NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
33 reportsClear category filterMileage unknown · Nov 11, 2003
EquipmentVisibility
PASSENGER SIDE WINDOW CLIP BROKE,CAUSED RATTLING HAD REPAIRED FOR $120.00 THEN OCT. 2003 MY DRIVER SIDE WINDOW FELL INTO THE DOOR.AFTER ANOTHER $45.00 I FOUND OUT THAT YET ANOTHER CLIP HAD BROKE,AND NOW THE CABLE WAS BROKE TOO.TOTAL REPAIR WOULD NOW BE $290.00 PLEASE RECALL THIS--I BELIEVE MY PASSENGER SIDE WINDOW IS ABOUT …
Read full complaint
PASSENGER SIDE WINDOW CLIP BROKE,CAUSED RATTLING HAD REPAIRED FOR $120.00 THEN OCT. 2003 MY DRIVER SIDE WINDOW FELL INTO THE DOOR.AFTER ANOTHER $45.00 I FOUND OUT THAT YET ANOTHER CLIP HAD BROKE,AND NOW THE CABLE WAS BROKE TOO.TOTAL REPAIR WOULD NOW BE $290.00 PLEASE RECALL THIS--I BELIEVE MY PASSENGER SIDE WINDOW IS ABOUT TO GO, I AM AFRAID TO USE MY WINDOWS.*AK
NHTSA ODI #10045930
Mileage unknown · Jul 4, 2003
Electrical SystemEngine And Engine CoolingEquipment
HAVE REPLACED THE ENTIRE INTAKE MANIFOLD ON THIS CAR THREE TIMES. 1999 GRAND AM, PURCHASED NEW, HAS LESS THAN 60,000 MILES ON IT. IN ADDITION, HAVE REPLACED POWER STEERING TWICE AND BRAKES NUMEROUS TIMES. REPLACED ALTERNATOR, SERPENTINE BELT, BATTERY, STARTER ON IGNITION, MOLDING DUE TO LEAKS, WIRING ON DASH, AIR CONDITIONING…
Read full complaint
HAVE REPLACED THE ENTIRE INTAKE MANIFOLD ON THIS CAR THREE TIMES. 1999 GRAND AM, PURCHASED NEW, HAS LESS THAN 60,000 MILES ON IT. IN ADDITION, HAVE REPLACED POWER STEERING TWICE AND BRAKES NUMEROUS TIMES. REPLACED ALTERNATOR, SERPENTINE BELT, BATTERY, STARTER ON IGNITION, MOLDING DUE TO LEAKS, WIRING ON DASH, AIR CONDITIONING RESISTORS/CIRCUITS, AND HEADLIGHTS/TAILLIGHTS.*AK
NHTSA ODI #10025413
11,000 miles · Jun 25, 2003
Electrical SystemEngine And Engine CoolingEquipment
1999 PONTIAC GRAND AM 2.4 L AUTO SEVERE BRAKE FAILURE---REPLACEMENT OF PADS 8 TIMES, ROTORS 3 TIMES AND CALIPERS 2 TIMES IN 80,000 MILES. BRAKES OCCASIONALLY LOCK UP AND MAKE LOUD GRINDING AND SQUEALING NOISES STEERING SHUDDERS AND VEHICLE PULLS TO LEFT.. PARTICIPATING PONTIAC DEALER FAILED TO FIX THIS PROBLEM SINCE PURCHASE …
Read full complaint
1999 PONTIAC GRAND AM 2.4 L AUTO SEVERE BRAKE FAILURE---REPLACEMENT OF PADS 8 TIMES, ROTORS 3 TIMES AND CALIPERS 2 TIMES IN 80,000 MILES. BRAKES OCCASIONALLY LOCK UP AND MAKE LOUD GRINDING AND SQUEALING NOISES STEERING SHUDDERS AND VEHICLE PULLS TO LEFT.. PARTICIPATING PONTIAC DEALER FAILED TO FIX THIS PROBLEM SINCE PURCHASE AT 11,000 MILES. UNDER WARRANTY REPLACEMENT IT HAS HAD 6 DOOR PANELS DUE TO PEELING LEATHER ON TOP OF PANEL, 5 GEAR SHIFTERS DUE TO DEALERS IMPROPER INSTALLATION, 2 FACTORY CD/RADIO FAILURES, 1 RACK AND PINION UNIT, 2 FRONT STRUT ASSEMBLIES DUE TO KNOCKING NOISE FROM FRONT OF CAR (WENT BAD AFTER 10,000 MILES USE), PROBLEM WITH HESITATION AT IDLE-COLD START(UNSUCCESSFULLY DIAGNOSED BY DEALER) CARPET LOOSE IN TRUNK AROUND LATCH ASSEMBLY(TOO SHORT FOR TRUNK AND WAS HOT GLUED TO BACK WALL OF CAR BY DEALER INSTEAD OF REPLACEMENT). TURN SIGNALS STILL OCCASIONALLY FAIL TO WORK(DEALER SAID THEY WORKED JUST FINE) BATTERY CONNECTION IN FACTORY BATTERY BROKE LOOSE SPILLING CORROSIVE BATTERY ACID ALL OVER AROUND BATTERY TRAY AREA. ALL FOUR WHEEL COVERS HAVE BEEN REPLACED BECAUSE OF "PIE PAN" NOISE WHEN YOU HIT A BUMP (NEW ONES DID NOT FIX PROBLEM). AFTER WARRANTY WAS UP PONTIAC' CARE HOTLINE OR THE DEALER COULD "CARE " LESS THAT AFTER DOZENS OF TRIPS FOR REPAIRS THE DEALER STILL DIDN'T FIX THE CAR WHILE IT WAS STILL UNDER WARRANTY. SINCE THEN,BESIDES THE UNREPAIRED ITEMS ON MY CAR, THE ALTERNATOR WENT BAD AT 60,000 MILES ($120), GLASS IN INTERIOR REAR VIEW MIRROR BROKE WHILE ADJUSTING, BOTH OUTSIDE REAR VIEW MIRRORS HAVE BROKE OFF IN TWO DIFFERENT AUTOMATIC CAR WASHES (HELD INTO DOOR BY A STUD MOUNTED INTO 1/4 INCH OF PLASTIC IN THE MIRROR). AND THE IGNITION SWITCH FAILED AT 75,000 MILES($300). FOG LIGHTS AND BACKUP LIGHTS HAVE WATER CONDENSATION IN THEM SHORTING OUT BULBS. SURPRISINGLY ,THIS CAR IS "BABIED" ,BUT BY IN MY DESCRIPTION YOU SURE COULDN'T TELL IT. *NLM
NHTSA ODI #10023794
41,000 miles · Feb 18, 2003
EquipmentFuel System, GasolineService Brakes, Hydraulic
I HAVE OWNED THIS CAR FOR JUST UNDER 4 YEARS AND HAVE SPENT THE LAST 2.5 IN AND OUT OF THE SERVICE DEPT. WITH IT. I'VE HAD THE BRAKE ROTORS REPLACED 3 TIMES, EVERY YEAR, ALMOST TO THE DAY. I HAVE ALSO JUST HAD THE FUEL PUMP REPLACED 2 TIMES AND DISCOVERED A LEAK IN MY INTAKE MANIFOLD WITH ONLY 41K MILES ON THE VEHICLE. IT HAS BE…
Read full complaint
I HAVE OWNED THIS CAR FOR JUST UNDER 4 YEARS AND HAVE SPENT THE LAST 2.5 IN AND OUT OF THE SERVICE DEPT. WITH IT. I'VE HAD THE BRAKE ROTORS REPLACED 3 TIMES, EVERY YEAR, ALMOST TO THE DAY. I HAVE ALSO JUST HAD THE FUEL PUMP REPLACED 2 TIMES AND DISCOVERED A LEAK IN MY INTAKE MANIFOLD WITH ONLY 41K MILES ON THE VEHICLE. IT HAS BEEN A SAFETY HAZARD AT TIMES AND LEFT ME STRANDED ONCE.
NHTSA ODI #10007722
30,000 miles · Jan 6, 2003
Electrical SystemEngine And Engine CoolingEquipment
I HAVE HAD TO HAVE THE FOLLOWING REPAIRED: THE FAN REPLACED 2 TIMES, THE BRAKES REPAIRED 4 TIMES, THE RADIO REPLACED ONCE, THE WATER PUMP REPLACED ONCE AND THE BATTERY REPLACED TWICE. I AM ALSO HAVING PROBLEMS WITH THE TRANSMISSION IT HAS BEEN SLIPPING. THE INTAKE GASKET NEEDS TO REPLACED BECAUSE ANTIFREEZE IS LEAKING OUT AND…
Read full complaint
I HAVE HAD TO HAVE THE FOLLOWING REPAIRED: THE FAN REPLACED 2 TIMES, THE BRAKES REPAIRED 4 TIMES, THE RADIO REPLACED ONCE, THE WATER PUMP REPLACED ONCE AND THE BATTERY REPLACED TWICE. I AM ALSO HAVING PROBLEMS WITH THE TRANSMISSION IT HAS BEEN SLIPPING. THE INTAKE GASKET NEEDS TO REPLACED BECAUSE ANTIFREEZE IS LEAKING OUT AND ONE OF THE LIFTERS IS KNOCKING. MOST OF THESE PROBLEMS STARTED AT ABOUT 30,000 MILES AND GRADUALLY THERE WAS JUST ONE PROBLEM AFTER ANOTHER. I TOOK IT IN TO THE DEALERSHIP FOR THE TRANMISSION AT ABOUT 32,000 MILES AND SINCE THE DEALERSHIP COULDN'T GET IT TO SLIP THEY WOULDN'T DO ANYTHING ABOUT IT. THE BRAKES STARTED HAVING PROBLEMS AT 40,000 MILES. I CALLED GM TO COMPLAIN ABOUT THE CAR AND GM TOLD ME THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS OUT OF WARRANTY. IF IT WAS STILL UNDER WARRANTY THEY WOULD REPLACED THE ROTORS BECAUSE THE ROTORS WERE TO THIN WHEN THE CAR WAS MANUFACTURED. I WONDER WHY NO RECALL WAS SENT OUT ON THIS. THE BRAKES ARE AN IMPORTANT PART OF A CAR. THE BATTERY, RADIO AND FAN WERE REPLACED AT ABOUT 30,000 ALSO. THEN THE FAN WAS REPLACED AGAIN AT ABOUT 70,000. THE INTAKE STARTED GIVING ME PROBLEMS THAT ABOUT 90,000. THE SECOND BATTERY WAS INSTALLED AT ABOUT 95,000. THE LIFTER STARTED HAVING PROBLEMS AT ABOUT 110,000. THE TRANSMISSION HAS SLIPPED EVER SINCE I GOT THE CAR.
NHTSA ODI #10000556
Mileage unknown · Jun 15, 2002
EquipmentExterior LightingFuel System, Gasoline
CIGARETTE LIGHTER DOES NOT WORK, HAZARD LIGHTS AND BLINKERS WORK INTERMITTENTLY, GAS CAP IS BROKEN, WINDSHIELD HAS 3 CHIPS, RADIO VOLUME KNOB WORKS INTERMITTENTLY, STEERING HAS JERKED WHEN ROUNDING CORNERS, HEATER FAN SPEEDS 1 AND 2 DO NOT WORK AT ALL, CRUISE DOESN'T WORK INTERMITTENTLY, RUBBER MOLDING ON DOOR COMING OFF, DEALER…
Read full complaint
CIGARETTE LIGHTER DOES NOT WORK, HAZARD LIGHTS AND BLINKERS WORK INTERMITTENTLY, GAS CAP IS BROKEN, WINDSHIELD HAS 3 CHIPS, RADIO VOLUME KNOB WORKS INTERMITTENTLY, STEERING HAS JERKED WHEN ROUNDING CORNERS, HEATER FAN SPEEDS 1 AND 2 DO NOT WORK AT ALL, CRUISE DOESN'T WORK INTERMITTENTLY, RUBBER MOLDING ON DOOR COMING OFF, DEALER SAYS NEED ALL NEW BRAKE PADS AND FRONT ROTORS
NHTSA ODI #763115
Mileage unknown · Apr 18, 2002
Electrical SystemEngine And Engine CoolingEquipment
I HAVE HAD ISSUES WITH THE ROTERS RAIDO REPLACED 2 TIMES, THE DOORS BUBBLE, MANY ISSUES TO WRITE. THE CAR IS NO LONGER UNDER WARRENTY, HOW EVER IT WAS MY UNDER STANDING THET THE COOLENT SYSTEM WAS COVERED FOR 150,00, THE INTAKE GASKET NEEDS REPLACEING THE CAR HAS BEEN AT THE DEALERSHIP FOR ALMOST 2 WEEKS , COULDNT FIND THE PART…
Read full complaint
I HAVE HAD ISSUES WITH THE ROTERS RAIDO REPLACED 2 TIMES, THE DOORS BUBBLE, MANY ISSUES TO WRITE. THE CAR IS NO LONGER UNDER WARRENTY, HOW EVER IT WAS MY UNDER STANDING THET THE COOLENT SYSTEM WAS COVERED FOR 150,00, THE INTAKE GASKET NEEDS REPLACEING THE CAR HAS BEEN AT THE DEALERSHIP FOR ALMOST 2 WEEKS , COULDNT FIND THE PART. THIS ISSUE IS OUT OF POCKET 800.00. VERY DISSATIFIED WITH GM, NO EFFORTS TO GIVE A CAR TO USE, DEALER WILL CHARGE 20.00 A DAY, WHO CAN AFFORD THAT WHEN 800.00 HAS TO BE PAID TO GET THE CAR RUNNING AGAIN. BECAUSE THE CAR IS NO LONGER UNDER WARRENTY, THE CUSTOMER IS OUT OF LUCK FOR ANY KING OF HELP. I WILL SUGGEST WHEN ASKED NOT TO BUY A PONTIAC, OR GM VERY DISAPOINTED.*AK
NHTSA ODI #760874
Mileage unknown · Apr 12, 2002
Electrical SystemEngine And Engine CoolingEquipment
CONSUMER EXPERIENCING VARIOUS PROBLEMS WITH VEHICLE SUCH AS STRONG FUEL SMELL INSIDE OF VEHICLE, INTAKE MANIFOLD LEAKING, ENGINE RUNNING ROUGH / FLUTTERS AND DIES WHILE DRIVING, STRONG FUEL SMELL, BAD RELAY IN A/C, ORANGE JELLY-LIKE SUBSTANCE IN ENGINE OIL, ABS LIGHT ON WHEN STEPPING ON BRAKE, CONSUMER ALSO STATED THAT ALL LIGHT…
Read full complaint
CONSUMER EXPERIENCING VARIOUS PROBLEMS WITH VEHICLE SUCH AS STRONG FUEL SMELL INSIDE OF VEHICLE, INTAKE MANIFOLD LEAKING, ENGINE RUNNING ROUGH / FLUTTERS AND DIES WHILE DRIVING, STRONG FUEL SMELL, BAD RELAY IN A/C, ORANGE JELLY-LIKE SUBSTANCE IN ENGINE OIL, ABS LIGHT ON WHEN STEPPING ON BRAKE, CONSUMER ALSO STATED THAT ALL LIGHTS WERE COMING ON, HOWEVER DEALER COULD NOT DUPLICATE THE PROBLEM. *AK *TT
NHTSA ODI #8007471
Mileage unknown · Aug 16, 2001
Electrical SystemEngine And Engine CoolingEquipment
CONSUMER HAS EXPERIENCED PROBLEMS WITH RADIO SEVERL TIMES.TD
NHTSA ODI #562550
Mileage unknown · Mar 2, 2001
Air BagsElectrical SystemEquipment
STEERING WHEEL MADE NOISE AND DRIVER'S SIDE AIRBAG DROPPED OUT AND FELL IN LAPS. VEHICLE PULLED TO LIGHT, AND DASHLIGHT FLASHED ON AND OFF. ALSO HORN WAS INOPERABLE. *AK CONSUMER STATES THERE IS A NOISE IN BRAKE PEDAL, ALSO ABS LIGHT ILLUMINATED. AIR CONDITIONER AND HEATER INOPERABLE. DUE TO SQUEAKY STEERING, DEALER REPLAC…
Read full complaint
STEERING WHEEL MADE NOISE AND DRIVER'S SIDE AIRBAG DROPPED OUT AND FELL IN LAPS. VEHICLE PULLED TO LIGHT, AND DASHLIGHT FLASHED ON AND OFF. ALSO HORN WAS INOPERABLE. *AK CONSUMER STATES THERE IS A NOISE IN BRAKE PEDAL, ALSO ABS LIGHT ILLUMINATED. AIR CONDITIONER AND HEATER INOPERABLE. DUE TO SQUEAKY STEERING, DEALER REPLACED STEERING RACK WHICH WAS LOOSE AND SET TOE. RADIO INOPERABLE. *SLC
NHTSA ODI #881998
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Illustration