IllustrationFIRE IN STEERING COLUMN - LIGHTS NOW STUCK ON BRIGHT - OTHERWISE I HAVE NO LIGHTS. *AK
1999 Pontiac Grand Am
Owner reports · Recalls · Investigations
More warning signs than most Grand Am years
Owner complaints for the 1999 Pontiac Grand Am are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Am years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
5925–50K
6650–75K
7075–100K
43100–150K
13150K+
273 reports with mileage · 576 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 203 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
73 crash reports13 fire reports48 injury reports
Electrical System complaints
132 reportsCOMPLETE LOSS OF POWER WHILE DRIVING - REPLACED BATTERY/ALTERNATOR- PROBLEM IS IN WIRING??? FYI.....3RD ALTERNATOR PUT IN CAR SINCE PURCHASED. *AK
AFTER THE CAR SITS OVERNIGHT AND THE CAR IS STARTED AND START TO DRIVE AND THE WHEEL IS SLIGHTLY TURNED TO THE LEFT THE ELECTRONIC TRACTION CONTROL LIGHT COMES ON. IT HAS BEEN TO THE DEALER SEVERAL TIMES SINCE THE YEAR 2000. THEY NEVER SEE THE TRACTION CONTROL LIGHT COME ON. THEY CAN NOT FIND THE PROBLEM. *AK
THE ENGINE, ENGINE COOLING SYSTEM AND ALTERNATOR FAILED. *PH *CB *NLM
WHILE DRIVING THE COOLANT LIGHT BEGAN TO FLASH. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE INTAKE MANIFOLD NEEDED TO BE REPLACED. TWO DAYS LATER THE ALTERNATOR FAILED. *AK *CB *NLM
HAVE REPLACED THE ENTIRE INTAKE MANIFOLD ON THIS CAR THREE TIMES. 1999 GRAND AM, PURCHASED NEW, HAS LESS THAN 60,000 MILES ON IT. IN ADDITION, HAVE REPLACED POWER STEERING TWICE AND BRAKES NUMEROUS TIMES. REPLACED ALTERNATOR, SERPENTINE BELT, BATTERY, STARTER ON IGNITION, MOLDING DUE TO LEAKS, WIRING ON DASH, AIR CONDITIONING…
Read full complaint
HAVE REPLACED THE ENTIRE INTAKE MANIFOLD ON THIS CAR THREE TIMES. 1999 GRAND AM, PURCHASED NEW, HAS LESS THAN 60,000 MILES ON IT. IN ADDITION, HAVE REPLACED POWER STEERING TWICE AND BRAKES NUMEROUS TIMES. REPLACED ALTERNATOR, SERPENTINE BELT, BATTERY, STARTER ON IGNITION, MOLDING DUE TO LEAKS, WIRING ON DASH, AIR CONDITIONING RESISTORS/CIRCUITS, AND HEADLIGHTS/TAILLIGHTS.*AK
1999 PONTIAC GRAND AM 2.4 L AUTO SEVERE BRAKE FAILURE---REPLACEMENT OF PADS 8 TIMES, ROTORS 3 TIMES AND CALIPERS 2 TIMES IN 80,000 MILES. BRAKES OCCASIONALLY LOCK UP AND MAKE LOUD GRINDING AND SQUEALING NOISES STEERING SHUDDERS AND VEHICLE PULLS TO LEFT.. PARTICIPATING PONTIAC DEALER FAILED TO FIX THIS PROBLEM SINCE PURCHASE …
Read full complaint
1999 PONTIAC GRAND AM 2.4 L AUTO SEVERE BRAKE FAILURE---REPLACEMENT OF PADS 8 TIMES, ROTORS 3 TIMES AND CALIPERS 2 TIMES IN 80,000 MILES. BRAKES OCCASIONALLY LOCK UP AND MAKE LOUD GRINDING AND SQUEALING NOISES STEERING SHUDDERS AND VEHICLE PULLS TO LEFT.. PARTICIPATING PONTIAC DEALER FAILED TO FIX THIS PROBLEM SINCE PURCHASE AT 11,000 MILES. UNDER WARRANTY REPLACEMENT IT HAS HAD 6 DOOR PANELS DUE TO PEELING LEATHER ON TOP OF PANEL, 5 GEAR SHIFTERS DUE TO DEALERS IMPROPER INSTALLATION, 2 FACTORY CD/RADIO FAILURES, 1 RACK AND PINION UNIT, 2 FRONT STRUT ASSEMBLIES DUE TO KNOCKING NOISE FROM FRONT OF CAR (WENT BAD AFTER 10,000 MILES USE), PROBLEM WITH HESITATION AT IDLE-COLD START(UNSUCCESSFULLY DIAGNOSED BY DEALER) CARPET LOOSE IN TRUNK AROUND LATCH ASSEMBLY(TOO SHORT FOR TRUNK AND WAS HOT GLUED TO BACK WALL OF CAR BY DEALER INSTEAD OF REPLACEMENT). TURN SIGNALS STILL OCCASIONALLY FAIL TO WORK(DEALER SAID THEY WORKED JUST FINE) BATTERY CONNECTION IN FACTORY BATTERY BROKE LOOSE SPILLING CORROSIVE BATTERY ACID ALL OVER AROUND BATTERY TRAY AREA. ALL FOUR WHEEL COVERS HAVE BEEN REPLACED BECAUSE OF "PIE PAN" NOISE WHEN YOU HIT A BUMP (NEW ONES DID NOT FIX PROBLEM). AFTER WARRANTY WAS UP PONTIAC' CARE HOTLINE OR THE DEALER COULD "CARE " LESS THAT AFTER DOZENS OF TRIPS FOR REPAIRS THE DEALER STILL DIDN'T FIX THE CAR WHILE IT WAS STILL UNDER WARRANTY. SINCE THEN,BESIDES THE UNREPAIRED ITEMS ON MY CAR, THE ALTERNATOR WENT BAD AT 60,000 MILES ($120), GLASS IN INTERIOR REAR VIEW MIRROR BROKE WHILE ADJUSTING, BOTH OUTSIDE REAR VIEW MIRRORS HAVE BROKE OFF IN TWO DIFFERENT AUTOMATIC CAR WASHES (HELD INTO DOOR BY A STUD MOUNTED INTO 1/4 INCH OF PLASTIC IN THE MIRROR). AND THE IGNITION SWITCH FAILED AT 75,000 MILES($300). FOG LIGHTS AND BACKUP LIGHTS HAVE WATER CONDENSATION IN THEM SHORTING OUT BULBS. SURPRISINGLY ,THIS CAR IS "BABIED" ,BUT BY IN MY DESCRIPTION YOU SURE COULDN'T TELL IT. *NLM
DURING THE LAST 6 MONTHS MY WIFE AND I HAVE PUT APPROXIMATELY $650.00 INTO A 1999 GRAND AM. THIS WAS REPLACING THE WATER PUMP, ALTERNATOR AND THE *INTAKE GASKETS *HAS NOT BEEN 30 DAYS. ON JUNE 20 THE ENGINE FAILS. THIS WAS A $220.00 TOWING BILL. SEVERAL PEOPLE AND MECHANICS ARE QUESTIONED NO ONE HAS THE ANSWER. BUT I DO BELIEVE…
Read full complaint
DURING THE LAST 6 MONTHS MY WIFE AND I HAVE PUT APPROXIMATELY $650.00 INTO A 1999 GRAND AM. THIS WAS REPLACING THE WATER PUMP, ALTERNATOR AND THE *INTAKE GASKETS *HAS NOT BEEN 30 DAYS. ON JUNE 20 THE ENGINE FAILS. THIS WAS A $220.00 TOWING BILL. SEVERAL PEOPLE AND MECHANICS ARE QUESTIONED NO ONE HAS THE ANSWER. BUT I DO BELIEVE "GM" CAN PROVIDE THE ANSWER TO ALL OF OUR QUESTIONS. WE WILL NEVER OWN ANOTHER GM PRODUCT. *NLM
LOWER INTAKE WAS JUST FIXED 01/01/2002. LOWER INTAKE HAS TO BE REPLACED AGAIN 05/05/2003. LOWER INTAKE HAS BEEN CHANGED TO BE STRONGER. THE LOWER INTAKE WAS FAULTY. I SHOULD NOT BE MADE TO PAY FOR IT AGAIN. THE FIRST CHARGE WAS $1032 AND I AM AGAIN BEING CHARGED $1306. I SHOULD NOT HAVE TO PAY AGAIN FOR THE SAME PROBLEM. I HAVE …
Read full complaint
LOWER INTAKE WAS JUST FIXED 01/01/2002. LOWER INTAKE HAS TO BE REPLACED AGAIN 05/05/2003. LOWER INTAKE HAS BEEN CHANGED TO BE STRONGER. THE LOWER INTAKE WAS FAULTY. I SHOULD NOT BE MADE TO PAY FOR IT AGAIN. THE FIRST CHARGE WAS $1032 AND I AM AGAIN BEING CHARGED $1306. I SHOULD NOT HAVE TO PAY AGAIN FOR THE SAME PROBLEM. I HAVE EXCEED THE LIMITED WARRANTY OF ONE YEAR OR 12,000 MILES. THE LOWER INTAKE IS DESIGNED TO LAST ALMOST THE LIFE OF THE CAR. THE CAR IS A 99 PONT GRAND AM. I PURCHASED IT IN JUNE 2000. I HAD THE CAR 2 YEARS AND 8 MONTHS AND I AM STILL MAKING PAYMENTS ON IT. THIS IS UNFAIR THAT I SHOULD HAVE TO PAY FOR REPAIRS AGAIN. ALSO I UNDERSTAND THAT RECALLS WERE DONE FOR THE STEERING AND BODY STRUCTURE. I NEVER GOT ANY NOTICES ABOUT ANY RECALLS. IF I HAD NOT GONE TO YOUR WEB SITE, I WOULD NOT HAVE KNOWN. HOW DO I GET MY CAR REPAIRED WITHOUT CHARGE? ALSO THE ALTERNATOR WAS REPLACED 07/02/2002 FOR $456 AND THE ALTERNATOR HAD TO BE REPLACED AGAIN 03/17/03 WHICH I WAS NOT CHARGED FOR. I PURCHASED A CAR WITH A LOT OF DEFECTS AND SHOULD NOT HAVE TO PAY. I WILL GET RID OF THIS CAR. *JB
THERE IS A FOUL SMELL COMING FROM THE AC VENT ALMOST LIKE AMMONIA. MY ALTERNATOR WAS REPLACED AT 37000 MILES, AFTER HAVING IT "CHECKED" BY THE DEALERSHIP FOR LOW VOLTAGE. CAR SHAKES AT 55 MPH ON HIGHWAY AFTER ROTATION, ALIGNMENT, AND AFTERMARKET WHEELS. SCRATCHES ON PASSENGER WINDOW FROM ROLLING IT UP AND DOWN. *NLM
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
00V140000 · Structure:body
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
98V320000 · Steering: Steering Wheel/handle Bar
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.