IllustrationCONSUMER HAS A 1999 OLDSMOBILE INTRIGUE AND WANTS KNOW WHY IT TOOK TEN YEARS FOR GM TO ISSUE A RECALL. *NJ
1999 Oldsmobile Intrigue
Owner reports · Recalls · Investigations
More warning signs than most Intrigue years
Owner complaints for the 1999 Oldsmobile Intrigue are substantially higher than the model-year median of 108.
About this comparison →How this year compares
Owner complaints by model year
Compare all Intrigue years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
1025–50K
2450–75K
3075–100K
15100–150K
11150K+
106 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports14 fire reports11 injury reports
What owners actually said
256 reportsON SAT, MAY 9, I DROVE MY VEHICLE TO WORK AND PARKED IN THE BUSINESS PARKING LOT, TURNED OFF THE IGNITION, LEFT THE VEHICLE TO GO INSIDE AND CHECK ON MY EMPLOYEES.. APPROXIMATELY 10 MINUTES LATER A CO-WORKER NOTIFIED ME THAT SMOKE WAS COMING FROM MY VEHICLE. UPON OPENING THE HOOD I NOTICED A FIRE BURNING FROM THE MANIFOLD INTO T…
Read full complaint
ON SAT, MAY 9, I DROVE MY VEHICLE TO WORK AND PARKED IN THE BUSINESS PARKING LOT, TURNED OFF THE IGNITION, LEFT THE VEHICLE TO GO INSIDE AND CHECK ON MY EMPLOYEES.. APPROXIMATELY 10 MINUTES LATER A CO-WORKER NOTIFIED ME THAT SMOKE WAS COMING FROM MY VEHICLE. UPON OPENING THE HOOD I NOTICED A FIRE BURNING FROM THE MANIFOLD INTO THE ENGINE COVER AND SPARK PLUG WIRES. SEVERAL ATTEMPTS WERE MADE TO EXTINGUISH THE FIRE AND GET MY DOG OUT OF THE VEHICLE. THE FIRE WAS EVENTUALLY EXTINGUISHED WITH A FIRE EXTINGUISHER. THERE WAS A STRONG OIL SMELL. THE INCIDENT WAS OBSERVED BY CO-WORKERS AND CAPTURED BY SECURITY CAMERAS. OIL WAS LEAKING FROM VALVE COVER AND HAD IGNITED ON THE MANIFOLD AND BURNED VARIOUS PLASTIC PARTS OF THE ENGINE COMPONENTS. THE VEHICLE WAS ABLE TO START AND, ACCEPT FOR A HESITATION IN THE ENGINE, WAS DRIVABLE. CONTACTED DEALER, WAS TOLD THAT ISSUE WAS PART OF A RECALL. WAS TOLD CAR WOULD HAVE TO BE HELD FOR 2-3 WEEKS FOR AN ASSESSMENT OF CAUSE BEFORE THE MINOR REPAIRS WOULD BE MADE. WHEN I EXPLAINED THAT MY WORK REQUIRES DRIVING, THE DEALERS WOULD NOT PROVIDE ME WITH ANY TYPE OF VEHICLE. I WAS TOLD I COULD TAKE MY CAR, EVEN THOUGH IT IS RECALLED, WITHOUT ANY OF THE REPAIRS BEING MADE TO MAKE IT SAFE FROM CATCHING FIRE AGAIN. *TR
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED, THE DRIVER SMELLED SMOKE IN THE VEHICLE. THE DRIVER PULLED OFF THE ROAD AND ALL OF THE OCCUPANTS EXITED THE VEHICLE. THE VEHICLE THEN MADE A LOUD EXPLOSIVE NOISE AND THE FRONT END CAUGHT FIRE. THE FIRE AND POLICE DEPARTMENTS ARRIVED AND EXTING…
Read full complaint
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED, THE DRIVER SMELLED SMOKE IN THE VEHICLE. THE DRIVER PULLED OFF THE ROAD AND ALL OF THE OCCUPANTS EXITED THE VEHICLE. THE VEHICLE THEN MADE A LOUD EXPLOSIVE NOISE AND THE FRONT END CAUGHT FIRE. THE FIRE AND POLICE DEPARTMENTS ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND A POLICE REPORT WAS FILED. THE MANUFACTURER WOULD NOT ASSUME ANY LIABILITY FOR THE VEHICLE. SHORTLY AFTER THE FAILURE, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000, WHICH STATED THAT IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE. THERE WERE NO INJURIES. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 53,000.
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. AFTER THE VEHICLE HAD BEEN PARKED IN THE DRIVEWAY FOR A WEEK AND A HALF, THE BATTERY NEEDED TO BE CHARGED. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, THE INTAKE MANIFOLD EXPLODED AND CREATED A SMALL FIRE. THE WATER HOUSING JACKET WAS NEWLY INSTALLED ON THE VEHICLE. THE CU…
Read full complaint
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. AFTER THE VEHICLE HAD BEEN PARKED IN THE DRIVEWAY FOR A WEEK AND A HALF, THE BATTERY NEEDED TO BE CHARGED. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, THE INTAKE MANIFOLD EXPLODED AND CREATED A SMALL FIRE. THE WATER HOUSING JACKET WAS NEWLY INSTALLED ON THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 68,000.
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED AND MAKING A LEFT TURN, THE CONTACT HEARD AN EXPLOSION THAT SHOOK HER VEHICLE. SHE LOST CONTROL OF THE STEERING, THE BATTERY WARNING LIGHT ILLUMINATED, AND SMOKE WAS PRESENT UNDERNEATH THE HOOD. A RELATIVE, WHO IS ALSO A MECHANIC, STATED THAT TH…
Read full complaint
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED AND MAKING A LEFT TURN, THE CONTACT HEARD AN EXPLOSION THAT SHOOK HER VEHICLE. SHE LOST CONTROL OF THE STEERING, THE BATTERY WARNING LIGHT ILLUMINATED, AND SMOKE WAS PRESENT UNDERNEATH THE HOOD. A RELATIVE, WHO IS ALSO A MECHANIC, STATED THAT THE FLUID ON THE MANIFOLD CAUSED THE VEHICLE TO BEGIN SMOKING AND THE STEERING KNUCKLE FELL OFF OF THE VEHICLE, WHICH COULD ALSO HAVE CAUSED FLUID TO LEAK AND SMOKE TO APPEAR. A FEW MONTHS AGO, THE CONTACT HEARD A HIGH PITCHED SOUND IN THE STEERING WHEEL. PRIOR TO THE FAILURE, SHE NOTICED AN OIL LEAK AND THE DEALER REPLACED THE PISTONS. THE VIN WAS UNAVAILABLE. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 137,000.
I HAVE A 1999 OLDS INTRIGUE, AND I SAW THE RECALL ON THE ENGINE. MY ENGINE IS A 3.8L V6. I NEED TO KNOW HOW TO PROCEED ON FIXING THIS PROBLEM. THANK YOU. *TR
1999 OLDSMOBILE INTRIGUE-OIL LEAK -I WENT OUT TO START MY CAR LAST WINTER AND WHEN I STARTED THE CAR I HEARD A LOUD POP AND SMOKE STARTED BILLOWING OUT OF THE ENGINE I WAS 7 MONTHS PREGNANT AT THE TIME AND CALLED THE FIRE DEPARTMENT BUT BY THE TIME THEY ARRIVED AT THE HOUSE THE ENGINE FIRE WAS OUT OF CONTROL AND THE CAR WAS TOTA…
Read full complaint
1999 OLDSMOBILE INTRIGUE-OIL LEAK -I WENT OUT TO START MY CAR LAST WINTER AND WHEN I STARTED THE CAR I HEARD A LOUD POP AND SMOKE STARTED BILLOWING OUT OF THE ENGINE I WAS 7 MONTHS PREGNANT AT THE TIME AND CALLED THE FIRE DEPARTMENT BUT BY THE TIME THEY ARRIVED AT THE HOUSE THE ENGINE FIRE WAS OUT OF CONTROL AND THE CAR WAS TOTALED. I WOULD LIKE COMPENSATION FOR THE DAMAGES SINCE MY CAR INSURANCE DID NOT COVER THE FIRE. *TR
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING 25 MPH, THE RPMS WOULD DROP AND ALL THE INSTRUMENT PANEL GAUGES WOULD DIM. IN ADDITION, THE VEHICLE WOULD OCCASIONALLY STALL UNEXPECTEDLY. THE VEHICLE WOULD RESTART IMMEDIATELY, BUT THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT NOT…
Read full complaint
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING 25 MPH, THE RPMS WOULD DROP AND ALL THE INSTRUMENT PANEL GAUGES WOULD DIM. IN ADDITION, THE VEHICLE WOULD OCCASIONALLY STALL UNEXPECTEDLY. THE VEHICLE WOULD RESTART IMMEDIATELY, BUT THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT NOTICED THAT THE RPMS WOULD INCREASE AND THE ENGINE SOUNDED AS IF IT WERE REVVING. DURING THIS TIME, THE VEHICLE WOULD LUNGE FORWARD. THE VEHICLE WAS INSPECTED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE SPARK PLUGS HAVE BEEN CHANGED ALONG WITH OTHER REMEDIES, BUT THE FAILURE STILL PERSISTS. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 135,000 AND FAILURE MILEAGE WAS APPROXIMATELY 133,000.
I HAVE A 1999 INTRIGUE THAT PERIODICALLY DOES NOT WANT TO START, I HAVE READ SO MANY FORUMS ABOUT THIS PROBLEM AND I BELIEVE GM SHOULD RECALL THE CARS AND FIX THE PROBLEM. *TR
1999 OLDSMOBILE INTRIGUE: WHEN DRIVING IN COLD WEATHER (BELOW 40 DEGREES F), ALL LIGHTS DIM AND THEN BRIGHTEN RANDOMLY, INCLUDING HEADLIGHTS AND DASH LIGHTS. SOMETIMES HEADLIGHTS MOMENTARILY DIM SO MUCH AS TO MAKE DRIVING TEMPORARILY UNSAFE. PROBLEM HAS OCCURRED EVERY WINTER FOR SEVERAL YEARS. GM DEALER CLAIMS TO KNOW NOTHING AB…
Read full complaint
1999 OLDSMOBILE INTRIGUE: WHEN DRIVING IN COLD WEATHER (BELOW 40 DEGREES F), ALL LIGHTS DIM AND THEN BRIGHTEN RANDOMLY, INCLUDING HEADLIGHTS AND DASH LIGHTS. SOMETIMES HEADLIGHTS MOMENTARILY DIM SO MUCH AS TO MAKE DRIVING TEMPORARILY UNSAFE. PROBLEM HAS OCCURRED EVERY WINTER FOR SEVERAL YEARS. GM DEALER CLAIMS TO KNOW NOTHING ABOUT IT, BUT SOME WEB SITES SAY A REPLACEMENT BOSCH ALTERNATOR (APPROX. $450 PLUS INSTALLATION) CAN CURE THE PROBLEM. THIS IS A REPEATED ANNOYANCE THAT COULD CAUSE A FATAL CRASH. *TR
Official recalls
615V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
00V044000 · Seat Belts
Feb 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.
Consequence & remedy
Consequence: THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.
Remedy: DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.
98V241000 · Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
Oct 5, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.8L V6 ENGINE. SOME OF THESE VEHICLES WERE BUILT WITHOUT A HEATER HOSE CLIP WHICH COULD ALLOW THE HOSE TO SAG AND CONTACT THE OXYGEN SENSOR RESULTING IN A COOLANT LEAK.
Consequence & remedy
Consequence: IF A COOLANT LEAK WERE TO OCCUR, AND LEAKING COOLANT CONTACTED THE HOT EXHAUST MANIFOLD, AN ENGINE COMPARTMENT FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A HEATER HOSE CLIP.
98V102000 · Exterior Lighting:headlights
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02005 · Headlamps Dim/flicker
Opened Jan 18, 2002 · Closed Apr 15, 2002
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA99019 · Rear Shoulder Belt Malfunction
Opened Jul 7, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
THE ALLEGED DEFECT CONCERNS TWO MAJOR SYMPTOMS:FAILURE TO RETRACT WEBBING AND INABILITY TO EXTEND THE WEBBINNG FOR USE. THE ROOT CAUSE OF THESE SYMPTOMS IS THE DESIGN OF THE TRIM BEZEL THROUGH WHICH THE SEBBING PASSES. BUILT INTO THE REAR PACKAGE SHELF, THE BEZEL INCLUDES A VERTICAL SLOT TO FACILITATE VEHICLE ASSEMBLY.THE SLOT IS POSITIONED SUCH THAT THE SHOULDER BELT WEBBING TENDS TO SLIP INTO IT.WEBBING INGESTION BY THE VERTICAL SLOT MAY RETARD WEBBING RETRACTION, OR ALLOW WEBBING TWISTS TO ACCUMULATE ON THE RETRACTOR SPOOL.IN EITHER CASE, THE RETRACTOR MAY FAIL TO MAINTAIN APPROPRIATE TENSION ON THE SEAT OCCUPANT.FAILURE OF THE SHOULDER BELT TO COMPLETELY RETRACT MAY ALSO RESULT IN AN INABILITY TO EXTEND IT FOR USE IF THE CHILD RESTRAINT CINCH FEATURE HAS BEEN INADVERTENTLY ENGAGE (BY EXTENDING THE WEBBING TO ITS MAXIMUM LENGTH).GM WILL REMEDY THE ALLEGED DEFECT IN THE SUBJECT VEHICLES BY STRAIGHTENING AN TWISTED REAR SHOULDER BELT WEBBING AND THEM INSTALLING A PLASTIC COVER THAT WILL PREVENT FURTHER WEBBING INGESTION BY THE WEBBING GUIDE VERTICAL SLOT.THIS ENGINEERIGN ANANLYSIS IS CLOSED.