IllustrationFOUND THE DRIVER SIDE STRUT TOWER IS COMPLETELY RUSTED OUT. DISCOVERED ONLINE HUNDREDS OF COMPLAINTS OF SAME ON THE SAME VEHICLE AND DATE RANGE. PLYMOUTH CHRYSLER KNOW ABOUT THIS AND DESCRIBES IT AS COSMETIC BUT THIS IS A STRUCTURAL PROBLEM. *TR
1998 Plymouth Grand Voyager
Owner reports · Recalls · Investigations
More warning signs than most Grand Voyager years
Owner complaints for the 1998 Plymouth Grand Voyager are substantially higher than the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
1225–50K
2050–75K
2975–100K
28100–150K
13150K+
108 reports with mileage · 168 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports20 fire reports9 injury reports
Suspension complaints
20 reportsMY VAN IS A LEMON. ALL KINDS OF ELECTRICAL PROBLEMS - DEFOGGER SOMETIMES WORK AND SOMETIMES NOT, WINDOWS WON'T ROLL DOWN, STEREO SPEAKERS SOMETIMES WORKS, INSTRUMENT PANEL LIGHTS GO OFF AND ON, DIM YELLOW HEADLIGHTS, ETC. FOUND PIN HOLE IN HEAD...DEFECT IN METAL. VAN OVER HEATED AND GAUGE DID NOT SAY IT WAS HOT. FAN WENT OUT…
Read full complaint
MY VAN IS A LEMON. ALL KINDS OF ELECTRICAL PROBLEMS - DEFOGGER SOMETIMES WORK AND SOMETIMES NOT, WINDOWS WON'T ROLL DOWN, STEREO SPEAKERS SOMETIMES WORKS, INSTRUMENT PANEL LIGHTS GO OFF AND ON, DIM YELLOW HEADLIGHTS, ETC. FOUND PIN HOLE IN HEAD...DEFECT IN METAL. VAN OVER HEATED AND GAUGE DID NOT SAY IT WAS HOT. FAN WENT OUT. NOW SOMETHING GOING WRONG WITH FRONT END. OCCASIONALLY SMELL GAS. THE LIFTER HEAD GASKET NOW LEAKS OIL. VAN SOMETIMES JUMPS IN PARK AND ROLLS. I CAN NOT AFFORD TO FIX THIS STUFF... BAIL ME OUT NOT CHRYSLER.... *TR
I OWN TWO CHRYSLER MINIVAN THAT HAVE RUSTED STRUT TOWERS, AND I TOOK THEM TO MY FAVORITE BODY SHOP. I HAVE BEEN TOLD THAT ALMOST EVERY CHRYSLER MINI VAN HAS HAD THIS, AND TO GO TO THE DEALER DUE TO A RECALL. THERE IS NO SUCH RECALL, AND WAS TOLD BY THE DEALER IT HAS BEEN A ISSUE. *TR
TL*THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT NOTICED SEVERE CORROSION AND RUST ON THE FRONT STRUTS. THE FAILURE HAS CAUSED THE FRONT TWO TIRES TO ABNORMALLY MOVE UP AND DOWN. HE TOOK THE VEHICLE TO THE DEALER AND A TECHNICIAN REFERENCED SERVICE BULLETIN NUMBER 23-04-02 FOR THE SAME FAILURE. SINCE THERE WAS …
Read full complaint
TL*THE CONTACT OWNS A 1998 PLYMOUTH GRAND VOYAGER. THE CONTACT NOTICED SEVERE CORROSION AND RUST ON THE FRONT STRUTS. THE FAILURE HAS CAUSED THE FRONT TWO TIRES TO ABNORMALLY MOVE UP AND DOWN. HE TOOK THE VEHICLE TO THE DEALER AND A TECHNICIAN REFERENCED SERVICE BULLETIN NUMBER 23-04-02 FOR THE SAME FAILURE. SINCE THERE WAS NOT AN OFFICIAL RECALL, THE DEALER WOULD NOT ASSUME ANY LIABILITY FOR THE REPAIR COSTS. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 172,000.
STRUT TOWER RUSTING OUT. *TR
DT*: THE CONTACT STATED THE STRUT TOWER HAD CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO REFERRED THE CONTACT TO A BODY SHOP USED BY THE DEALER. UPON REPLACEMENT, THE BODY SHOP MECHANIC EXPRESSED THAT THERE MAY BE A RECALL ON THIS MATTER. THE DEALER WERE WAS CONTACTED, AND DETERMINED THE VE…
Read full complaint
DT*: THE CONTACT STATED THE STRUT TOWER HAD CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO REFERRED THE CONTACT TO A BODY SHOP USED BY THE DEALER. UPON REPLACEMENT, THE BODY SHOP MECHANIC EXPRESSED THAT THERE MAY BE A RECALL ON THIS MATTER. THE DEALER WERE WAS CONTACTED, AND DETERMINED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE CONTACT ENCOUNTERED MANY COMPLAINTS ON THIS MATTER REGARDING THE SUSPENSION: FRONT: MACPHERSON STRUT. UPDATED 01/22/07. *JB
1998 PLYMOUTH GRAND VOYAGER WAS DIAGNOSED AS NEEDING NEW SHOCK TOWERS. MY MECHANIC FEELS THIS IS DUE TO A MANUFACTURER'S DEFECT SINCE WATER DOES NOT DRAIN ONTO THE GROUND BUT RATHER COLLECTS ABOVE THE SHOCK TOWER CAUSES PREMATURE RUSTING AND NECESSSITATING A STEEL PIECE HAVINGTO BE WELDED INTO PLACE . *AK
STRUT TOWERS RUSTING OUT. NOTICED THIS CONDITION APPROX. 2 YEARS AGO WHEN VEHICLE WAS LESS THAN 5 YEARS OLD. RESEARCHING THE PROBLEM, IT SEEMS MANY OTHER PLYMOUTH VOYAGER AND DODGE CARAVAN OWNERS HAVE THE SAME PROBLEM. FOUND TSB#23-044-02 WHICH REFERS TO THIS PROBLEM. SUDDEN FAILURE OF THE STRUT TOWER COULD RESULT IN LOSS OF STE…
Read full complaint
STRUT TOWERS RUSTING OUT. NOTICED THIS CONDITION APPROX. 2 YEARS AGO WHEN VEHICLE WAS LESS THAN 5 YEARS OLD. RESEARCHING THE PROBLEM, IT SEEMS MANY OTHER PLYMOUTH VOYAGER AND DODGE CARAVAN OWNERS HAVE THE SAME PROBLEM. FOUND TSB#23-044-02 WHICH REFERS TO THIS PROBLEM. SUDDEN FAILURE OF THE STRUT TOWER COULD RESULT IN LOSS OF STEERING AND/OR SUDDEN STOPPING FORCE APPLIED ON ONE SIDE OF VEHICLE AS A TIRE IMPACTS A WHEEL WELL.
THE VEHICLE'S FRONT LEFT STRUT CORRODED. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *NM
1.STRUT TWER RUSTING OUT ON DRIVER SIDE. 2. COULD CAUSE LOSS OF CONTROL AND STEERING IF IT GIVES OUT. 3. WILL GET STRUT TOWER CAP FROM DEALER AND HAVE IT REPAIRED. CHRYSLER WILL ONLY REPAIR IF I PAY $250 DEDUTABLE. *AK
Official recalls
404V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
97V231000 · Child Seat
Dec 15, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.
Consequence & remedy
Consequence: THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.
Remedy: DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available