2017 Mazda CX-5

On April 15th, 2019, Mazda made the public aware of Recall Campaign 3219D which involves a failure of the Front Body Control Module on Mazda 3 vehicles, which renders the front windshield wipers inoperable. That document indicates that the part number of replacement for the faulty module is KDY5-67-5XX. On July 10th, 2023, a Mazda dealership serviced a 2017 Mazda CX-5 as the windshield wipers were not functioning. They determined that the Front Body Control Module was faulty and causing the issue. With the new module, part number BAYS-67-5XX, the issue is resolved. The above part numbers are remarkably similar, especially given the added factor that the Front Body Control Module of this vehicle failed in the exact same way as is described in the recall. Mazda, in their filing of the Part 573 Safety Recall Report for campaign 3219D for the Mazda 3, indicated that there may still be an issue with the wiper motor's "condenser" (sic, capacitor) being undersized. Mazda refused to reimburse for these repairs when detailed and requested in writing.

There is an electrical issue with the infotainment system. It changes settings/programmed setup on its own. It is a known issue that mazda owners call “ghost touch”. This is becoming a safety concern for me as it has toggled for the smart city brake support and blind spot monitoring to toggle to off randomly. Although it is not relied on by myself, it can cause an accident or death if does not engage. Additionally, it has changed my display (driver gages) to the lowest setting which is extremely difficult to see at night. As well as the head unit (infotainment system). When this happened, I could not safely read the speed I was going nor reset the display brightness. Mazda needs to take responsibility of this as all system settings are located in the infotainment system. It has apparently also been a known issue for Mazda dated back to 2013 from researching online. Thank you.

The contact owns a 2017 Mazda CX-5. The contact stated while driving approximately 65 MPH, the vehicle jerked and stalled. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The dealer retrieved DTC code: P0192 with a faulty fuel pump. The contact added fuel, and the vehicle operated as designed. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was approximately 80,000.

I purchased my Mazda CX5 in July of 2017. In August 2018 I was driving on an expressway and the car started balking and cut out completely on the side of the road. The engine light was on. I called roadside assistance which I had purchased at the time I bought the car. They had no one in the area. After sitting at the side of the road with the hood up the car started. I took the car to an Auto Zone. They put the car on their computer and did not find a problem other than the engine light coming on. Since that incident the car has had identical problems in city driving and expressway driving. There is absolutely no warning other than the sudden balking and stalling. Twice I have been driving on the expressway at 75 mph in New Mexico and have had to limp to the breakdown lane with semitrucks going by within a foot of my disabled vehicle. We never let the car go below a quarter of a tank of gas. Mazda had recalls on fuel pumps in 2018 and 19 CX5s. The description of the problems on the recalls are identical to what happens with my car. That doesn't seem to impress Mazda as the dealership dismisses my problem as not being under the companies recall specifications. I checked with the dealership each time I brought the car in and got the pat answer, 'not covered under the recall list". I finally took the car to Crippen Mazda where I purchased the car specifically to check the problem. They had the car for the day, did not find anything and although they said they road tested the car it hadn't gone 1 mile according to their records. $130 charge.The answer, "bring it in when the engine light is on". The engine light does not stay on. I called "Mazda customer service" and was told to take a picture when the car stalled. Take a picture of what? They told me they would send an email which never happened. I wrote a letter to Mazda headquarters and have not gotten a response. I now have a car which has intermittent problems and no help from Mazda.

What component or system failed or malfunctioned, and is it available for inspection upon request? Sudden loss of power (and speed) on interstate highway at ~65 mph. Fuel level was under 1/4 tank level. Weather was clear and approx. 60-70 deg F. Cruise control was on and vehicle working normally for hours on the road trip with cruise control on and functioning properly on the highway. Suddenly, the vehicle lost power, check engine light came on, and vehicle was running very sporadic. P0192 code thrown. Low fuel pressure which resulted in car suddenly going into reduced power mode. Sudden loss of high pressure pump would have resulted in complete loss of propulsion, which did not occur in this case - this indicates low pressure from the in-tank LP fuel pump. How was your safety or the safety of others put at risk? Sudden and unexpected loss of power on the highway which could have resulted in rear end accident or loss of control while trying to get the vehicle off the highway. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes - if fuel tank level gets below 1/4 tank the problem will occur. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No - sudden loss of power and then engine light came on (constant, not flashing) and vehicle had sporadic power issues until we could get off the highway. Certified technician put scanner on car. Code was P0192 - low fuel rail pressure. Filled fuel tank to full, cleared code, and continued to drive car. Issue did not reoccur until fuel level fell below 1/4 level (approx.). 2017 Mazda CX5 is believed to have the same or similar low pressure fuel pump in tank, OEM = Denso, which is on recalled Mazda models from 2018 and newer. I believe older models of Mazda's with the same pumps should also be recalled!

On February 14, 2023 around 3:30 - 4:30 p.m. (EST), I drove to the local WAWA. Upon entering the driveway of WAWA at a very low speed and depressing the brake the car failed to come to a complete stop. I pressed down on the brake as hard as I good, but the car did not come to a stop until hitting the security/safety bollard in front of the WAWA store. I did not get injured and no one else was injured. The front end of my car sustained over $4000 worth of damage. The insurance company repaired by car. I was asked by the insurance company what caused the front end damage. As I played the accident over and over in my head, I just could not see what I did wrong. My foot was on the brake. Also, I entered the entrance of WAWA at a very slow/low speed. After a few weeks I took the car to the Mazda dealer to let them know the car accelerates and engine revs. Also, the car jolts forward while decelerating from about 20mph to 10mph. The car dealer/repair shop could not replicate the problem. Was told to bring the car back in, if problem continues.

While driving on the interstate (continuously for about 4 hours) the vehicle suddenly lost power and the engine stalled. Power steering and power brakes were impacted and the vehicle was difficult to get off the road safely. Once stopped, it would not restart over a 30 minute period. A tow truck was called and it was taken to the dealer. A couple hours later when the dealer checked it, the vehicle started normally and drove without issue. A P0192 code was stored in the ECU so the high pressure fuel pump was replaced even though they could not reproduce the problem. The vehicle has 63000 miles on it now, but a similar sequence happened at 15000 miles. In that situation while driving at a steady speed all power cut out and the engine abruptly downshifted to the point where the tires squealed. After pulling off the road and stopping/starting the vehicle it seemed to drive normally again. We were traveling at the time with no dealer nearby, but when we returned back home we took it to the dealer and they found the same code P0192 and ran various tests and decided to replace the high pressure fuel pump even though it was driving properly. In only 63000 miles this vehicle has twice failed dramatically and without warning in ways that could easily cause an accident or injury. I am lacking in confidence that the root cause has ever been identified.