IllustrationMY CAR SHUT OFF WHILE I WAS STOPPED AT A STOP SIGN. THE RADIO AND AIR WERE STILL ON. THE CAR WOULD NOT MOVE. IN ORDER FOR ME TO MOVE THE VEHICLE, I HAD TO PUT IT INTO PARK, TURN THE IGNITION SWITCH TO OFF AND TURN THE IGNITION BACK TO ON. BASICALLY TURN IT ALL THE WAY OFF AND RESTART THE VEHICLE. *TR
2015 Nissan Versa
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2015 Nissan Versa do not stand out strongly from the model-year median of 95.
About this comparison →How this year compares
Owner complaints by model year
Compare all Versa years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
3025–50K
2850–75K
1875–100K
8100–150K
1150K+
123 reports with mileage · 45 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports2 fire reports14 injury reports
Power Train complaints
47 reportsTHE CAR DON'T RUNS GOOD!, HAVE PROBLEMS WITH THE TRANSMISSION ONLY HAVE 47,677 MILES, O THINK HAVE WARRANTY! *TR
FEB. 10TH 2020 CVT TRANSMISSION STARTED SHUDDERING AND THEN BROKE DOWN IN VALDOSTA GEORIGA. VALDOSTA NISSAN SAID TRANSMISSION WAS NOT COVERED UNDER RECALL FROM CLASS ACTION SUIT. HAD TRANSMISSION REPLACED AT VALDOSTA TRANSMISSION WITH REMANUFACTURED NISSAN TRANSMISSION ON FEB. 13TH 2020. DROVE 992 MILES TO JACKSON MICH. STARTED …
Read full complaint
FEB. 10TH 2020 CVT TRANSMISSION STARTED SHUDDERING AND THEN BROKE DOWN IN VALDOSTA GEORIGA. VALDOSTA NISSAN SAID TRANSMISSION WAS NOT COVERED UNDER RECALL FROM CLASS ACTION SUIT. HAD TRANSMISSION REPLACED AT VALDOSTA TRANSMISSION WITH REMANUFACTURED NISSAN TRANSMISSION ON FEB. 13TH 2020. DROVE 992 MILES TO JACKSON MICH. STARTED HAVING PROBLEMS WITH NEWLY INSTALLED TRANSMISSION SO BRIGHT THE 201( NISSAN VERSA TO JACKSON NISSAN. WAS INFORMED BY SERVICE MANAGER JAMIE BALDWIN THAT TRANSMISSION FAILED DUE TO TRANSMISSION COOLING TUBE IN RADIATOR FAILED. OF COURSE THE RADIATOR FAILURE WAS NOT COVERED ANYMORE FROM THE EARLIER CLASS ACTION RADIATOR SUIT. I ALSO FILED A CLAIM WITH CONSUMER AFFAIR NISSAN, CASE #39608867. THE REPRESENTATIVE (AUSTIN) I SPOKE WITH DENIED THE CLAIM. I'VE TRIED TO REACH AUSTIN (615) 725-7582 A FEW TIMES TO GET ANY DOCUMENTATION THAT WAS USED FOR HIS DECISION TO DENY THIS CLAIM, BUT HE HAS NOT RETURNED ANY OF MY CALLS. I BELIEVE THAT NISSAN HAS AN OBLIGATION TO THE CONSUMER WHEN THEY HAVE SOLD DEFECTIVE CVT TRANSMISSIONS AND RADIATORS.
TL* THE CONTACT OWNS A 2015 NISSAN VERSA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE BEGAN TO LOSE POWER AND JERK, THE CONTACT VEERED TO THE SHOULDER OF THE ROAD WHERE ANOTHER VEHICLE CRASHED INTO THE REAR VEHICLE, CONTACT PLACED VEHICLE IN PARK TURNED T…
Read full complaint
TL* THE CONTACT OWNS A 2015 NISSAN VERSA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE BEGAN TO LOSE POWER AND JERK, THE CONTACT VEERED TO THE SHOULDER OF THE ROAD WHERE ANOTHER VEHICLE CRASHED INTO THE REAR VEHICLE, CONTACT PLACED VEHICLE IN PARK TURNED THE VEHICLE OFF AND BACK ON WHICH FAILED TO RESUME BACK TO NORMAL. NO AIRBAGS DEPLOYED. CONTACT SUSTAINED CHEST INJURIES FROM HITTING STEERING WHEEL. NO MEDICAL ATTENTION WAS CONTACTED. NO POLICE REPORT WAS MADE. THE VEHICLE RECEIVED MINOR DAMAGE'S TO THE REAR BUMPER. THE CONTACT MANAGED TO DRIVE THE VEHICLE TO THE CONTACT DEALER (NISSAN SOUTH UNION CITY 4080 JONESBORO RD, UNION CITY, GA 30291 (678) 379-2598) WHERE IT WAS TEST DRIVEN BUT UNABLE TO DUPLICATE THE ISSUES. THE VEHICLE WAS NOT REPAIRED, STATED ISSUES CONTINUED. THE VEHICLE WAS DRIVEN TO THE RESIDENTS WHERE AN INDEPENDENT MECHANIC CAME OUT AND DIAGNOSES THE VEHICLE WHICH DETERMINED THAT THE TCM (TRANSMISSION CONTROL MODEL) FAULTILY AND NEEDED TO BE REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT NO RECALLS WAS UNDER THE VIN. THE FAILURE MILEAGE APPROXIMATELY 66,000. *LN*JB
PLEASE TELL THE GOVERNMENT OR WHOEVER IS THE BIGGEST BOSS OF CAR MANUFACTURER NISSAN TO PUNISH NISSAN SEVERELY AND EXTREMELY FOR MAKING UNSAFE CARS THAT PUTS CONSUMER A T A SEVERE SAFETY RISK. FOR THEIR TRANSMISSIONS, SHOCKS, STRUTS, EVERYTHING IN THE CAR. EVER SINCE I GOT THE CAR IN OCTOBER 2016 I HAVE TO BRING IT TO THE SHOP …
Read full complaint
PLEASE TELL THE GOVERNMENT OR WHOEVER IS THE BIGGEST BOSS OF CAR MANUFACTURER NISSAN TO PUNISH NISSAN SEVERELY AND EXTREMELY FOR MAKING UNSAFE CARS THAT PUTS CONSUMER A T A SEVERE SAFETY RISK. FOR THEIR TRANSMISSIONS, SHOCKS, STRUTS, EVERYTHING IN THE CAR. EVER SINCE I GOT THE CAR IN OCTOBER 2016 I HAVE TO BRING IT TO THE SHOP EVERY 2-3 MONTHS, THERE IS ALWAYS SOMETHING WRONG WITH THE CAR, OCTOBER 2019 I HAD TO REPLACED THE FAN, BEFORE THAT THE MOTOR MOUNTS, THE SHOCKS NEEDS TO BE REPLACED, THE STRUTS TOO, THE AIRBAG LIGHT CAME ON AND STAYS ON, MULTIPLE PROBLEMS WITH THE CAR.. REPLACED THE TRANSMISSION BEFORE AND THE TRANSMISSION NEEDS TO BE REPLACED AGAIN. THE CAR JIGGLES, WADDLE, THE SHOCK, STRUTS, GETS STARTS TO WORN OUT AT 20,000 MILES, AT 50, 60, 70, 80,000 MILES THE CAR EXTREMELY UNSTABLE WHEN DRIVING ON THE HIGHWAY. IT FEELS SO LIGHT, FEELS LIKE ITS WHEELS WILL BREAK OR PULL OFF TO ONE SIDE. CAR IS PHYSICALLY UNSTABLE AND BOUNCE WAY TOO MUCH. THE CAR MOTOR MOUNTS MAKES SO MUCH CLICKING NOISE, BRAKES TERRIBLE. MAJOR CAR SAFETY HAZARD. 90.000 MILES CURRENTLY CAR IS NOT SAFE TO DRIVE DUE TO TRANSMISSION PROBLEMS MECHANIC SAID AND I CANNOT REPAIR IT. PLEASE MAKE NISSAN REFUNDED ME MY MONEY & TAKE FULL RESPONSIBILITY FOR THEIR FAULTY CAR. THEIR IS A CURRENT CLASS ACTION LAWSUIT AGAINST THEM FOR THEIR FAULTY TRANSMISSIONS WILL STOP WORKING ON THE NISSAN VERSA AND SENTRA CARS FROM 2013-2017 YEAR MODELS. AND EVEN IF YOU REPLACE THE TRANSMISSION IT WILL FAIL AFTER 30,000 MILES. PLEASE MAKE NISSAN PAY FOR THEIR FRAUDULENT CAR PARTS THAT THEY MADE THAT IS GOING TO NOT WORK SOON. FOR A MONTH I ALSO DROVE A 2019 NISSAN SENTRA RENTAL BRAND NEW CAR AT 1000 MILES. AT 5,000 -7,000 MILES THE CAR TRANSMISSION MAKES SO MUCH NOISE. NISSAN SENTRA AND VERSSA CARS ARE NOT SAFE. NISSAN NEEDS TO BE PUNISHED EXTREMELY AND SEVERELY FOR PUTTING PEOPLE'S SAFETY AT RISK..
12/5/2018 I REPLACED THE TRANSMISSION ON THE NISSAN VERSA 2015 AT 37,000 MILES. 2 MONTHS AT 42,000 MILES LATER CAR MAKING NOISE NOT KNOWING WHAT IT IS, AFTER MANY CAR CHECKS WITH AUTO MECHANICS. ON SEPTEMBER 2019 AT 93,000 MILES I RECEIVED A POST CARD ABOUT A CLASS ACTION LAWSUIT FILED BY NISSAN OWNERS AGAINST 2013-2017 NISSAN…
Read full complaint
12/5/2018 I REPLACED THE TRANSMISSION ON THE NISSAN VERSA 2015 AT 37,000 MILES. 2 MONTHS AT 42,000 MILES LATER CAR MAKING NOISE NOT KNOWING WHAT IT IS, AFTER MANY CAR CHECKS WITH AUTO MECHANICS. ON SEPTEMBER 2019 AT 93,000 MILES I RECEIVED A POST CARD ABOUT A CLASS ACTION LAWSUIT FILED BY NISSAN OWNERS AGAINST 2013-2017 NISSAN VERSA AND SENTRA CARS ''CVT' TRANSMISSIONS NOT PROPERLY WORKING TO NOT WORKING AT ALL. I FINALLY HAD THE CAR CHECKED AND THE NISSAN ONLY MECHANIC SAID MY 2015 NISSAN VERSA IS NOT SAFE TO DRIVE DUE TO THE TRANSMISSION NOT WORKING PROPERLY AND IT NEEDS TO BE REPLACED FOR A THIRD TIME AT MOSSY NISSAN HOUSTON, TX. ITS EXTREMELY NOT FAIR. NISSAN MANUFACTURE FAIL TO PROVIDE 100% OF REPAIR COST AND REFUSE TO TAKE FULL RESPONSIBILITY OF THE PAIN AND SUFFERING THEIR TERRIBLE CAR TRANSMISSION CAUSE ME. MANY PEOPLE AND TRANSMISSION REPAIR SHOPS KNOWS NISSAN TRANSMISSIONS ARE NOT GOOD. YOU CAN REPLACE A NISSAN TRANSMISSION TODAY AND THE SAME YEAR OR NEXT YEAR YOU HAVE TO REPLACE THE TRANSMISSION AGAIN. ITS EXTREMELY NOT FAIR WHAT NISSAN MANUFACTURER & DEALERSHIP DID. II REPLACED THE FIRST TRANSMISSION AT 37,000 MILES IN YEAR 2 OF OWNING MY CAR , AT 42,000 OR 50,000 MILES THE TRANSMISSION STARTS GOING BAD. AND YEAR 3 AT 93,000 I HAVE TO REPLACED AGAIN. THAT IS A MAJOR HIGHWAY SAFETY HAZARD. THE REASON I DID NOT HAVE A MAJOR ACCIDENT WITH THIS CAR I STRONGLY BELIEVE, IS BECAUSE I PRAYED EVERYDAY WHEN I START DRIVING FOR JEHOVAH GOD TO PROTECT ME, NOT TO HAVE AN ACCIDENT, AND NOT TO KILL ANYONE WITH THIS CAR. SO EVERY 30,000 MILES OR EVERY YEAR YOU HAVE TO REPLACE THE TRANSMISSION ON A NISSAN VERSA DEPENDING HOW MUCH YOU DRIVE FOR THE YEAR.. I HAD TO DEAL WITH EXTREME STRESS BEEN IN THE HOSPITAL 3 TIMES. PLEASE MAKE MONEY GREEDY NISSAN PAY FOR THEIR DELIBERATE FRAUD ACT. I DON'T DRIVE THE CAR BECAUSE ITS UNSAFE TO DRIVE WITH A VERY BAD TRANSMISSION.
NO ACCELERATION. WHEN TURNING CAR STUTTERS. THE CAR RUNS THIS WAY ALL THE TIME. TOOK THE CAR TO THE DEALER, TECH FOUND CODE P1715,P2765,AND P0965
TL* THE CONTACT OWNS A 2015 NISSAN VERSA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE FAILED TO ACCELERATE PROPERLY AND, EVENTUALLY, FAILED TO START. THE VEHICLE WAS TAKEN TO PASSPORT NISSAN (5000 AUTH WAY, MARLOW HEIGHTS, MD) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT RE…
Read full complaint
TL* THE CONTACT OWNS A 2015 NISSAN VERSA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE FAILED TO ACCELERATE PROPERLY AND, EVENTUALLY, FAILED TO START. THE VEHICLE WAS TAKEN TO PASSPORT NISSAN (5000 AUTH WAY, MARLOW HEIGHTS, MD) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000.
HAVING PROBLEM STOPPING MY CAR IN WET OR SNOWY WEATHER. ANTI-LOCK BREAKS NOT WORKING CORRECTLY. THERE IS A RECALL FOR MY YEAR BUT WHEN I DO A SEARCH IT SAYS THERE ARE ZERO RECALLS FOR MY VEHICLE. TRANSMISSION DOES NIT SHIFT PROPERLY.
TL* THE CONTACT OWNS A 2015 NISSAN VERSA. THE CONTACT STATED THAT THE TRANSMISSION FAILED. WHEN DRIVING THE VEHICLE, IT FAILED TO ACCELERATE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO RIVERSIDE NISSAN (8330 INDIANA AVE B, RIVERSIDE, CA 92504, (951) 509-6500) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSIO…
Read full complaint
TL* THE CONTACT OWNS A 2015 NISSAN VERSA. THE CONTACT STATED THAT THE TRANSMISSION FAILED. WHEN DRIVING THE VEHICLE, IT FAILED TO ACCELERATE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO RIVERSIDE NISSAN (8330 INDIANA AVE B, RIVERSIDE, CA 92504, (951) 509-6500) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THEY COULD ONLY ASSIST WITH 60% OF THE REPAIR COST. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS INVALID.
Official recalls
115V507000 · Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:accelerator Pedal
Aug 12, 2015
Nissan North America, Inc. (Nissan) is recalling certain model year 2012-2015 Nissan Versa sedan vehicles manufactured June 9, 2011, to March 11, 2015, and 2014-2015 Nissan Versa Note vehicles manufactured April 23, 2013, to March 11, 2015. The affected vehicles have a center console trim panel that may catch the driver's shoe and delay the transition from the accelerator pedal to the brake pedal.
Consequence & remedy
Consequence: A delay in the application of the brake pedal would lengthen the distance needed to stop the vehicle and increase the risk of a crash.
Remedy: Nissan will notify owners, and dealers will modify the console trim panel, free of charge. The recall began on September 14, 2015. Owners may contact Nissan customer service at 1-800-647-7261.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
Nissan North America, Inc. (Nissan) is recalling certain model year 2012-2015 Nissan Versa sedan vehicles manufactured June 9, 2011, to March 11, 2015, and 2014-2015 Nissan Versa Note vehicles manufactured April 23, 2013, to March 11, 2015. The affected vehicles have a center console trim panel that may catch the driver's shoe and delay the transition from the accelerator pedal to the brake pedal.
Consequence: A delay in the application of the brake pedal would lengthen the distance needed to stop the vehicle and increase the risk of a crash.
Remedy: Nissan will notify owners, and dealers will modify the console trim panel, free of charge. The recall began on September 14, 2015. Owners may contact Nissan customer service at 1-800-647-7261.
Service Brakes, Hydraulic:pedals And Linkages
Nissan North America, Inc. (Nissan) is recalling certain model year 2012-2015 Nissan Versa sedan vehicles manufactured June 9, 2011, to March 11, 2015, and 2014-2015 Nissan Versa Note vehicles manufactured April 23, 2013, to March 11, 2015. The affected vehicles have a center console trim panel that may catch the driver's shoe and delay the transition from the accelerator pedal to the brake pedal.
Consequence: A delay in the application of the brake pedal would lengthen the distance needed to stop the vehicle and increase the risk of a crash.
Remedy: Nissan will notify owners, and dealers will modify the console trim panel, free of charge. The recall began on September 14, 2015. Owners may contact Nissan customer service at 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
EA15003 · Pedal Operation Interference
Opened Apr 1, 2015 · Closed Sep 1, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:pedals And Linkages; Vehicle Speed Control:accelerator Pedal
On August 11, 2015, Nissan North America, Inc., submitted a Defect Information Report (DIR) describing a condition that may impede the driver's ability to transition quickly and smoothly from the accelerator pedal to the brake pedal in certain model year (MY) 2012 through 2015 Nissan Versa Sedans and MY 2014 through 2015 Nissan Versa Note vehicles (NHTSA Recall No. 15V-507).According to Nissan's DIR, in certain circumstances related to driver foot position and shoe type, the right edge of the driver?s shoe may catch the edge of the center console lower trim panel.Nissan indicated that this condition could cause a slight delay in the smooth transition between the accelerator pedal and the brake pedal which may increase the braking distance; therefore increasing the risk of a crash.Nissan's recall instructs dealers to trim the console panel so that the leading edge is at a greater distance from the driver?s foot.Nissan had previously issued a service campaign (Nissan Campaign ID #P5308; TSB #NTB15-033) on April 16, 2015, to provide the remedy for the same set of vehicles before deciding to change the program to a safety recall.Of the approximately 421,305 vehicles covered by recall 15V-507, approximately 122,558 have already been repaired under the service campaign. ODI's investigation also examined allegations that an HVAC duct in the driver's footwell area may interfere with the driver's right foot in certain circumstances.ODI's analysis of all complaints related to foot obstructions in the subject vehicles identified 45 complaints, 7 crashes and 1 minor soft tissue injury.Thirty-five (35) of the complaints, all 7 crashes and the only injury were caused by the trim panel condition which is the subject of the recall.ODI will continue to monitor complaints related to the HVAC duct condition.This investigation is closed based on Nissan's recall.The VOQs associated with the closing of this investigation are: 10725339, 10723544, 10711794, 10691631, 10649259, 10640644, 10629161, 10614957, 10610356, 10606832, 10606766, 10606670, 10597004, 10573057, 10503811, and 10498000.
Additional source detail variants (3)
Service Brakes, Hydraulic
On August 11, 2015, Nissan North America, Inc., submitted a Defect Information Report (DIR) describing a condition that may impede the driver's ability to transition quickly and smoothly from the accelerator pedal to the brake pedal in certain model year (MY) 2012 through 2015 Nissan Versa Sedans and MY 2014 through 2015 Nissan Versa Note vehicles (NHTSA Recall No. 15V-507).According to Nissan's DIR, in certain circumstances related to driver foot position and shoe type, the right edge of the driver?s shoe may catch the edge of the center console lower trim panel.Nissan indicated that this condition could cause a slight delay in the smooth transition between the accelerator pedal and the brake pedal which may increase the braking distance; therefore increasing the risk of a crash.Nissan's recall instructs dealers to trim the console panel so that the leading edge is at a greater distance from the driver?s foot.Nissan had previously issued a service campaign (Nissan Campaign ID #P5308; TSB #NTB15-033) on April 16, 2015, to provide the remedy for the same set of vehicles before deciding to change the program to a safety recall.Of the approximately 421,305 vehicles covered by recall 15V-507, approximately 122,558 have already been repaired under the service campaign. ODI's investigation also examined allegations that an HVAC duct in the driver's footwell area may interfere with the driver's right foot in certain circumstances.ODI's analysis of all complaints related to foot obstructions in the subject vehicles identified 45 complaints, 7 crashes and 1 minor soft tissue injury.Thirty-five (35) of the complaints, all 7 crashes and the only injury were caused by the trim panel condition which is the subject of the recall.ODI will continue to monitor complaints related to the HVAC duct condition.This investigation is closed based on Nissan's recall.The VOQs associated with the closing of this investigation are: 10725339, 10723544, 10711794, 10691631, 10649259, 10640644, 10629161, 10614957, 10610356, 10606832, 10606766, 10606670, 10597004, 10573057, 10503811, and 10498000.
Service Brakes, Hydraulic:pedals And Linkages
On August 11, 2015, Nissan North America, Inc., submitted a Defect Information Report (DIR) describing a condition that may impede the driver's ability to transition quickly and smoothly from the accelerator pedal to the brake pedal in certain model year (MY) 2012 through 2015 Nissan Versa Sedans and MY 2014 through 2015 Nissan Versa Note vehicles (NHTSA Recall No. 15V-507).According to Nissan's DIR, in certain circumstances related to driver foot position and shoe type, the right edge of the driver?s shoe may catch the edge of the center console lower trim panel.Nissan indicated that this condition could cause a slight delay in the smooth transition between the accelerator pedal and the brake pedal which may increase the braking distance; therefore increasing the risk of a crash.Nissan's recall instructs dealers to trim the console panel so that the leading edge is at a greater distance from the driver?s foot.Nissan had previously issued a service campaign (Nissan Campaign ID #P5308; TSB #NTB15-033) on April 16, 2015, to provide the remedy for the same set of vehicles before deciding to change the program to a safety recall.Of the approximately 421,305 vehicles covered by recall 15V-507, approximately 122,558 have already been repaired under the service campaign. ODI's investigation also examined allegations that an HVAC duct in the driver's footwell area may interfere with the driver's right foot in certain circumstances.ODI's analysis of all complaints related to foot obstructions in the subject vehicles identified 45 complaints, 7 crashes and 1 minor soft tissue injury.Thirty-five (35) of the complaints, all 7 crashes and the only injury were caused by the trim panel condition which is the subject of the recall.ODI will continue to monitor complaints related to the HVAC duct condition.This investigation is closed based on Nissan's recall.The VOQs associated with the closing of this investigation are: 10725339, 10723544, 10711794, 10691631, 10649259, 10640644, 10629161, 10614957, 10610356, 10606832, 10606766, 10606670, 10597004, 10573057, 10503811, and 10498000.
Vehicle Speed Control:accelerator Pedal
On August 11, 2015, Nissan North America, Inc., submitted a Defect Information Report (DIR) describing a condition that may impede the driver's ability to transition quickly and smoothly from the accelerator pedal to the brake pedal in certain model year (MY) 2012 through 2015 Nissan Versa Sedans and MY 2014 through 2015 Nissan Versa Note vehicles (NHTSA Recall No. 15V-507).According to Nissan's DIR, in certain circumstances related to driver foot position and shoe type, the right edge of the driver?s shoe may catch the edge of the center console lower trim panel.Nissan indicated that this condition could cause a slight delay in the smooth transition between the accelerator pedal and the brake pedal which may increase the braking distance; therefore increasing the risk of a crash.Nissan's recall instructs dealers to trim the console panel so that the leading edge is at a greater distance from the driver?s foot.Nissan had previously issued a service campaign (Nissan Campaign ID #P5308; TSB #NTB15-033) on April 16, 2015, to provide the remedy for the same set of vehicles before deciding to change the program to a safety recall.Of the approximately 421,305 vehicles covered by recall 15V-507, approximately 122,558 have already been repaired under the service campaign. ODI's investigation also examined allegations that an HVAC duct in the driver's footwell area may interfere with the driver's right foot in certain circumstances.ODI's analysis of all complaints related to foot obstructions in the subject vehicles identified 45 complaints, 7 crashes and 1 minor soft tissue injury.Thirty-five (35) of the complaints, all 7 crashes and the only injury were caused by the trim panel condition which is the subject of the recall.ODI will continue to monitor complaints related to the HVAC duct condition.This investigation is closed based on Nissan's recall.The VOQs associated with the closing of this investigation are: 10725339, 10723544, 10711794, 10691631, 10649259, 10640644, 10629161, 10614957, 10610356, 10606832, 10606766, 10606670, 10597004, 10573057, 10503811, and 10498000.