NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
15 reportsClear category filter170,012 miles · Sep 26, 2016
EngineExterior LightingSuspension
MY 1999 OLDSMOBILE INTRIGUE IS SUFFERING FROM THE SAME PRE-EXISTING ISSUES AS OTHER OLDSMOBILE INTRIGUE'S. SUCH AS THE ENGINE AND ENGINE COOLING, THE EXTERIOR LIGHTING AND ELECTRICAL SYSTEM. I HAVE LOOKED ON WWW.SAFERCAR.GOV AND CALLED 18004249393 AND MY OLDSMOBILE CONSULTANT 1800442653. AS THE ONLY THING SAID IS THAT MY VEHICLE…
Read full complaint
MY 1999 OLDSMOBILE INTRIGUE IS SUFFERING FROM THE SAME PRE-EXISTING ISSUES AS OTHER OLDSMOBILE INTRIGUE'S. SUCH AS THE ENGINE AND ENGINE COOLING, THE EXTERIOR LIGHTING AND ELECTRICAL SYSTEM. I HAVE LOOKED ON WWW.SAFERCAR.GOV AND CALLED 18004249393 AND MY OLDSMOBILE CONSULTANT 1800442653. AS THE ONLY THING SAID IS THAT MY VEHICLE WAS NOT EFFECTED. I DO THINK MY VEHICLE WAS AFFECTED AND HERE ARE THE REASONS. TL* THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE THAT PROGRESSED, WHICH SOUNDED LIKE A KNOCKING ASSOCIATED WITH THE ENGINE ASSEMBLY RODS. WHILE DRIVING AN 20 MPH RATE OF SPEED, THE VEHICLE FAILED TO MOVE. A LOCAL MECHANIC DIAGNOSED THAT A ROD FRACTURED AND WATER AND OIL LEAKED INTO THE ENGINE, WHICH CAUSED A MAJOR ISSUE. THE VEHICLE WAS WAS ABLE TO BE DRIVEN AND WAS PARKED AT THE HOME AND NOW CAN ONLY DRIVEN FOR A SHORT TIME DUE TO OVER HEATING (ENGINE AND ENGINE COOLING), 00V044000 (SEAT BELTS), AND 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED, AND MILEAGE ANY WHERE FROM 10 TO 70 MPH.
NHTSA ODI #10909708
116,000 miles · Jun 4, 2013
Suspension
TL* THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ALIGNMENT FAILED WHILE THE TRACTION CONTROL, CHECK ENGINE AND AVS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE WHEEL SENSOR AND BEARINGS NEEDED TO BE REPLACED. THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ALIGNMENT FAILED WHILE THE TRACTION CONTROL, CHECK ENGINE AND AVS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE WHEEL SENSOR AND BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 116,000. *TR
NHTSA ODI #10515110
3,589 miles · Nov 22, 2004
Electrical SystemEngine And Engine CoolingSteering
POWER STEERING ASSIST (RACK/PINION-LONG SHAFT) UNIT SECOND FAILURE. *BF THE RIGHT REAR WEATHER STRIP WAS DEFORMED, ENGINE STALLED SHORTLY AFTER STARTING, PULSATING NOISE COMING FROM THE FRONT END, TIRE NOISE, RIGHT REAR WINDOW INOPERATIVE, CLUNKING NOISE IN THE FRONT END WHEN TURNING, THE BATTERY LIGHT HAD COME ON FOR 20 MIN…
Read full complaint
POWER STEERING ASSIST (RACK/PINION-LONG SHAFT) UNIT SECOND FAILURE. *BF THE RIGHT REAR WEATHER STRIP WAS DEFORMED, ENGINE STALLED SHORTLY AFTER STARTING, PULSATING NOISE COMING FROM THE FRONT END, TIRE NOISE, RIGHT REAR WINDOW INOPERATIVE, CLUNKING NOISE IN THE FRONT END WHEN TURNING, THE BATTERY LIGHT HAD COME ON FOR 20 MINUTES BUT THE PROBLEM BUT WAS ACTUALLY COOLANT LIGHT, THE ENGINE WOULD CRANK BUT NO START, THE VEHICLE WOULD RUN ROUGH AND DIES, FAILED IGNITION SWITCH, FAILED CRANKSHAFT SENSOR, REMOTE WAS NOT WORKING, LOST POWER STEERING ON A LEFT TURN AND STILL HAD POWER ON RIGHT TURNS, THERE WAS AN OIL LEAK, THERE WAS EXCESSIVE WEAR OF THE INTERMEDIATE STEERING SHAFT, AND EXCESSIVE PLAY IN THE LEFT FRONT HUB AND BEARING ASSEMBLY. *SC
NHTSA ODI #10101807
24,000 miles · Oct 10, 2004
Service Brakes, HydraulicSuspension
BRAKES HAVE BEEN PULSING A LOT TO THE POINT THAT THE CAR DOES NOT BREAK WELL. TOOK IT IN TO HAVE IT FIXED AND WAS TOLD THAT BOTH FRONT ROTORS AND BEARINGS WOULD HAVE TO BE REPLACED. TOLD THAT THIS IS A COMMON PROBLEM WITH THIS CAR. COST ME OVER $1000 FOR THIS REPAIR. *NM
NHTSA ODI #10093875
91,158 miles · Mar 27, 2004
Suspension
FRONT STABILIZER BAR BROKE COMPLETELY THROUGH NEAR PASSENGER SIDE MOUNT WITHOUT PRIOR AUDIBLE NOTICE. AREA OF TUBE BROKEN IS APPROXIMATELY WHERE THE TUBE BEGINS TO FLATTEN OUT FOR MOUNTING TO CONTROL ARM. NO PRIOR ACCIDENT OR UNUSUAL STRESS HAS HAPPENED TO THIS VEHICLE. IT APPEARS THAT IT HAS SLOWLY BEEN "WORKED" UNTIL IT COMP-L…
Read full complaint
FRONT STABILIZER BAR BROKE COMPLETELY THROUGH NEAR PASSENGER SIDE MOUNT WITHOUT PRIOR AUDIBLE NOTICE. AREA OF TUBE BROKEN IS APPROXIMATELY WHERE THE TUBE BEGINS TO FLATTEN OUT FOR MOUNTING TO CONTROL ARM. NO PRIOR ACCIDENT OR UNUSUAL STRESS HAS HAPPENED TO THIS VEHICLE. IT APPEARS THAT IT HAS SLOWLY BEEN "WORKED" UNTIL IT COMP-LETELY CRACKED THROUGH, AND THEN THERE WAS A VERY AUDIBLE BANGING NOISE DURING NORMAL OPERATION OF THE VEHICLE ON CITY STREETS. *AK
NHTSA ODI #10064019
12,000 miles · Feb 21, 2004
SuspensionCrashInjury
IN MINOR SIDEWAY SKID, RR LOWER CONTROL ARM BARS (2), BENT LIKE THEY WERE MADE OF COAT HANGARS. CAR ONLY HAS 12000 MILES ON IT, 1999 OLDS INTRIGUE, GARAGE KEPT. CAR FLIPPED ON TO RIGHT SIDE WHEN CONTROL ARM BARS BENT, CAUSING VEHICLE TO ROLL OVER ON TO SIDE. SON MATTHEW INJURED. THIS MAY BE ALL W BODIES IN GM LINE. CHEAPENED SYS…
Read full complaint
IN MINOR SIDEWAY SKID, RR LOWER CONTROL ARM BARS (2), BENT LIKE THEY WERE MADE OF COAT HANGARS. CAR ONLY HAS 12000 MILES ON IT, 1999 OLDS INTRIGUE, GARAGE KEPT. CAR FLIPPED ON TO RIGHT SIDE WHEN CONTROL ARM BARS BENT, CAUSING VEHICLE TO ROLL OVER ON TO SIDE. SON MATTHEW INJURED. THIS MAY BE ALL W BODIES IN GM LINE. CHEAPENED SYSTEM, NEW STANDARDS ARE NEEDED TO PREVENT VEHICLE ROLL OVER IN MINOR SKID. SON WAS NOT SPEEDING AT TIME OF ACCIDENT. AFTER OWNING 38 GM CARS, THIS DISGUSTS ME. *JB
NHTSA ODI #10058653
35,000 miles · Jan 7, 2003
Suspension
THE BEARINGS ON THE COUNTER BALANCE SHAFT WENT BAD, CAUSING A KNOCKING NOISE. TS *JG
NHTSA ODI #10002178
Mileage unknown · Jan 28, 2002
Suspension
WHILE DRIVING, AND UPON MAKING A U TURN AT 5MPH CONSUMER SUDDENLY HEARD A GRINDING NOISE AND FRONT WHEEL CAME COMPLETELY OFF VEHICLE, CONSUMER CONTACTED DEALER, AFTER INSPECTING THE VEHICLE, THE DEALER DETERMINED THAT THE LOWER BALL JOINT WAS THE CAUSE OF THE FAILURE.*AK *SLC
NHTSA ODI #8002915
Mileage unknown · Feb 28, 2001
Service Brakes, HydraulicSteeringSuspension
VEHICLE HAS HAD STRUTS REPLACED. *SLC
NHTSA ODI #559993
Mileage unknown · Feb 18, 2001
Seat BeltsStructureSuspension
CONSUMER STATES THAT THE FRONT END HAS A VERY LOUD RATTLING NOISE WHILE DRIVING ON BUMPY ROADS. *SLC
NHTSA ODI #785287
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.
Consequence & remedy
Consequence: THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.
Remedy: DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.
Oct 5, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.8L V6 ENGINE. SOME OF THESE VEHICLES WERE BUILT WITHOUT A HEATER HOSE CLIP WHICH COULD ALLOW THE HOSE TO SAG AND CONTACT THE OXYGEN SENSOR RESULTING IN A COOLANT LEAK.
Consequence & remedy
Consequence: IF A COOLANT LEAK WERE TO OCCUR, AND LEAKING COOLANT CONTACTED THE HOT EXHAUST MANIFOLD, AN ENGINE COMPARTMENT FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A HEATER HOSE CLIP.
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02005 · Headlamps Dim/flicker
Opened Jan 18, 2002 · Closed Apr 15, 2002
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA99019 · Rear Shoulder Belt Malfunction
Opened Jul 7, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
THE ALLEGED DEFECT CONCERNS TWO MAJOR SYMPTOMS:FAILURE TO RETRACT WEBBING AND INABILITY TO EXTEND THE WEBBINNG FOR USE. THE ROOT CAUSE OF THESE SYMPTOMS IS THE DESIGN OF THE TRIM BEZEL THROUGH WHICH THE SEBBING PASSES. BUILT INTO THE REAR PACKAGE SHELF, THE BEZEL INCLUDES A VERTICAL SLOT TO FACILITATE VEHICLE ASSEMBLY.THE SLOT IS POSITIONED SUCH THAT THE SHOULDER BELT WEBBING TENDS TO SLIP INTO IT.WEBBING INGESTION BY THE VERTICAL SLOT MAY RETARD WEBBING RETRACTION, OR ALLOW WEBBING TWISTS TO ACCUMULATE ON THE RETRACTOR SPOOL.IN EITHER CASE, THE RETRACTOR MAY FAIL TO MAINTAIN APPROPRIATE TENSION ON THE SEAT OCCUPANT.FAILURE OF THE SHOULDER BELT TO COMPLETELY RETRACT MAY ALSO RESULT IN AN INABILITY TO EXTEND IT FOR USE IF THE CHILD RESTRAINT CINCH FEATURE HAS BEEN INADVERTENTLY ENGAGE (BY EXTENDING THE WEBBING TO ITS MAXIMUM LENGTH).GM WILL REMEDY THE ALLEGED DEFECT IN THE SUBJECT VEHICLES BY STRAIGHTENING AN TWISTED REAR SHOULDER BELT WEBBING AND THEM INSTALLING A PLASTIC COVER THAT WILL PREVENT FURTHER WEBBING INGESTION BY THE WEBBING GUIDE VERTICAL SLOT.THIS ENGINEERIGN ANANLYSIS IS CLOSED.
Illustration