NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
93 reportsClear category filterMileage unknown · Jul 2, 2001
Engine And Engine CoolingSeat BeltsVisibility
CONSUMER STATES THE MAIN BOLT SECURING THE LEFT REAR SEATBELT ASSEMBLY TO THE FLOOR BROKE OFF COMPLETELY WHILE ADJUSTING AND PULLING ON THE BELT, UPON EXAMINATION CONSUMER FOUND THE SHEARED SURFACE OF THE BROKEN BOLT TO BE CORRODED RATHER THAN SHINNY, WHICH SUGGESTED TO THE CONSUMER THAT THE BOLT HAD BEEN BROKEN FOR A LONG TIME …
Read full complaint
CONSUMER STATES THE MAIN BOLT SECURING THE LEFT REAR SEATBELT ASSEMBLY TO THE FLOOR BROKE OFF COMPLETELY WHILE ADJUSTING AND PULLING ON THE BELT, UPON EXAMINATION CONSUMER FOUND THE SHEARED SURFACE OF THE BROKEN BOLT TO BE CORRODED RATHER THAN SHINNY, WHICH SUGGESTED TO THE CONSUMER THAT THE BOLT HAD BEEN BROKEN FOR A LONG TIME AND HAD ALMOST CERTAINLY BEEN OVERSTRESSED DURING THE ORIGINAL INSTALLATION, CONSUMER WAS ADVISED BY DEALERSHIP THAT WARRANTY HAD EXPIRED AND THAT HE WOULD BE RESPONSIBLE FOR THE NECESSARY REPAIRS.*JB
NHTSA ODI #561823
Mileage unknown · Jun 13, 2001
Engine And Engine Cooling
RECALL 00 V 367 000/ENGINE COOLING FAN: DEALER (KAIN FAMILY FORD, LONDON, KY; PHONE# 606/864-3555 ) UNABLE TO HONOR MANUFACTURER'S RECALL DUE TO NO PARTS AVAILABLE. PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
NHTSA ODI #890314
Mileage unknown · May 23, 2001
Electrical SystemEngine And Engine Cooling
WHILE TRAVELING AT 30MPH TEMPERATURE GAUGE WENT TO HOT, AND VEHICLE COMPLETELY DIED. REP AT DEALERSHIP HAD VEHICLE TOWED TO DEALER, AND THEY REPORTED THAT WIRES HAD MELTED UNDERHOOD WHICH RESULTED IN WIRING HARNESS NEEDED TO BE REPLACED. *AK RECALL 00V367 DEALING WITH OVERHEATING RELATED TO THE PROBLEM CONSUMER HAD WITH VEHICL…
Read full complaint
WHILE TRAVELING AT 30MPH TEMPERATURE GAUGE WENT TO HOT, AND VEHICLE COMPLETELY DIED. REP AT DEALERSHIP HAD VEHICLE TOWED TO DEALER, AND THEY REPORTED THAT WIRES HAD MELTED UNDERHOOD WHICH RESULTED IN WIRING HARNESS NEEDED TO BE REPLACED. *AK RECALL 00V367 DEALING WITH OVERHEATING RELATED TO THE PROBLEM CONSUMER HAD WITH VEHICLE, HOWEVER DEALER WILL NOT DO ANY RECALL REPAIRS DUE TO MILEAGE OF VEHICLE. *SLC
NHTSA ODI #888972
Mileage unknown · May 21, 2001
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
THE FUEL RAIL BURST WHILE DRIVING CAUSING FUEL TO SPRAY ONTO THE HOT ENGINE RESULTING IN FIRE, DURING REPAIR OF THE FUEL RAIL THE DEALER FOUND THAT THE WATER PUMP SHEARED OFF AND REPLACE THE PUMP AND PUMP DRIVE BELT, THE DEALER ALSO FOUND THAT THERE WAS NO COMPRESSION IN 4 OF CYLINDER, THE TIMING CHAIN FAILED CAUSING VALVE DAMAG…
Read full complaint
THE FUEL RAIL BURST WHILE DRIVING CAUSING FUEL TO SPRAY ONTO THE HOT ENGINE RESULTING IN FIRE, DURING REPAIR OF THE FUEL RAIL THE DEALER FOUND THAT THE WATER PUMP SHEARED OFF AND REPLACE THE PUMP AND PUMP DRIVE BELT, THE DEALER ALSO FOUND THAT THERE WAS NO COMPRESSION IN 4 OF CYLINDER, THE TIMING CHAIN FAILED CAUSING VALVE DAMAGE, THE DEALER SUGGEST THE ENTIRE ENGINE BE REPALCED. NLM
NHTSA ODI #561290
Mileage unknown · May 17, 2001
Engine And Engine Cooling
ENGINE COOLING FAN FAILED, CAUSING OVERHEATING AND STALLING. THERE IS RECALL 00V367000 FOR THIS DEFECT. HOWEVER, THIS VEHICLE IS NOT INCLUDED DUE TO VIN. *AK
NHTSA ODI #888506
Mileage unknown · May 14, 2001
Engine And Engine Cooling
4/11/01 WATER PUMP REPLACED BY DEALER IN MANASSAS,VA. 5/11/01 OVERHEATED AGAIN. NOW TOLD THE IT IS THE RELAY SWITCH IN THE ENGINEE COMPARTMENT.*AK
NHTSA ODI #745313
Mileage unknown · May 4, 2001
Engine And Engine Cooling
WHILE DRIVING ABOUT 25 MPH ENGINE WILL STALL WITHOUT A PRIOR WARNING. HAS TO DRIVE TO SIDE OF ROAD, AND RESTART ENGINE, AND WILL WORK.*AK
NHTSA ODI #887546
Mileage unknown · Apr 23, 2001
Engine And Engine Cooling
CONSUMER TOOK VEHICLE TO DEALERSHIP TO HAVE RECALL 00V367000 REPAIRS DONE FOR ENGINE OVERHEATING. AFTER RECALL WORK WAS PERFORMED, ENGINE STILL WAS RUNNING HOT. DEALERSHIP STATED THAT ANY ADDITIONAL WORK WAS NOT COVERED UNDER WARRANTY. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
NHTSA ODI #886464
Mileage unknown · Apr 16, 2001
Engine And Engine Cooling
WHILE DRIVING 45 MPH AND PASSING ANOTHER VEHICLE, VEHICLE STALLED. TOOK VEHICLE TO DEALER, WHO FOUND THAT PLASTIC TENSION WHEEL ATTACHED TO TIMING BELT BROKE. *AK TENSION WHEEL BROKE IN 4 PLACES, CONSUMER STATES THIS PART WAS MADE OF MOLDERS PLASTIC. *SLC
NHTSA ODI #885958
Mileage unknown · Apr 11, 2001
Engine And Engine Cooling
RECALL 00 V 367 000 REPAIRED ON 09-FEB-2001. CONSUMER STATED THAT AFTER RECALL REPAIRS WERE DONE ENGINE SEIZED UP.*AK
NHTSA ODI #885660
Official recalls
8Nov 6, 2000
VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.
Consequence & remedy
Consequence: OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.
Remedy: DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.
Sep 18, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
Dec 8, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE TRACTION CONTROL OPTION. THE THROTTLE CABLES WERE DAMAGED DURING VEHICLE ASSEMBLY LEADING TO FRAYING OR SEPARATION OF THE THROTTLE CABLE.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE ENGINE FROM RETURNING TO IDLE.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE WITH A REVISED DESIGN THAT IS LESS SUSCEPTIBLE TO BENDING OR KINKING DURING INSTALLATION.
Dec 5, 1995
THE FUEL TANK FILLER PIPE OPENING REINFORCEMENT, CONSTRUCTED FROM TWO SEPARATELY MOLDED PIECES, CAN LEAK AT THE WELD.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK ASSEMBLIES WITH UNITS CONTAINING ONE-PIECE MOLDED REINFORCEMENTS.
Dec 4, 1995
CRACKS HAVE BEEN FOUND IN THE FRONT SAFETY BELT OUTBOARD ANCHOR TABS DUE TO A COMBINATION OF HYDROGEN EMBRITTLEMENT OF THE TAB AND STRESS INTRODUCED DURING ATTACHMENT OF THE ANCHOR TAB TO THE SEAT FRAME. THIS DOES NOT CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: A FRACTURE OR SEPARATION IN THIS AREA WOULD REDUCE THE LOAD THAT THE ANCHOR AND THE FRONT SAFETY BELT ANCHORAGES COULD SUSTAIN, INCREASING THE RISK OF INJURY IN A VEHICLE COLLISOIN.
Remedy: DEALERS WILL INSPECT AND INSTALL AN ANCHOR TAB REINFORCEMENT OR REPLACEMENT OF THE COMPLETE FRONT SEAT BELT ASSEMBLY IF AN ANCHOR TAB IS FOUND TO HAVE FRACTURED.
Jan 24, 1995
THE GLASS TEMPERING PROCESS ON THE RIGHT HAND REAR DOOR WINDOWS WAS NOT CORRECTLY PERFORMED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 205, "GLAZING MATERIALS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE WINDOW BREAKS, THE GLASS FRAGMENTS OF THE REAR WINDOWS EXCEED THE SIZE SPECIFICATIONS OF FMVSS NO. 205.
Remedy: DEALERS WILL REPLACE THE RIGHT REAR DOOR GLASS.
Oct 18, 1994
THE FUEL TANK FILLER PIPE OPENING REINFORCEMENT CAN LEAK AT THE WELD.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, AS APPROPRIATE, REPLACE THE FUEL TANKS.
Sep 29, 1994
A METAL SHIELD ON THE OUTSIDE OF THE PLASTIC FUEL FILLER PIPE CAN DEVELOP A STATIC ELECTRICAL CHARGE DURING REFUELING OF THE VEHICLE.
Consequence & remedy
Consequence: A STATIC CHARGE CAN DISCHARGE AND SERVE AS AN IGNITION SOURCE FOR FUEL VAPORS IN THE AREA OF THE FILLER PIPE, RESULTING IN A FLASH VAPOR IGNITION AND A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, MODIFY THE VEHICLES BY ADDING A GROUND STRAP BETWEEN THE FILLER PIPE SHIELD AND THE BODY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA00005 · Engine Cooling Fan Fires
Opened Feb 23, 2000 · Closed Nov 9, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
PE99052 · Engine Cooling Fan Fires
Opened Aug 18, 1999 · Closed Feb 23, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI OPENED THIS INVESTIGATION ON AUGUST 18, 1999, BASED ON FOUR REPORTS OF FIRE INVOLVING THE ENGINE COOLING FAN.THE REPORTS ALLEGE THE ELECTRONIC COOLING FAN CAUGHT FIRE WITH RESULTANT DAMAGE TO THE FAN AND WIRE HARNESS AND/OR THE HARNESS CONNECTOR.IN ITS PE RESPONSE, FORD PROVIDED INFORMATION RELEVANT TO 46 ADDITIONAL ALLEGED FIRE INCIDENTS AND 47 ALLEGED FAILURES OF THE COOLING FAN INVOLVING THERMAL DAMAGE TO THE FAN.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER STUDY THE ISSUE.
Illustration