NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
678 reports40,000 miles · Dec 21, 2008
Visibility
I HAVE A 2004 NISSAN MURANO SL. AT ABOUT 40,000 MILES, MY DRIVER SIDE SUN VISOR STARTED FALLING. IT WILL NOT STAY IN POSITION, AND HANGS RIGHT IN FRONT OF MY FACE, UNLESS I KEEP IT TACKED UP WITH VELCRO. THE PASSENGER SIDE VISOR ALSO SWINGS DOWN SOMETIMES, BUT NOT AS BAD AS THE DRIVER SIDE. I DID AN INTERNET SEARCH ON "MURANO SU…
Read full complaint
I HAVE A 2004 NISSAN MURANO SL. AT ABOUT 40,000 MILES, MY DRIVER SIDE SUN VISOR STARTED FALLING. IT WILL NOT STAY IN POSITION, AND HANGS RIGHT IN FRONT OF MY FACE, UNLESS I KEEP IT TACKED UP WITH VELCRO. THE PASSENGER SIDE VISOR ALSO SWINGS DOWN SOMETIMES, BUT NOT AS BAD AS THE DRIVER SIDE. I DID AN INTERNET SEARCH ON "MURANO SUN VISOR" AND FOUND OUT VERY QUICKLY THAT THIS IS A WIDESPREAD PROBLEM THAT NEEDS TO BE ADDRESSED BY NISSAN WITH A FULL RESOLUTION; I.E. RECALL. THE DEALER WANTS NEARLY $300 TO REPLACE ONE VISOR, WHICH IS LIKELY TO BREAK AGAIN, ACCORDING TO SEVERAL ACCOUNTS IN THE MESSAGE BOARDS. THIS IS A SERIOUS SAFETY ISSUE. I HAVE ALMOST HAD TWO COLLISIONS BECAUSE OF IT, AND ONCE, I RAN A RED LIGHT BECAUSE OF IT FALLING DOWN. IF I KEEP IT TACKED UP, THEN OF COURSE THERE ARE TIMES OF THE DAY WHEN THE SUN IS BLINDING ME, SO IT IS NOT SAFE NO MATTER WHAT I DO. *TR
NHTSA ODI #10252375
29,000 miles · Dec 6, 2008
Fuel System, GasolineTires
DID A THROTTLE BODY CLEANING ON A NISSAN MURANO AND THE CHECK ENGINE LIGHT CAME ON. THE DEALER SAID IT WAS A MONEY MAKER AND MANY SHOP THAT CLEAN THE THROTTLE BODY HAVE TO COME TO THEM FOR THE RE-LEARNING OF THE IDLE AIR CONTROL VALVE. THIS IS CRAZY ,I HAVE DONE THIS ON MY PORSCHE AND MY FORDS AND CHEVY AND HAVE NEVER HAD THIS H…
Read full complaint
DID A THROTTLE BODY CLEANING ON A NISSAN MURANO AND THE CHECK ENGINE LIGHT CAME ON. THE DEALER SAID IT WAS A MONEY MAKER AND MANY SHOP THAT CLEAN THE THROTTLE BODY HAVE TO COME TO THEM FOR THE RE-LEARNING OF THE IDLE AIR CONTROL VALVE. THIS IS CRAZY ,I HAVE DONE THIS ON MY PORSCHE AND MY FORDS AND CHEVY AND HAVE NEVER HAD THIS HAPPEN. NISSAN SHOULD HAVE A WARNING STICKER ON THE THROTTLE BODY TO SEE MANUAL -THE MANUAL SHOULD STATE DO NOT CLEAN OR YOU WILL NEED TO GO TO DEALER TO RE-LEARN THE IDLE AIR CONTROL SYSTEM. *TR
NHTSA ODI #10250950
85,000 miles · Dec 3, 2008
Visibility
I HAVE JUST PURCHASED A 2004 NISSAN MURANO AND HAVE BEEN READING ON THE FORUM WEBSITES REGARDING THE SUN VISOR. MY SUN VISOR WILL NOT STAY UP ON IT'S OWN IN THIS VEHICLE. IT MAY STAY UP FOR A FEW MINUTES, BUT IF YOU HIT A BUMP WRONG THE SUN VISOR CAN SWING DOWN AND BLOCK VIEW OF THE WINDSHIELD. THIS VISOR WILL ALSO NOT STAY U…
Read full complaint
I HAVE JUST PURCHASED A 2004 NISSAN MURANO AND HAVE BEEN READING ON THE FORUM WEBSITES REGARDING THE SUN VISOR. MY SUN VISOR WILL NOT STAY UP ON IT'S OWN IN THIS VEHICLE. IT MAY STAY UP FOR A FEW MINUTES, BUT IF YOU HIT A BUMP WRONG THE SUN VISOR CAN SWING DOWN AND BLOCK VIEW OF THE WINDSHIELD. THIS VISOR WILL ALSO NOT STAY UP TOWARDS THE WINDSHIELD WHEN I ACTUALLY WANT TO USE IT TO BLOCK THE SUN SO I CAN SEE. I FEEL IT IS A SAFETY CONCERN SINCE I DON'T KNOW WHEN THE SUN VISOR WILL FLIP DOWN AND BLOCK MY VIEW OF THE ROAD UNEXPECTEDLY. *TR
NHTSA ODI #10250620
78,000 miles · Nov 30, 2008
Visibility
I HAVE A 2004 NISSAN MURANO. THE DRIVER SUNVISOR HAS FAILED. IT IS AN EXTREME SAFETY HAZARD TO BE DRIVING DOWN THE ROAD AND HAVE THE VISOR DROP DOWN. I DOES NOT STAY IN THE UP POSITION. WHEN DOWN, IT'S FLOPPY. THE DEALER WILL NOT COVER THIS ITEM AND REPLACE. NO DEATHS YET! *TR
NHTSA ODI #10250183
Mileage unknown · Nov 26, 2008
Seats
I OWN A 2004 NISSAN MURANO, AND TODAY AFTER ONLY OWNING THE CAR FOR LESS THAN A YEAR, THE DRIVER SEAT (AUTOMATIC) BROKE AND IS LEANING TO THE LEFT. I AM COVERED UNDER AN EXTENDED WARRANTY AND THIS PROBLEM WILL BE COVERED BY NISSAN, BUT TO THOSE MANY OWNERS OF THIS VEHICLE THAT THIS HAS HAPPENED TOO, I FEEL OBLIGATED TO REPORT TH…
Read full complaint
I OWN A 2004 NISSAN MURANO, AND TODAY AFTER ONLY OWNING THE CAR FOR LESS THAN A YEAR, THE DRIVER SEAT (AUTOMATIC) BROKE AND IS LEANING TO THE LEFT. I AM COVERED UNDER AN EXTENDED WARRANTY AND THIS PROBLEM WILL BE COVERED BY NISSAN, BUT TO THOSE MANY OWNERS OF THIS VEHICLE THAT THIS HAS HAPPENED TOO, I FEEL OBLIGATED TO REPORT THIS ISSUE. I FEEL THIS IS A DRIVING HAZARD AND COULD CAUSE A SERIOUS ACCIDENT OR EVEN DEATH. WHEN THE SEAT BROKE, I WAS IN MOVING TRAFFIC OF AROUND 45 MILES AN HOUR, AND I ALMOST SWERVED TO THE LEFT AND HIT A CAR. THIS IS A PARTS ISSUE THAT NISSAN SHOULD COVER. I THINK IT WOULD BE UNJUST TO ALLOW NISSAN TO NOT RECALL THIS ITEM AND REPAIR THIS ITEM FOR FREE. I WEIGH LESS THAN 185, SO I DOUBT THIS PROBLEM WAS DUE TO WEIGHT ISSUES. IT'S A DEFECTIVE PARTS ISSUE. PLEASE CONTACT NISSAN TO GET THIS CORRECTED. *TR
NHTSA ODI #10249964
38,000 miles · Nov 23, 2008
Fuel System, GasolineLatches/locks/linkages
NISSAN MURANO 2004 FUEL DOOR WOULD NOT OPEN. THE PROBLEM STARTED AS INTERMITTENT AND NOW CANNOT OPEN THE DOOR TO REFUEL THE CAR. TROUBLESHOOTED IT TO A FAULTY RELAY. *TR
NHTSA ODI #10249592
32,000 miles · Nov 8, 2008
Latches/locks/linkages
1. HAVING A SECURE ENVIRONMENT IS PARAMOUNT IN CERTAIN NEIGHBORHOODS. WHEN LOCKING THE DOORS IT'S IMPERATIVE NOBODY CAN GAIN ACCESS AT WILL BY WALKING UP TO THE CAR. IF ANYONE CAN SIMPLY OPEN THE DOOR TO GAIN ACCESS, CARJACKING, INJURY, OR EVEN MURDER IS EASIER. IF THE DOORS LOCKED PROPERLY THIS PROVIDES A MORE SECURE ENVIRONMEN…
Read full complaint
1. HAVING A SECURE ENVIRONMENT IS PARAMOUNT IN CERTAIN NEIGHBORHOODS. WHEN LOCKING THE DOORS IT'S IMPERATIVE NOBODY CAN GAIN ACCESS AT WILL BY WALKING UP TO THE CAR. IF ANYONE CAN SIMPLY OPEN THE DOOR TO GAIN ACCESS, CARJACKING, INJURY, OR EVEN MURDER IS EASIER. IF THE DOORS LOCKED PROPERLY THIS PROVIDES A MORE SECURE ENVIRONMENT FOR THIS TYPE OF SCENARIO. 2. NISSAN KNOWING THERE IS A SECURITY PROBLEM WITH THEIR LOCKING MECHANISM AND NOT RECALLING THEM FOR SAFETY CONCERN IS NEGLIGENT. IT'S AN OPEN DOOR TO A LAWSUIT IF SOMEONE WERE TO BE MURDERED DUE TO A DOOR THAT DIDN'T LOCK, ALTHOUGH THE DRIVER PUSHED THE LOCK BUTTON AND HEARD THE LOCKING NOISE. REMEMBER, IN THIS CASE THERE'S NO OBVIOUS INDICATION THE DOOR ISN'T LOCKED UNLESS SOMEONE WALKS UP AND OPENS IT FROM THE OUTSIDE. THE DRIVE "THINKS" THE DOOR IS LOCKED, WHEN IN REALITY IT'S AN "OPEN DOOR" FOR CARJACKING OR ROBBERY. THIS FAILURE IS AN INTERMITTENT OF OPERATION. SOMETIMES THE DOORS LOCK OK, OTHER TIMES THEY DON'T. IN ADDITION, SOMETIMES THE DOORS UNLOCK OK, OTHER TIMES THEY DON'T. 3. IN EMERGENCIES IT'S IMPORTANT TO BE ABLE TO UNLOCK DOORS QUICKLY. SINCE 99% OF THE TIME WE ALL USE THE BUTTON TO LOCK AND UNLOCK DOORS, USING THE MANUAL LOCKING LEVER IS UNFAMILIAR. AND THE MURANO'S DESIGN IS SUCH THAT IT'S NOT EASY TO COMPREHEND IF IT'S NOT YOUR CAR, FOR INSTANCE A RENTAL CAR. I CAN EASILY UNDERSTAND HOW SOME PEOPLE WOULD BE CONFUSED HOW UNLOCK A DOOR USING THE MANUAL LEVEL IN AN EMERGENCY WHEN THEY VIRTUALLY HAVE NO EXPERIENCE WITH IT. IN EMERGENCIES EVERY SECOND COUNTS. THE LOCKING/UNLOCKING SOLENOID MALFUNCTIONING IS CLEARLY A HIGH RISK IN EMERGENCY SCENARIOS. SOME PEOPLE WHO CANNOT AFFORD THE $1600 TO HAVE ALL THE SOLENOIDS REPLACED (AS QUOTED BY DEALERS) WILL FORGO GETTING THEM FIXED, PUTTING THEIR FAMILY MEMBERS AT RISK WITH THE ABOVE MISHAP EXAMPLES. THIS SHOULDN'T BE, NISSAN SHOULD RECALL THEM. *TR
NHTSA ODI #10248013
67,128 miles · Oct 26, 2008
Power Train
WHILE DRIVING MY 2004 NISSAN MURANO THE VEHICLE WOULD NOT ACCELERATE IN TRAFFIC AND WAS FORCED TO COAST TO THE SIDE OF THE ROAD AND RESTART THE VEHICLE. MY 8 YEAR OLD SON WAS WITH ME AND THIS COULD HAVE CAUSED AN ACCIDENT AND INJURY. SUPERIOR NISSAN, WHERE I PURCHASED THE CARE LESS THAN 5 MONTHS PRIOR, SAID THAT THE TRANSMISSI…
Read full complaint
WHILE DRIVING MY 2004 NISSAN MURANO THE VEHICLE WOULD NOT ACCELERATE IN TRAFFIC AND WAS FORCED TO COAST TO THE SIDE OF THE ROAD AND RESTART THE VEHICLE. MY 8 YEAR OLD SON WAS WITH ME AND THIS COULD HAVE CAUSED AN ACCIDENT AND INJURY. SUPERIOR NISSAN, WHERE I PURCHASED THE CARE LESS THAN 5 MONTHS PRIOR, SAID THAT THE TRANSMISSION VALVE BODY AND CAM LOBE SENSOR WAS GOING BAD. THE VEHICLE HAS ONLY 67,000 MILES ON IT. THE DEALER REFUSED TO STAND BEHIND THEIR PRODUCT AND QUOTED US A COST OF $2200 TO REPAIR. AFTER READING HUNDREDS OF SIMILAR COMPLAINTS ON THE INTERNET, I FEEL THAT NISSAN SHOULD BE FORCED TO RECALL ALL MURANO MODELS WITH THE CVT TRANSMISSION AND REPAIR THEM. THIS IS A KNOW PROBLEM AND THEY ARE IGNORING THE FACT THEY PUT OUT A DEFECTIVE PRODUCT THAT COULD CAUSE INJURIES OR DEATHS. *TR
NHTSA ODI #10246724
29,000 miles · Oct 23, 2008
Power Train
2004 MURANO SL AWD WITH ONLY 29,000 MILES WHEN THE VEHICLE WAS STARTED THE SERVICE ENGINE SOON LIGHT, SLIP LIGHT, AND VDC LIGHT CAME ON AND STAYED ON. UPON PUSHING THE GAS PEDAL, IT TOOK A COUPLE SECONDS FOR ANY ACCELERATION TO OCCUR. AFTER GETTING ON THE HIGHWAY AND PRESSING THE GAS PEDAL AGAIN, THE ACCELERATION WAS DELAYED …
Read full complaint
2004 MURANO SL AWD WITH ONLY 29,000 MILES WHEN THE VEHICLE WAS STARTED THE SERVICE ENGINE SOON LIGHT, SLIP LIGHT, AND VDC LIGHT CAME ON AND STAYED ON. UPON PUSHING THE GAS PEDAL, IT TOOK A COUPLE SECONDS FOR ANY ACCELERATION TO OCCUR. AFTER GETTING ON THE HIGHWAY AND PRESSING THE GAS PEDAL AGAIN, THE ACCELERATION WAS DELAYED AND WOULD ONLY GO UP TO ABOUT 40 MPH, BUT THE RPMS WERE EXTREMELY HIGH. EVERY TIME I TRY TO TAKE OFF FROM A STOP, IT TAKES AWHILE FOR ANY ACCELERATION TO OCCUR. FEELS LIKE THE TRANSMISSION IS SLIPPING. VEHICLE HAD TO BE TOWED AND I HAD TO PAY FOR IT. NOW I'M BEING TOLD THAT EVEN WITH ONLY 29,000 MILES, IT'S NOT COVERED UNDER WARRANTY. *TR
NHTSA ODI #10246471
45,000 miles · Oct 20, 2008
Visibility
THE VISOR ON MY VEHICLES FALLS DOWN, TOLD SPRING IS DEFECTIVE. NISSAN MURANO 2004. *TR
NHTSA ODI #10246163
Official recalls
4May 19, 2009
NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING.
Consequence & remedy
Consequence: ENGINE MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Feb 13, 2006
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
Consequence & remedy
Consequence: IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jan 10, 2006
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jul 14, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08065 · Driver Seat Anchor Failure
Opened Nov 18, 2008 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Seats
THIS INVESTIGATION CONCERNS STRUCTURAL FAILURE OF THE ANCHOR/BRACKET ON THE LEFT REAR SIDE OF THE DRIVER'S SEAT.THE CONCERN IS THAT SUCH FAILURES MAY ALTER THE DRIVER'S SEATED POSITION SO AS TO REDUCE EFFECTIVENESS OF THE OCCUPANT PROTECTION SYSTEM OR POTENTIALLY COMPROMISE VEHICLE CONTROL.FAILURE OF THE SUBJECT ANCHOR BRACKET RESULTS FROM METAL FATIGUE AND CAUSES REARWARD TILTING OF THE DRIVER'S SEAT.THESE FAILURES USUALLY OCCUR DURING DRIVER INGRESS BUT MAY ALSO OCCUR WHILE THE VEHICLE IS BEING OPERATED.THE SAFETY RELATED CONCERNS DURING ACTUAL VEHICLE USE WERE NOT VALIDATED BY THIS INVESTIGATION.WHILE THE NUMBER OF COMPLAINTS OF THIS PROBLEM IS RELATIVELY HIGH, ONLY THREE VERY MINOR, UNDOCUMENTED INJURIES WERE REPORTED.THE REPORTED INJURIES OCCURRED DURING DRIVER INGRESS, NOT WHILE THE VEHICLE WAS IN MOTION.INVESTIGATION DISCLOSED THAT THE APPARENT RISK OF COMPROMISE TO VEHICLE CONTROL HAS NOT BEEN DEMONSTRATED.INVESTIGATION ALSO DISCLOSED THAT THE APPARENT RISK OF COLLAPSE OF THE DRIVER'S SEAT BACK HAS NOT BEEN DEMONSTRATEDA SAFETY RELATED DEFECT TREND WAS NOT IDENTIFIED AND THIS INVESTIGATION HAS BEEN CLOSED.
PE05050 · Fuel Tank Punctures From Road Debris
Opened Sep 13, 2005 · Closed Jan 31, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
EA05006 · Alternator Failure / Engine Stalling
Opened Mar 25, 2005 · Closed Aug 17, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE04077 · Alternator Failure/ Engine Stalling
Opened Nov 19, 2004 · Closed Mar 25, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Electrical System
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Illustration