IllustrationREAR HUB CAP RECALL COULD NOT BE PERFORMED ON THE KIA SEDONA DUE TO LACK OF PARTS.*MR *JB
2004 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
Wheels complaints
32 reportsDT: CONTACT RECEIVED A RECALL LETTER AROUND 6-15-05 CONCERNING ALLOY WHEELS. THE CONSUMER CALLED THE DEALER, AND THEY TOLD HER THE BEST THEY COULD DO WAS PUT HER ON A WAITING LIST. THEY COULD NOT TELL HER A SPECIFIC TIME WHEN SHE MIGHT BE CALLED BACK. THERE WERE MORE THAN 30 PEOPLE AT DEALER WITH SIMILAR PROBLEMS. . SHE CONTA…
Read full complaint
DT: CONTACT RECEIVED A RECALL LETTER AROUND 6-15-05 CONCERNING ALLOY WHEELS. THE CONSUMER CALLED THE DEALER, AND THEY TOLD HER THE BEST THEY COULD DO WAS PUT HER ON A WAITING LIST. THEY COULD NOT TELL HER A SPECIFIC TIME WHEN SHE MIGHT BE CALLED BACK. THERE WERE MORE THAN 30 PEOPLE AT DEALER WITH SIMILAR PROBLEMS. . SHE CONTACTED THE DEALER THE VERY SAME DAY SHE RECEIVED THE LETTER. THE LAST TIME SHE CALLED,(ON JULY 12,05, SHE TOLD THEM TO PUT HER ON THE LIST. THEY DID RECOMMEND ANOTHER KIA DEALER FURTHER AWAY. SHE DID NOT WANT TO GO FURTHER AWAY DUE TO THE SAFETY ISSUE INVOLVED.*AK *JB
DT: CONTACT STATES RECEIVED A RECALL LETTER DATED 6-13 05 FRO KIA. ON 6-28-05 TOOK VEHICLE TO DEALER FOR INSPECTION . THEY SAID THEY WOULD NEED TO ORDER THE PARTS. HE KEPT CALLING EACH WEEK, AND THEY TOLD HIM THEYE WERE STILL WAITING FOR THE PARTS. WHEN THE CONSUMER CALLED THE 800 CUSTOMER SERVICE NUMBER FOR KIA THEY TELL HI…
Read full complaint
DT: CONTACT STATES RECEIVED A RECALL LETTER DATED 6-13 05 FRO KIA. ON 6-28-05 TOOK VEHICLE TO DEALER FOR INSPECTION . THEY SAID THEY WOULD NEED TO ORDER THE PARTS. HE KEPT CALLING EACH WEEK, AND THEY TOLD HIM THEYE WERE STILL WAITING FOR THE PARTS. WHEN THE CONSUMER CALLED THE 800 CUSTOMER SERVICE NUMBER FOR KIA THEY TELL HIM THE PARTS WERE ON BACKORDER FROM KOREA. ON 8-10-05 THEY TOLD HIM TO TAKE VEHICLE BACK TO THE DEALER, HAVE THEM LOOK AT IT, AND IF THEY FEEL THAT VEHICLE WAS UNSAFE THEY WILL GOVE HIM A RENTAL/LOANER CAR TO DRIVE.*AK
DT: THE CONTACT OWNED A 2004 KIA SEDONA. THE CONTACT RECEIVED A RECALL 05V232000 IN JUNE OF 2005. IN AUGUST 2005 NOW AUGUST CONSUMER WAS IS STILL UNABLE TO GET RECALL REPAIRS DONE. CONTACTED THE MANUFACTURER AND DEALERSHIP, AND THEY TOLD HER THAT SHE HAD TO WAIT. CONSUMER DID NOT WANT TO WAIT SINCE THIS WAS A SAFETY DE…
Read full complaint
DT: THE CONTACT OWNED A 2004 KIA SEDONA. THE CONTACT RECEIVED A RECALL 05V232000 IN JUNE OF 2005. IN AUGUST 2005 NOW AUGUST CONSUMER WAS IS STILL UNABLE TO GET RECALL REPAIRS DONE. CONTACTED THE MANUFACTURER AND DEALERSHIP, AND THEY TOLD HER THAT SHE HAD TO WAIT. CONSUMER DID NOT WANT TO WAIT SINCE THIS WAS A SAFETY DEFECT. THE DEALERSHIP WOULD NOT EVEN INSPECT THE VEHICLE, PARTS WERE UNAVAILABLE. *AK
DT: THE CONTACT OWNS A 2004 KIA SEDONA. HE RECEIVED NHTSA RECALL 05V232000 ON JUNE 13, 2005. CONTACT WASU NABLE TO GET THE REPAIR WORK DONE. WHEN CONTACT TOOK VEHICLE TO DEALER TO GET TIRES ROTATED WAS TOLD BY DEALER THAT HUB ASSEMBLY WAS FIXE, BUT THEY DID NOT REPLACE THE RECALL PART. CONTACT COMPLAINED THAT DEALER DID N…
Read full complaint
DT: THE CONTACT OWNS A 2004 KIA SEDONA. HE RECEIVED NHTSA RECALL 05V232000 ON JUNE 13, 2005. CONTACT WASU NABLE TO GET THE REPAIR WORK DONE. WHEN CONTACT TOOK VEHICLE TO DEALER TO GET TIRES ROTATED WAS TOLD BY DEALER THAT HUB ASSEMBLY WAS FIXE, BUT THEY DID NOT REPLACE THE RECALL PART. CONTACT COMPLAINED THAT DEALER DID NOT NOTIFY HIM THAT THEY DID NOT COMPLETE THE RECALL. *AK
DT: RECEIVED RECALL LETTER FROM KIA ON JUNE 13, 2005 FOR THE HUB ASSEMBLEY. CONTACTED THE DEALER, THEY DO NOT HAVE THE PARTS. CONTACTED THE MANUFACTURER THEY WERE SHORT ON PARTS. *AK
DT: THE CONSUMER OWNS A 2004 KIA SEDONA. HE STATED HE RECEIVED A RECALL LETTER ON JUNE 13, 2005 AND SINCE THEN HE HAS BEEN UNABLE TO GET HIS VEHICLE REPAIRED. THE DEALERSHIP KEEPS TELLING HIM THEY DO NOT HAVE THE PARTS AVAILABLE HE DID SPEAK WITH THE MANUFACTURER AND THEY JUST TELL HIM TO GO TO ANOTHER DEALERSHIP TO GET THE REP…
Read full complaint
DT: THE CONSUMER OWNS A 2004 KIA SEDONA. HE STATED HE RECEIVED A RECALL LETTER ON JUNE 13, 2005 AND SINCE THEN HE HAS BEEN UNABLE TO GET HIS VEHICLE REPAIRED. THE DEALERSHIP KEEPS TELLING HIM THEY DO NOT HAVE THE PARTS AVAILABLE HE DID SPEAK WITH THE MANUFACTURER AND THEY JUST TELL HIM TO GO TO ANOTHER DEALERSHIP TO GET THE REPAIR WORK DONE. HE DOES NOT FEEL SAFE DRIVING THIS VEHICLE BECAUSE HE CAN'T GET THIS DONE. THE RECALL WAS ON THE ALLOY WHEELS, MOISTURE COULD ACCUMULATE AROUND THE REAR HUBCAPS.*JB
DT: CALLER HAS RECALL THAT CAN'T GET FIXED BECAUSE DEALER HAS PARTS ON BACK ORDER. RECALL NUMBER IS NOT AVAILABLE. DEALER INSISTS THEY CAN'T FIX THE PROBLEM NOW BECAUSE THEY DON'T HAVE THE PARTS ON HAND. MANUFACTURER ALSO SAID THE PARTS WERE ON BACK ORDER. *AK
DT: THE CALLER RECEIVED A RECALL NOTICE AND CAN'T GET THE WORK DONE. THE CALLER HAD THREE DIFFERENT APPOINTMENTS TO GET IT FIXED, AND ALL THREE TIMES THEY TOLD HER THAT THEY DID NOT HAVE THE PARTS. THE DEALER AND THE MANUFACTURER HAVE TOLD HER THAT THEY COULD NOT GET THE PARTS. *AK AS OF 08/02/05 THE PARTS HAD NOT COME IN. …
Read full complaint
DT: THE CALLER RECEIVED A RECALL NOTICE AND CAN'T GET THE WORK DONE. THE CALLER HAD THREE DIFFERENT APPOINTMENTS TO GET IT FIXED, AND ALL THREE TIMES THEY TOLD HER THAT THEY DID NOT HAVE THE PARTS. THE DEALER AND THE MANUFACTURER HAVE TOLD HER THAT THEY COULD NOT GET THE PARTS. *AK AS OF 08/02/05 THE PARTS HAD NOT COME IN. *SC
I WAS NOTIFIED VIA A LETTERDATED JUNE 13,2005 OF A RECALL TO CORRECT A DEFECT ON MY VEHICLE. (CAMPAIGN ID# 05V232000). I IMMEDIATELY CALLED THE DEALER TO SCHEDULE AN APPOINTMENT FOR THE REPAIRS. DEALER NOTIFIED ME OF AWARENESS OF THE RECALL BUT NO PARTS WERE AVAILABLE AT THAT TIME TO COMPLETE THE REPAIRS. DEALER INDICATED H…
Read full complaint
I WAS NOTIFIED VIA A LETTERDATED JUNE 13,2005 OF A RECALL TO CORRECT A DEFECT ON MY VEHICLE. (CAMPAIGN ID# 05V232000). I IMMEDIATELY CALLED THE DEALER TO SCHEDULE AN APPOINTMENT FOR THE REPAIRS. DEALER NOTIFIED ME OF AWARENESS OF THE RECALL BUT NO PARTS WERE AVAILABLE AT THAT TIME TO COMPLETE THE REPAIRS. DEALER INDICATED HE WOULD CALL ME WHEN THE PARTS WERE AVAILABLE. I WAITED APPROX. FOUR WEEKS THEN CALLED THE DEALER. AGAIN NO PARTS. I THEN CALLED KIA CUSTOMER AFFAIRS DEPT. THEY HAVE NO IDEA WHEN PARTS WILL BE AVAILABLE. THEY SUGGESTED I TAKE THE VEHICLE TO THE DEALER FOR INSPECTION AND IF A DEFECT WAS FOUND THE VEHICLE WOULD BE IMPOUNDED UNTIL PARTS BECAME AVAILABLE. I THINK KIA IS TAKING FAR TO LONG TO CORRECT THIS PROBLEM. THE RECALL WAS TO BEGIN JUNE 5, 2005. OWNERS WERE NOTIFIED VIA LETTER DATED JUNE 13, 2005. AS OF JULY 12, 2005 THEY HAVE NO IDEA WHEN REPAIRS CAN BE MADE. MUST PEOPLE BE KILLED BEFORE ACTION IS TAKEN?
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.