Electrical SystemEngine And Engine CoolingPower Train
POWER SEAT FORE/AFT INOP - CAN'T ADJUST. BOTH FRONT HEAD RESTRAINT PLASTIC INNARDS HAVE DISINTEGRATED - WOBBLE AROUND -CAN'T ADJUST. FOUND CRUISE CONTROL INOP AFTER DELIVERY - REPLACED. DRIVERS SEATBELT BUCKLE STOP BUTTON GONE - FALLS TO FLOOR. WATER PUMP IMPELER EXPLODED ON FREEWAY - LEFT STRANDED. BATTERY/CABLE SHORTED &BURNED…
Read full complaint
POWER SEAT FORE/AFT INOP - CAN'T ADJUST. BOTH FRONT HEAD RESTRAINT PLASTIC INNARDS HAVE DISINTEGRATED - WOBBLE AROUND -CAN'T ADJUST. FOUND CRUISE CONTROL INOP AFTER DELIVERY - REPLACED. DRIVERS SEATBELT BUCKLE STOP BUTTON GONE - FALLS TO FLOOR. WATER PUMP IMPELER EXPLODED ON FREEWAY - LEFT STRANDED. BATTERY/CABLE SHORTED &BURNED - CAUSED LOSS OF ENGINE POWER / STEERING UPON SHORT. HAS ALSO AFFECTED PERFORMANCE SINCE INCEDENT- - POOR MILAGE AND SUCH.AUTOMATIC TRANS. SWITCH FAILED ON FREEWAY CAUSED SUDDEN/ERRATIC SLOWING OF VEHICLE IN TRAFFIC AND LOSS OF ACCELERATION ABILITY.
NHTSA ODI #719105
Mileage unknown · Oct 2, 1999
Electrical System
THE CAR HAS COME TO A DEAD STOP SEVERAL TIMES BEFORE. BATTERY WAS REPLACED, ALTERNATOR AND OTHER ITEMS REWIRED. DEALER SAID SIMILAR EVENTS HAVE OCCURED ON FEW OTHER CARS.
NHTSA ODI #712685
Mileage unknown · Sep 20, 1999
Electrical System
THE INSULATION OF THE WIRING HAS DEGRADED, CAUSING THE VEHICLE TO SHORT OUT. DEALER HAS REPAIRED THE VEHICLE, AND THE PROBLEM STILL EXISTS.*AK
NHTSA ODI #848119
Mileage unknown · Sep 19, 1999
Electrical System
DANGEROUS PROBLEM PLASE CONTACT OWNER AS SOON AL POSIBLE, 787-258-4177
NHTSA ODI #711568
Mileage unknown · Sep 2, 1999
Electrical System
VEHICLE IS ACCELERATING SLOWLY. TOOK CAR TO THE DEALER FOR A TUNE UP, AND WAS TOLD EXPOSED WIRING FROM THE TRANSMISSION HARNESS CAUSES THE SLOW ACCELERATION. *AK
NHTSA ODI #846618
Mileage unknown · Jul 1, 1999
Electrical SystemPower Train
AT AROUND 38000 MILES, THE STARTER GEAR SPLIT IN HALF, CAUSING STARTER FAILURE. THE COMPONENT WAS INSPECTED BY BOTH AN INDEPENDENT MECHANIC AND A FORD SERVICE TECHNICIAN, AND BOTH AGREED THAT THE PART FAILED BECAUSE OF A DEFECT. AFTER DRIVING THE VEHICLE ABOUT 2000 MILES, APPARENTLY A PIECE OF THE BROKEN STARTER ENTERED THE TR…
Read full complaint
AT AROUND 38000 MILES, THE STARTER GEAR SPLIT IN HALF, CAUSING STARTER FAILURE. THE COMPONENT WAS INSPECTED BY BOTH AN INDEPENDENT MECHANIC AND A FORD SERVICE TECHNICIAN, AND BOTH AGREED THAT THE PART FAILED BECAUSE OF A DEFECT. AFTER DRIVING THE VEHICLE ABOUT 2000 MILES, APPARENTLY A PIECE OF THE BROKEN STARTER ENTERED THE TRANSMISSION HOUSING AND DESTROYED THE CLUTCH AND RING GEAR, AND PUNCHED A HOLE IN THE TRANSMISSION HOUSING. I BELIEVE THIS TO BE A SAFETY ISSUE BECAUSE THE TECHNICIAN TOLD ME THAT THE PROBLEM WAS SEVERE ENOUGH THAT IT COULD HAVE CAUSED TRANSMISSION OR CLUTCH PARTS TO ACTUALLY BREAK OFF AT ROAD SPEED, POSSIBLY ENTERING THE PASSENGER COMPARTMENT OF THE VEHICLE. *AK
NHTSA ODI #708141
Mileage unknown · Jun 14, 1999
Electrical System
WIRING HARNESS SHORTED OUT. *AK
NHTSA ODI #707541
Mileage unknown · Jun 11, 1999
Electrical SystemEngine And Engine CoolingPower Train
PROBLEM WITH FAN MOTOR LED TO OUR TAKING VEHICLE INTO DEALER. THEIR INSPECTION REVEALED SEVERE DETERIORATION TO WIRING HARNESS INSULATION WHICH SERVICE MANAGER SAID MIGHT LEAD TO A FIRE HAZARD. FORD AREA REP CONTACTED AND OFFERED $1,500 PAYMENT TOWARD $2,500 BILL. THIS ALL TOOK PLACE YESTERDAY, JUNE 10, 1999. I DID NOT AUTH…
Read full complaint
PROBLEM WITH FAN MOTOR LED TO OUR TAKING VEHICLE INTO DEALER. THEIR INSPECTION REVEALED SEVERE DETERIORATION TO WIRING HARNESS INSULATION WHICH SERVICE MANAGER SAID MIGHT LEAD TO A FIRE HAZARD. FORD AREA REP CONTACTED AND OFFERED $1,500 PAYMENT TOWARD $2,500 BILL. THIS ALL TOOK PLACE YESTERDAY, JUNE 10, 1999. I DID NOT AUTHORIZE ANY REPLACEMENT TO BE DONE PENDING FURTHER CONVERSATION WITH FORD AND REQUEST THAT THEY REPLACE DEFECTIVE WIRING HARNESS AT NO CHARGE TO ME. PLEASE ALSO NOTE THAT IN JUNE 1998, I COMPLETED AND FILED ANOTHER VEHICLE OWNER'S QUESTIONANAIRE, THIS TIME HAVING TO DO WITH DEFECTIVE WIRING RELATING TO THE ABS SYSTEM. I RECEIVED NO RESPONSE FROM THAT FROM DOT OR FORD. THIS PROBLEM, HAVING TO DO WITH DEFECTIVE WEATHERPROOF COVERING ON THE 22 PIN ELECTRICAL CONNECTOR THAT CONTROLS ABS AND TRACTION CONTROL CIRCUITS AND CAUSES INADVERTENT BRAKING. I BELIEVE THESE ARE PROBLEMS THAT NEED THE ATTENTION OF YOUR AGENCY BEFORE INJURIES OR FATALATIES TAKE PLACE.
NHTSA ODI #707463
Mileage unknown · Jun 11, 1999
Electrical SystemPower TrainUnknown Or Other
AT THE SPEED OF 55 MPH THE CAR SHUTS DOWN IN THE RAIN OR THE TRANSMISSON SLIPS IN AND OUT OF GEARS. RECENTLY THE CHECK ENGINE LIGHT APPEARED WITH THE AIR CONDITIONER. I BELIEVE ITS AN ONGOING ELECTRICAL ISSUE.
NHTSA ODI #707453
Mileage unknown · May 20, 1999
Electrical System
ELECTRCIAL HARNESS WIRING HAS NO INSTALLATION WHICH COULD RESULT IN A FIRE, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.
Consequence & remedy
Consequence: OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.
Remedy: DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE TRACTION CONTROL OPTION. THE THROTTLE CABLES WERE DAMAGED DURING VEHICLE ASSEMBLY LEADING TO FRAYING OR SEPARATION OF THE THROTTLE CABLE.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE ENGINE FROM RETURNING TO IDLE.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE WITH A REVISED DESIGN THAT IS LESS SUSCEPTIBLE TO BENDING OR KINKING DURING INSTALLATION.
CRACKS HAVE BEEN FOUND IN THE FRONT SAFETY BELT OUTBOARD ANCHOR TABS DUE TO A COMBINATION OF HYDROGEN EMBRITTLEMENT OF THE TAB AND STRESS INTRODUCED DURING ATTACHMENT OF THE ANCHOR TAB TO THE SEAT FRAME. THIS DOES NOT CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: A FRACTURE OR SEPARATION IN THIS AREA WOULD REDUCE THE LOAD THAT THE ANCHOR AND THE FRONT SAFETY BELT ANCHORAGES COULD SUSTAIN, INCREASING THE RISK OF INJURY IN A VEHICLE COLLISOIN.
Remedy: DEALERS WILL INSPECT AND INSTALL AN ANCHOR TAB REINFORCEMENT OR REPLACEMENT OF THE COMPLETE FRONT SEAT BELT ASSEMBLY IF AN ANCHOR TAB IS FOUND TO HAVE FRACTURED.
THE GLASS TEMPERING PROCESS ON THE RIGHT HAND REAR DOOR WINDOWS WAS NOT CORRECTLY PERFORMED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 205, "GLAZING MATERIALS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE WINDOW BREAKS, THE GLASS FRAGMENTS OF THE REAR WINDOWS EXCEED THE SIZE SPECIFICATIONS OF FMVSS NO. 205.
Remedy: DEALERS WILL REPLACE THE RIGHT REAR DOOR GLASS.
A METAL SHIELD ON THE OUTSIDE OF THE PLASTIC FUEL FILLER PIPE CAN DEVELOP A STATIC ELECTRICAL CHARGE DURING REFUELING OF THE VEHICLE.
Consequence & remedy
Consequence: A STATIC CHARGE CAN DISCHARGE AND SERVE AS AN IGNITION SOURCE FOR FUEL VAPORS IN THE AREA OF THE FILLER PIPE, RESULTING IN A FLASH VAPOR IGNITION AND A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, MODIFY THE VEHICLES BY ADDING A GROUND STRAP BETWEEN THE FILLER PIPE SHIELD AND THE BODY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA00005 · Engine Cooling Fan Fires
Opened Feb 23, 2000 · Closed Nov 9, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
PE99052 · Engine Cooling Fan Fires
Opened Aug 18, 1999 · Closed Feb 23, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI OPENED THIS INVESTIGATION ON AUGUST 18, 1999, BASED ON FOUR REPORTS OF FIRE INVOLVING THE ENGINE COOLING FAN.THE REPORTS ALLEGE THE ELECTRONIC COOLING FAN CAUGHT FIRE WITH RESULTANT DAMAGE TO THE FAN AND WIRE HARNESS AND/OR THE HARNESS CONNECTOR.IN ITS PE RESPONSE, FORD PROVIDED INFORMATION RELEVANT TO 46 ADDITIONAL ALLEGED FIRE INCIDENTS AND 47 ALLEGED FAILURES OF THE COOLING FAN INVOLVING THERMAL DAMAGE TO THE FAN.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER STUDY THE ISSUE.
1995 Mercury Mystique Problems, Complaints & Recalls | Skip That Year
Illustration