IllustrationINSTRUMENT CLUSTER NOT WORKING (ALL GAUGES FLATLINED). APPARENTLY THIS IS A COMMON PROBLEM DUE TO POOR SOLDER ON THE BACK OF THE UNIT. THIS ALSO LED IN THE PAST TO UNCONTROLLED CYCLING OF THE DOOR LOCKS. *TR
1999 Plymouth Voyager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Plymouth Voyager do not stand out strongly from the model-year median of 197.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1825–50K
3150–75K
2975–100K
19100–150K
7150K+
109 reports with mileage · 164 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports10 fire reports11 injury reports
What owners actually said
273 reportsTL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. WHILE DRIVING 65 MPH, THE BRAKE LINE FAILED. THE DEALER STATED THAT THE ENTIRE BRAKE LINE WAS BADLY CORRODED. THE CONTACT STATED THAT IT WAS A CATASTROPHIC FAILURE THAT SHOULD HAVE NEVER OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 104,000. UPDATED 02-14-08. *KB
PURCHASED USED PLYMOUTH IN OCTOBER 2007 WITH 5393 MILES ON THE ODOMETER. REGISTERED AND DROVE IT FROM DECEMBER 3, 2007 TO JAN 2, 2008. NOTICED SIGNIFICANT AMOUNT OF TRANSMISSION FLUID UNDER THE VEHICLE AND FILM OF FLUID ON BACK WINDOW AND HATCH AREA. OBSERVED FLUID PUMPING OUT FROM UNDER THE CAR. MECHANIC TELLS ME THE SOLENO…
Read full complaint
PURCHASED USED PLYMOUTH IN OCTOBER 2007 WITH 5393 MILES ON THE ODOMETER. REGISTERED AND DROVE IT FROM DECEMBER 3, 2007 TO JAN 2, 2008. NOTICED SIGNIFICANT AMOUNT OF TRANSMISSION FLUID UNDER THE VEHICLE AND FILM OF FLUID ON BACK WINDOW AND HATCH AREA. OBSERVED FLUID PUMPING OUT FROM UNDER THE CAR. MECHANIC TELLS ME THE SOLENOID BLOCK MOST LIKELY HAS FAILED AND WILL NEED TO BE REPLACED. I AM TOLD THIS IS A "COMMON" FAILURE IN LATER MODEL 41TE TRANSMISSIONS.*CN
TRANSMISSION IS SHIFTING TERRIBLE!THE BACK DOOR WILL NOT OPEN AT ALL,THE SIDE DOOR WILL NOT OPEN FROM INSIDE. MY LIGHTS FROM THE INSIDE OF VEHICLE GOES ON AND OFF. WHILE DRIVING DOWN THE ROAD THE VAN SHAKES TERRIBLE, IT FEELS LIKE THE MOTOR SHAKES. *TR
OBSERVED THAT THE DRIVER'S SIDE STRUT TOWER IS RUSTED THROUGH TWO LAYERS OF METAL AND PERFORATED OVER HALF THE WAY AROUND FRONT TOP OF THE STRUT TOWER. VEHICLE HAS LITTLE OTHER BODY RUST EXCEPT THIS SHOCK / STRUT TOWER AREA AND THERE NEEDS TO BE A SAFETY RECALL TO REPAIR THIS DEFECTIVE ITEM BEFORE FURTHER ABNORMAL CORROSION CAUS…
Read full complaint
OBSERVED THAT THE DRIVER'S SIDE STRUT TOWER IS RUSTED THROUGH TWO LAYERS OF METAL AND PERFORATED OVER HALF THE WAY AROUND FRONT TOP OF THE STRUT TOWER. VEHICLE HAS LITTLE OTHER BODY RUST EXCEPT THIS SHOCK / STRUT TOWER AREA AND THERE NEEDS TO BE A SAFETY RECALL TO REPAIR THIS DEFECTIVE ITEM BEFORE FURTHER ABNORMAL CORROSION CAUSES THE METAL TO FAIL AND FORCING THE STRUT THROUGH THE HOOD AND INTO THE WINDSHIELD OF THE VEHICLE CAUSING AN ACCIDENT OR INJURIES. *TR
OBSERVED THAT THE DRIVER'S SIDE STRUT TOWER IS RUSTED THROUGH TWO LAYERS OF METAL AND PERFORATED OVER HALF THE WAY AROUND FRONT TOP OF THE STRUT TOWER. VEHICLE HAS NO OTHER BODY RUST EXCEPT THIS SHOCK / STRUT TOWER AREA AND THERE NEEDS TO BE A SAFETY RECALL TO REPAIR THIS DEFECTIVE ITEM BEFORE FURTHER ABNORMAL CORROSION CAUSES …
Read full complaint
OBSERVED THAT THE DRIVER'S SIDE STRUT TOWER IS RUSTED THROUGH TWO LAYERS OF METAL AND PERFORATED OVER HALF THE WAY AROUND FRONT TOP OF THE STRUT TOWER. VEHICLE HAS NO OTHER BODY RUST EXCEPT THIS SHOCK / STRUT TOWER AREA AND THERE NEEDS TO BE A SAFETY RECALL TO REPAIR THIS DEFECTIVE ITEM BEFORE FURTHER ABNORMAL CORROSION CAUSES THE METAL TO FAIL AND FORCING THE STRUT THROUGH THE HOOD AND INTO THE WINDSHIELD OF THE VEHICLE CAUSING AN ACCIDENT OR INJURIES. *TR
TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT COULD NOT START HER VEHICLE AND IT WAS TOWED TO A MECHANIC. THE MECHANIC STATED THAT A CYLINDER IN THE TUMBLER, WHERE THE KEY IS PLACED IN THE IGNITION TO START THE VEHICLE, FAILED. THE FAILURE FIRST OCCURRED AT 60,000 MILES AND RECURRED ON SEPTEMBER 7, 2007. THE VEHIC…
Read full complaint
TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT COULD NOT START HER VEHICLE AND IT WAS TOWED TO A MECHANIC. THE MECHANIC STATED THAT A CYLINDER IN THE TUMBLER, WHERE THE KEY IS PLACED IN THE IGNITION TO START THE VEHICLE, FAILED. THE FAILURE FIRST OCCURRED AT 60,000 MILES AND RECURRED ON SEPTEMBER 7, 2007. THE VEHICLE CANNOT START ONCE THIS COMPONENT FAILS. THE VEHICLE IS NO LONGER UNDER WARRANTY AND THE CONTACT WAS INFORMED THAT SHE WOULD BE RESPONSIBLE FOR THE REPAIR. SHE BELIEVED IT WAS A DEFECT THAT FAILED EVERY 50,000 MILES AND SHE SHOULD NOT BE RESPONSIBLE FOR THE REPAIR. THE VEHICLE IS CURRENTLY AT THE DEALER AND HAS NOT BEEN REPAIRED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 119,000 AND FAILURE MILEAGE WAS 60,000. UPDATED 10/24/07. *JB
1999 PLYMOUTH VOYAGER CAUGHT FIRE IN THE ENGINE COMPARTMENT. *KB OHIO TRAFFIC CRASH REPORT. *JB
1999 PLYMOUTH GRAND VOYAGER THROWS SERPENTINE BELT WHEN DRIVING THROUGH A PUDDLE, RESULTING IN LOSS OF STEERING. *TR
TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. WHILE DRIVING 20 MPH, THE VEHICLE ACCELERATED AUTOMATICALLY TO 45 MPH. THE CONTACT ATTEMPTED TO APPLY THE BRAKES, BUT THE VEHICLE FAILED TO STOP. THE CONTACT CRASHED INTO THE REAR END OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE VIN, ENGINE SIZE, # OF CYLINDERS, AND POWERTR…
Read full complaint
TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. WHILE DRIVING 20 MPH, THE VEHICLE ACCELERATED AUTOMATICALLY TO 45 MPH. THE CONTACT ATTEMPTED TO APPLY THE BRAKES, BUT THE VEHICLE FAILED TO STOP. THE CONTACT CRASHED INTO THE REAR END OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE VIN, ENGINE SIZE, # OF CYLINDERS, AND POWERTRAIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 160,000.
Official recalls
404V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available