NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
33 reportsClear category filter60,000 miles · Oct 25, 2006
EquipmentFuel System, Gasoline
IN NOVEMBER 2004 MY "SERVICE ENGINE SOON" LIGHT CAME ON ALONG WITH THE "TRAC OFF" LIGHT. AFTER FLIPPING THROUGH MY CARS MANUAL I DECIDED TO HAVE IT SERVICED WITH THE DEALER I ORIGINALLY BOUGHT IT FROM. AT ONLY 60,000 MILES THEY DETERMINED ALL OF MY FUEL INJECTORS WENT BAD. I HAD TO REPLACE THESE AND WITH LABOR CHARGES IT COS…
Read full complaint
IN NOVEMBER 2004 MY "SERVICE ENGINE SOON" LIGHT CAME ON ALONG WITH THE "TRAC OFF" LIGHT. AFTER FLIPPING THROUGH MY CARS MANUAL I DECIDED TO HAVE IT SERVICED WITH THE DEALER I ORIGINALLY BOUGHT IT FROM. AT ONLY 60,000 MILES THEY DETERMINED ALL OF MY FUEL INJECTORS WENT BAD. I HAD TO REPLACE THESE AND WITH LABOR CHARGES IT COST ME NEARLY $1,000. APPROXIMATELY 11 MONTHS LATER, THE SAME LIGHTS STARTED TO COME ON AGAIN. I IMMEDIATELY DROVE THE CAR TO DEALER WHERE THEY PROCEEDED TO EXPLAIN THAT MY FUEL INJECTORS WENT BAD A SECOND TIME. THEY FIRST REPLACEMENTS WERE UNDER WARRANTY, I WAS REQUIRED TO PAY LABOR. UNFORTUNATELY THIS PAST WEEK THE LIGHTS FOR THE FUEL INJECTORS CAME ON AGAIN, AND IS CURRENTLY GETTING DIAGNOSED. THIS WILL BE MY THIRD SET OF FUEL INJECTORS IN 36 MONTHS. THE ONLY THING THE DEALER WILL DO IS REPLACE THE FUEL INJECTORS, BUT UNFORTUNATELY THEY CAN'T PROMISE THIS WON'T HAPPEN AGAIN. I FEEL THAT THE FUEL INJECTORS THAT WERE INITIALLY REPLACED, AND THE REPLACEMENTS AFTER THEM HAVE BEEN FAULTY. *NM
NHTSA ODI #10171787
130,000 miles · Aug 4, 2006
Equipment
DT*: THE CONTACT STATED THE AIR CONDITIONER WOULD NOT WORK UNLESS IT WAS SET ON HIGH. ON THE LOWER LEVELS, THE COMPRESSOR WOULD NOT INITIATE. THE AIR CONDITIONER WORKED UNTIL JANUARY, 2005. THE VEHICLE WAS NOT SERVICED. *AK UPDATED 10/25/2006 - *NM
NHTSA ODI #10164543
106,000 miles · Nov 15, 2005
Electrical SystemEngine And Engine CoolingEquipment
I BOUGHT MY 1999 GRAND AM IN OCT' 04. THE FIRST 2 MO. OF OWNING IT MY ALTERNATOR WENT OUT. A FEW MONTHS LATER I HAD TO REPLACE MY FRONT BRAKES. SHORTLY AFTER THAT MY(2ND) ALTERNATOR AND A/C PUMP WENT OUT NOT TO MENTION THE BATTERY TOO. OH AND NOT ONLY HAS THE SERVICE ENGINE LIGHT BEEN ON MOST OF THE TIME, A SECOND SERVICE ENGI…
Read full complaint
I BOUGHT MY 1999 GRAND AM IN OCT' 04. THE FIRST 2 MO. OF OWNING IT MY ALTERNATOR WENT OUT. A FEW MONTHS LATER I HAD TO REPLACE MY FRONT BRAKES. SHORTLY AFTER THAT MY(2ND) ALTERNATOR AND A/C PUMP WENT OUT NOT TO MENTION THE BATTERY TOO. OH AND NOT ONLY HAS THE SERVICE ENGINE LIGHT BEEN ON MOST OF THE TIME, A SECOND SERVICE ENGINE LIGHT CAME ON! I HAVE NEVER KNOWN A VEHICLE TO HAVE 2 SERVICE ENGINE LIGHTS ON AT THE SAME TIME!! WAS THIS SOME KIND OF PREMONITION!? AS SOON AS I GOT THE CAR BACK,I WENT AND PICKED MY KIDS UP TO GO TO THE FAIR. WE WERE NOT EVEN 2 MILES OUT OF TOWN YET WHEN MY ENGINE STARTED OVERHEATING. I HAD TO PULL OVER AND WAIT FOR QUITE SOMETIME BEFORE I COULD MAKE IT HOME SAFELY WITH MY CHILDREN. NOW MY CAR THAT I'VE SPENT A LOT OF MONEY ON, NOT JUST PURCHASING THE CAR,BUT ALSO IN PARTS IS CURRENTLY IN THE SHOP FOR EITHER A BLOWN HEAD GASKET OR THE ENGINE BLOCK IS DAMAGED. THE MECHANIC TOLD ME THIS IS HAPPENING TO A LOT OF THESE SPECIFIC CARS OR SHOULD I SAY ENGINE TYPE. NEVERTHELESS, THIS IS COSTLY AND VERY DANGEROUS TO EVERYONE WHO OWNS ONE OF THESE LEMONS!!!! SOMETHING NEEDS TO BE DONE REAL QUICK WITH THESE PROBLEMS OR THE MANUFACTURE OF THESE VEHICLES WILL BE PAYING FOR MORE THAN JUST PARTS! *CB *NM
NHTSA ODI #10142764
Mileage unknown · Nov 1, 2005
Electrical SystemEngine And Engine CoolingEquipment
I OWN A 1999 GRAND AM SE. EVER SINCE I BOUGHT THE CAR IN OCT '04 I HAVE BEEN HAVING NOTHING BUT PROBLEMS WITH IT. THIS PAST JUNE I HAD TO REPLACE THE ENGINE. LEADING UP TO THAT THE CAR WOULD DIE AT LEAST ONCE A WEEK. I WOULD BRING IT TO THE DEALER (MORE LIKE TOW IT) AND I WOULD ALWAYS BE TOLD NOTHING IS WRONG. THEN YET AGAIN IT …
Read full complaint
I OWN A 1999 GRAND AM SE. EVER SINCE I BOUGHT THE CAR IN OCT '04 I HAVE BEEN HAVING NOTHING BUT PROBLEMS WITH IT. THIS PAST JUNE I HAD TO REPLACE THE ENGINE. LEADING UP TO THAT THE CAR WOULD DIE AT LEAST ONCE A WEEK. I WOULD BRING IT TO THE DEALER (MORE LIKE TOW IT) AND I WOULD ALWAYS BE TOLD NOTHING IS WRONG. THEN YET AGAIN IT WOULD DIE. AFTER THAT THE STALLING BEGAN. I WOULD BE DRIVING AND THE CAR WOULD SHUT OFF. IT WOULD USUALLY TAKE UP TO 10 MINUTES TO TURN BACK ON. ONCE THE DEALER WENT "WELL MAYBE ITS YOUR LIGHTS, YOU LEAVE THEM ON." MY RESPONSE WAS HOW DO I LEAVE ON AUTOMATIC LIGHTS? I HAVE HAD TO REPLACE MY ALTERNATOR 3 TIMES AND HAVE HAD TO REPLACE MY BATTERY TWICE. IT GOT TO THE POINT THAT ONCE I SHUT OFF MY CAR THE ONLY WAY TO START IT WAS BY TAKING OUT THE MAIL RELAY CHIP FOR 2 MINUTES THAN REPLACING IT. THAN THE CAR WOULD START UP. FINALLY I WAS ON THE HIGH WAY AND OUT OF NO WHERE YOU HEAD A LOUD POP. THERE WENT THE HEADER, PISTONS, OIL GASKET. THE ENGINE BLEW. HOWEVER IT WAS NEVER A EFFECT OF THE OIL. I WAS ALWAYS CHECKING IT AND GETTING IT CHANGED ONCE EVER OTHER MONTH (I COMMUTED A LOT). SO I GOT A REBUILT ENGINE PUT IN AND THE PROBLEMS WENT AWAY... OR SO I THOUGHT. LAST NIGHT I WAS DRIVING AND ALL OF A SUDDEN MY CAR STARTED SHAKING. IT WENT FROM A LITTLE TO A GREAT AMOUNT. THE MUFFLER IS MAKING AN ODD PUFF PUFF NOISE AND THE EXHAUST SMELLS LIKE WINDSHIELD WASHER FLUID (ONLY WAS TO DESCRIBE IT). I PULLED IT INTO MY DRIVEWAY AND ON WENT THE TRAC OFF LIGHT AND THE SERVICE ENGINE SOON LIGHTS. THANK YOU. ALSO PRIOR TO THE NEW ENGINE MY CDS WOULD NO LONGER PLAY. I WOULD GET THE E20 ERROR AND THE CDS WOULD SPIT OUT. ANOTHER PROBLEM IS MY REAR PASSENGER WINDOWS HAVE SCRATCHES UP THE MIDDLE OF THEM. I CAN NOT FIGURE OUT WHERE THE MARKS ARE COMING FROM. *JB
NHTSA ODI #10141384
Mileage unknown · Jul 20, 2005
EquipmentService Brakes, AirSteeringCrashInjury
ABOUT MARCH 1, 2005, STEERING MECHANISM WOULD VIBRATE AND LOSE CONTROL. FRONT BRAKES WOULD PULL THE CAR TO THE RIGHT. A SUBSEQUENT MOTOR VEHICLE ACCIDENT OCCURRED ON FEBRUARY 7, 2005, ON I80, 7PM, GOING SOUTHBOUND. LUCKILY NO ONE WAS INJURED IN EITHER CAR ... MY CAR WAS HYDROPLANING DUE TO INCLEMENT WEATHER CONDITIONS.
NHTSA ODI #10129451
12,000 miles · Dec 31, 2004
EquipmentSteering
I HAVE HAD THE POWER STEERING RACK IN MY 99 GRAND AM REPLACED TWICE. THE LAST TIME WAS IN APRIL 2004. IT IS LEAKING AND NEEDS TO BE REPLACED AGAIN.*AK
NHTSA ODI #10104845
55,000 miles · Jun 28, 2004
Engine And Engine CoolingEquipment
SECOND NOTICE POSTED: INCE 2002: REPLACED ROTORS, TOO THIN WHEN CAR WAS MANUFACTURED. (NO RECALL EVER DONE). COOLING SYSTEM: ALTHOUGH THE MANIFOLD GASKET HAS BEEN REPLACED, THE WATER RESERVOIR CAP HAS BEEN REPLACED, THE RADIATOR FLUSHED REPEATEDLY, ENTIRE COOLING SYSTEM BLEED (TO REMOVE ANY EXCESS AIR FROM RADIATOR), SERPENTINE…
Read full complaint
SECOND NOTICE POSTED: INCE 2002: REPLACED ROTORS, TOO THIN WHEN CAR WAS MANUFACTURED. (NO RECALL EVER DONE). COOLING SYSTEM: ALTHOUGH THE MANIFOLD GASKET HAS BEEN REPLACED, THE WATER RESERVOIR CAP HAS BEEN REPLACED, THE RADIATOR FLUSHED REPEATEDLY, ENTIRE COOLING SYSTEM BLEED (TO REMOVE ANY EXCESS AIR FROM RADIATOR), SERPENTINE BELT REPLACED, ALL FUSES, INCLUDING THE AC RELAY FUSE/SWITCH, ALL SENSORS REPLACED, AND VARIOUS MECHANICS HAVE CHECKED THE ENTIRE CAR BUMPER-TO-BUMPER, IT CONTINUES TO LEAK ANTIFREEZE COOLANT BY FORCING THE WATER OUT OF THE RADIATOR INTO THE RESERVOIR AND OUT THROUGH THE OVERFLOW TUB (SMALL TUBE LOCATED ON RESERVOIR TANK). EXCESS PRESSURE BUILDING UP IN THE SYSTEM. LEAKING ANTIFREEZE ONCE CAR IS STOPPED. I HAVE TO REFILL THE TANK AT LEAST ONCE A WEEK. THIS PROBLEM (THE PONTIAC GRAND AM LEAKING COOLANT) IS A COMMON PROBLEM WITH ALL PONTIAC GRAND AM. RECALL TO SOME COMPONENT OF COOLING SYSTEM IS DIRE OVERDUE! THIS CAR IS AN OIL CHANGE EVERY THREE MONTHS, REGARDLESS OF 3000 MILES OR NOT, STILL OUT OF THE BLUE, THE LIFTERS ARE KNOCKING AND THE BELT IS MAKING A VERY HIGH PITCHED SCREECHING SOUND. BELIEVED TENSION PULLEY NEEDS REPLACING, WITH A POSSIBILITY THAT ALL OTHER PULLEYS NEED REPLACING. ITS NOT THE BELT; THE BELT HAS BEEN CONSIDERED BY THREE DIFFERENT MECHANICS HAS BEEN "BASICALLY NEW". ALSO, ALTHOUGH IT HAS ONLY HAPPENED THREE TIMES IN THE LAST SEVERAL MONTHS, THE ENGINE HAS STALLED. WHEN THIS ORIGINALLY HAPPENED I CHANGED THE GRADE OF GASOLINE I PUT IN THE CAR FROM 87 GRADE TO 89 GRADE. DIDN'T HELP. (NUMBER OF FAILURES: FOR COOLANT LEAKS: INFINITE). *AK
NHTSA ODI #10078909
38,000 miles · Feb 23, 2004
Equipment
WHILE DRIVING AT ANY SPEED AND WITHOUT ANY WARNING ANTI THEFT DEVICE ENGAGED, CAUSING VEHICLE TO STALL ON TWO DIFFERENT OCCASIONS, AND NEARLY CAUSING A COLLISION EACH TIME. *AK
NHTSA ODI #10059570
1,500 miles · Jan 15, 2004
EquipmentUnknown Or OtherVisibility
MY MAJOR COMPLAINT IS THE BLACK GLOSSY PAINT THAT IS PEELING FROM THE SIDE DOOR/REAR QUARTER WINDOW PILARS. THE DEALER SAID THAT THIS IS NOT COVERED UNDER WARRANTY, AND I HAVE HAD SEVERAL QUOTES TO HAVE IT FIXED WHICH ARE IN THE RANGE OF $250 TO $500. THE SIDE MIRROR FELL OFF IN A CAR WASH TWO MONTHS AFTER THE PURCHASE OF THIS V…
Read full complaint
MY MAJOR COMPLAINT IS THE BLACK GLOSSY PAINT THAT IS PEELING FROM THE SIDE DOOR/REAR QUARTER WINDOW PILARS. THE DEALER SAID THAT THIS IS NOT COVERED UNDER WARRANTY, AND I HAVE HAD SEVERAL QUOTES TO HAVE IT FIXED WHICH ARE IN THE RANGE OF $250 TO $500. THE SIDE MIRROR FELL OFF IN A CAR WASH TWO MONTHS AFTER THE PURCHASE OF THIS VEHICLE, HOWEVER THE DEALER DID FIX IT ONCE AT NO CHARGE. THE RADIO DISPLAY DOES NOT WORK RIGHT AWAY, AND USUALLY HAS TO WARM UP BEFORE I AM ABLE TO READ THE DIGITAL DISPLAY. I HAVE ALSO HAD PROBLEMS WITH A SENSOR, WHICH CAUSED THE VEHICLE NOT START, AND THE DEALER PAID FOR THAT SERVICE AS WELL. THE CHECK ENGINE LIGHT HAS BEEN ON ALMOST SINCE THE FIRST DAY I PURCHASED THIS VEHICLE, AND I HAVE HAD SEVERAL DIAGNOSTIC TESTS COMPLETED AT MY COSTS, HOWEVER THE LIGHT WILL GO OFF FOR A WHILE, AND THEN COME BACK ON.
NHTSA ODI #10071196
Mileage unknown · Jan 15, 2004
Air BagsEquipmentFuel System, Gasoline
1)SECOND TIME THEY CLEANED INJECTORS ADVISOR SAID IT WAS BECAUSE I USED 89 OCTANE INSTEAD OF 87 (2 DIGITAL READOUT ON RADIO BECOMES ILLEGIBLE COVERED BY FID. I DECLINED REPAIRS (3 AIR BAG THEY FOUND SIR COIL BAD I DECLINED TO PAY $400.00 FOR REPAIRS SHOULD HAVE BEEN COVERED BY FID OR GM HAS NEVER BEEN DEPLOYED.
NHTSA ODI #10069442
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Illustration