ON HIGH SPEED. IT WAS LATER DETERMINED THAT THE BLOWER MOTOR SHORTED OUT AND IT WAS REPLACED. THE VEHICLE HAD 8626 MILES. THE COMPARTMENT OVER THE REAR VIEW MIRROR WOULD NOT REMAIN LATCHED. *NM
NHTSA ODI #10161570
Mileage unknown · Jun 19, 2006
Electrical SystemFire
WHILE PARKED IN DRIVEWAY, CAR CAUGHT ON FIRE. CAR HAD BEEN SITTING FOR APPROXIMATELY 1 HOUR AFTER BEING DRIVEN A SHORT DISTANCE. COMPLETELY ENGULFED AND WAS A TOTAL LOSS. *JB
NHTSA ODI #10160206
Mileage unknown · May 21, 2006
Steering
I HAVE A 1999 PONTIAC GRAND AM AND THE RACK AND PINION HAS BROKE TWICE. THE LAST TIME BEING WHEN I WAS TURNING OUT ON AN INTERSTATE LOOSING ALL STEERING CAPABILITIES. *NM
NHTSA ODI #10157946
Mileage unknown · May 18, 2006
Visibility
POWER WINDOW REGULATOR FAILS CAUSING WINDOW TO FALL INTO DOOR. *JB
NHTSA ODI #10157811
65,000 miles · May 14, 2006
Engine And Engine Cooling
I HAVE A '99 PONTIAC GRAND AM WITH 65,000 MILES WITH A DEFECTIVE INTAKE MANIFOLD GASKET. I UNDERSTAND THIS IS A CLASS ACTION SUIT ISSUE IN CANADA AND IS A COMMON ISSUE IN THE USA ALSO. GM IS NOT ISSUING A RECALL EVEN THOUGH THERE IS EVIDENCE THIS IS A DEFECTIVE PART (OR DEFECTIVE BECAUSE OF THE DEXCOOL COOLANT). I SPOKE WITH …
Read full complaint
I HAVE A '99 PONTIAC GRAND AM WITH 65,000 MILES WITH A DEFECTIVE INTAKE MANIFOLD GASKET. I UNDERSTAND THIS IS A CLASS ACTION SUIT ISSUE IN CANADA AND IS A COMMON ISSUE IN THE USA ALSO. GM IS NOT ISSUING A RECALL EVEN THOUGH THERE IS EVIDENCE THIS IS A DEFECTIVE PART (OR DEFECTIVE BECAUSE OF THE DEXCOOL COOLANT). I SPOKE WITH GM AND WAS TOLD THIS WAS NOT A RECALL ITEM AND THE CAR WAS OUT OF THE WARRANTY PERIOD. FORTUNATELY, THIS PROBLEM WAS RECOGNIZED AND REMEDIED PRIOR TO RUINING THE ENGINE. THE REPAIR BILL WAS $558.84. *NM
NHTSA ODI #10157527
67,000 miles · May 9, 2006
Service Brakes, Hydraulic
BRAKES MAKE GRINDING NOISE AND SHAKE/PULSATE WHEN APPLIED AT ANY SPEED. BRAKE ROTORS WERE TURNED AND PADS REPLACED. THEN A WEEK LATER DEALER SAID CALIPERS WERE STICKING AND NEEDED REPLACED. NOW 2 MONTHS LATER IT NEEDS TO GO BACK TO DEALER FOR BRAKES PROBLEMS. *JB
NHTSA ODI #10157141
87,000 miles · Apr 18, 2006
Suspension
NO WARNING OR EVENT LEADING UP TO FAILURE. 1999 PONTIAC GRAND AM GT WITH 87,000 MILES. NEW TIRES IN DECEMBER OF 2004. WHILE BACKING OUT OF DRIVEWAY, RECEIVED SOME RESISTANCE, THOUGHT MY BRAKES WERE STICKING. PUSHED ON ACCELERATOR TO BACK OUT OF MY DRIVEWAY AND HEARD A LOUD SNAP AND RIPPING NOISE. AFTER I HEARD THE NOISE, I …
Read full complaint
NO WARNING OR EVENT LEADING UP TO FAILURE. 1999 PONTIAC GRAND AM GT WITH 87,000 MILES. NEW TIRES IN DECEMBER OF 2004. WHILE BACKING OUT OF DRIVEWAY, RECEIVED SOME RESISTANCE, THOUGHT MY BRAKES WERE STICKING. PUSHED ON ACCELERATOR TO BACK OUT OF MY DRIVEWAY AND HEARD A LOUD SNAP AND RIPPING NOISE. AFTER I HEARD THE NOISE, I STOPPED THE CAR AND PUT THE CAR BACK IN DRIVE TO PULL FORWARD. BEFORE HITTING THE ACCELERATOR TO PULL FORWARD I FELT THE FRONT RIGHT OF MY CAR FALL DOWN AND HEARD AN "AIR RELEASE" NOISE. I EXITED MY CAR AND DISCOVERED I HAD A FLAT TIRE. MY HUSBAND REMOVED MY TIRE THAT DAY AND FOUND THE WHOLE INSIDE WALL OF MY TIRE OPEN. THE SPRING COIL ON THE FRONT RIGHT HAND SIGHT WAS BROKEN IN TWO AND A JAGGED EDGE WAS EXPOSED. I HAD MY CAR TOWED TO A NEARBY SHOP. THEY HAVE NOT GIVEN ME AN ESTIMATE YET BUT THEY SUSPECT I NEED NEW SPRING COILS AND POSSIBLY A WHOLE NEW SUSPENSION. PENDING ON CORRECTIVE ACTION. I HAVE CONTACTED THE MANUFACTURER AND THEY HAVE ADVISED THAT THERE ARE NO RECALLS WITH THIS DEFECT. THIS IS A SAFETY HAZARD. IF I WAS DRIVING AT HIGHWAY SPEEDS AND MY TIRE BLEW, I COULD HAVE KILLED MYSELF. I HAVE RESEARCHED OTHER WEBSITES SUCH AS MYCARFACTS.COM AND HAVE FOUND SEVERAL COMPLAINTS OF THIS SAME THING HAPPENING TO PEOPLE WITH 1999 PONTIAC GRAND AMS. I HAVE ALSO READ THE NHTSA HAS DONE AN INVESTIGATION (EA03021 AND PE03031). I AM WRITING TO SUBMIT MY COMPLAINT IN HOPES THAT SOME ACTION WILL COME OUT OF THIS. IT IS VERY SAD THAT A COMPANY WOULD ALLOW THIS TO CONTINUE TO HAPPEN, ESPECIALLY HERE IN AMERICA. MY SISTER IS 8 MONTHS PREGNANT AND DRIVES A GRAND AM ALSO. I WORRY FOR HER SAFETY. IS IT GOING TO TAKE A DEATH FOR THIS MATTER TO BE ADDRESSED? THANKS FOR YOUR TIME. *JB
NHTSA ODI #10155573
61,000 miles · Mar 17, 2006
Electrical SystemEngine And Engine Cooling
DT*: THE CONTACT STATED WHILE DRIVING 60 MPH ALL THE LIGHTS ON THE DASH FAILED AND THE ENGINE STALLED. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD. AFTER THE VEHICLE WAS RESTARTED, IT WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY REPLACED THE IGNITION SWITCH AND CYLINDER, WHICH REMEDIED THE PROBLEM.
NHTSA ODI #10152962
55,000 miles · Mar 14, 2006
Electrical System
SECURITY LIGHT\PASSCODE, PASSLOCK IGNITION ON GRAND AM GT VEHICLE UNABLE TO START WHEN SECURITY LIGHT COMES ON- ANTI-THEFT SYSTEM IS DEFECTIVE. MUST LEAVE KEY IN ON POSITION TO RESET- TAKES A WHOLE 15 MINUTES TO RESET- LATE APPTS, SCHOOL DELAYS, ETC... NOW PASSCODE FEATURE IS DEFECTING THE ABS & TRAC FEATURES ON CAR- COST OF R…
Read full complaint
SECURITY LIGHT\PASSCODE, PASSLOCK IGNITION ON GRAND AM GT VEHICLE UNABLE TO START WHEN SECURITY LIGHT COMES ON- ANTI-THEFT SYSTEM IS DEFECTIVE. MUST LEAVE KEY IN ON POSITION TO RESET- TAKES A WHOLE 15 MINUTES TO RESET- LATE APPTS, SCHOOL DELAYS, ETC... NOW PASSCODE FEATURE IS DEFECTING THE ABS & TRAC FEATURES ON CAR- COST OF REPAIR FOR NEW IGNITION SYSTEM & OTHER NECESSARY PARTS RELATING TO PASSLOCK = SECURITY DEFECT IN CAR FROM DEALERSHIP IS CLOSE TO $600, THIS AMOUNT DOES NOT INCLUDE LABOR CHARGES. *NM
NHTSA ODI #10152730
Mileage unknown · Mar 10, 2006
Suspension
THERE WERE NO EVENTS LEADING UP TO THE FAILURE. ONE DAY AFTER WORK, I GOT INTO MY CAR AND AS I BACKED OUT OF THE PARKING SPOT, THE DRIVER'S SIDE FRONT COIL SPRING BROKE. THE BROKEN COIL SPRING THEN LODGED ITSELF IN MY FRONT DRIVER'S SIDE TIRE, COMPLETELY DESTROYING THE TIRE AND RENDERING THE CAR UNDRIVABLE. THE TIRE AND COIL …
Read full complaint
THERE WERE NO EVENTS LEADING UP TO THE FAILURE. ONE DAY AFTER WORK, I GOT INTO MY CAR AND AS I BACKED OUT OF THE PARKING SPOT, THE DRIVER'S SIDE FRONT COIL SPRING BROKE. THE BROKEN COIL SPRING THEN LODGED ITSELF IN MY FRONT DRIVER'S SIDE TIRE, COMPLETELY DESTROYING THE TIRE AND RENDERING THE CAR UNDRIVABLE. THE TIRE AND COIL SPRING WERE REPLACED AT MY EXPENSE. THE OLD COIL SPRING IS AVAILABLE. *NM
NHTSA ODI #10152398
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Illustration