IllustrationMY STEERING IN MY 2004 KIA SEDONA LX IS TENDING TO BIND AND NEARLY LOCK UP AROUND TURNS. THIS PROBLEM COMES AND GOES.
2004 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
Steering complaints
22 reportsMY VAN WONT STEER. IT IS TIGHT AND WONT LET ME GO LEFT OR RIGHT.
WHILE DRIVING IN WET CONDITIONS THE BRAKE AND BATTERY LIGHT WILL COME ON INSTRUMENT PANEL AND THERE IS A LOSS OF POWER OF STEERING. WHEN TAKEN TO KIA DEALERSHIP TO FIX PROBLEM THEY TOLD US IT IS A COMMON COMPLAINT AMONG KIA CARS. THEY CHECKED ALL BELTS, BATTERY AND ALTERNATOR ALL TESTS CAME BACK NORMAL. WHILE DRIVING IT IS DANGE…
Read full complaint
WHILE DRIVING IN WET CONDITIONS THE BRAKE AND BATTERY LIGHT WILL COME ON INSTRUMENT PANEL AND THERE IS A LOSS OF POWER OF STEERING. WHEN TAKEN TO KIA DEALERSHIP TO FIX PROBLEM THEY TOLD US IT IS A COMMON COMPLAINT AMONG KIA CARS. THEY CHECKED ALL BELTS, BATTERY AND ALTERNATOR ALL TESTS CAME BACK NORMAL. WHILE DRIVING IT IS DANGEROUS TO LOSE POWER OF STEERING ESPECIALLY IN WET CONDITIONS. *TR
WHILE MAKING RIGHT AND LEFT TURNS THE STEERING BECOMES VERY TIGHT. THE POWER STEERING FLUID WAS FINE. NO OTHER WARNINGS. THIS MADE ME VERY SCARED TO MAKE TURNS. I DID MY BEST TO AVOID TURNS ONLY IF ABSOLUTELY NECESSARY FOR TWO DAYS. IN MY 32 YEARS OF DRIVING I HAVE NEVER HAD THIS HAPPEN TO ME. WHEN I TOOK IT TO TIRE CHOICE …
Read full complaint
WHILE MAKING RIGHT AND LEFT TURNS THE STEERING BECOMES VERY TIGHT. THE POWER STEERING FLUID WAS FINE. NO OTHER WARNINGS. THIS MADE ME VERY SCARED TO MAKE TURNS. I DID MY BEST TO AVOID TURNS ONLY IF ABSOLUTELY NECESSARY FOR TWO DAYS. IN MY 32 YEARS OF DRIVING I HAVE NEVER HAD THIS HAPPEN TO ME. WHEN I TOOK IT TO TIRE CHOICE AND TOTAL CAR CARE THEY SAID IT WAS MY INTERMEDIATE STEERING SHAFT NEED TO BE REPLACED. I HAD IT REPLACED THAT DAY 9/20/14. *TR
STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE REFERENCE BULLETIN TSB-019 THIS IS RIDICULOUS THAT THERE HASN'T BEEN A RECALL! ARE WE JUST WAITING FOR A WRECK THAT ACTUALLY KILLS SOME ONE? WE WERE TURNING ONTO THE HIGHWAY AND THE STEERING WHEEL LOCKED AND HAD TO BE TURNED BACK TO STRAIGHT OR ELSE IT WOULD HAVE JU…
Read full complaint
STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE REFERENCE BULLETIN TSB-019 THIS IS RIDICULOUS THAT THERE HASN'T BEEN A RECALL! ARE WE JUST WAITING FOR A WRECK THAT ACTUALLY KILLS SOME ONE? WE WERE TURNING ONTO THE HIGHWAY AND THE STEERING WHEEL LOCKED AND HAD TO BE TURNED BACK TO STRAIGHT OR ELSE IT WOULD HAVE JUST KEPT TURNING US INTO ONCOMING TRAFFIC. *TR
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT WAS DRIVING 2 MPH AND ATTEMPTING A RIGHT TURN WHEN THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER AND A PRIVATE MECHANIC. THE MECHANIC ADVISED THAT THE RACK AND PINION FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT WAS DRIVING 2 MPH AND ATTEMPTING A RIGHT TURN WHEN THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER AND A PRIVATE MECHANIC. THE MECHANIC ADVISED THAT THE RACK AND PINION FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 83,325 AND THE CURRENT MILEAGE WAS 85,000.
INCREASED STEERING EFFORT NOTED. RESEARCHED AND FOUND NHTSA ACTION # 10027724, AND FOUND IT WAS OPENED AND CLOSED TWICE. THE ACTION APPEARED TO BE RELATED THE INTERMEDIATE STEERING SHAFT AND ASSOCIATED UNIVERSAL JOINT. LUBRICATING THE INTERMEDIATE SHAFT UNIVERSAL JOINT APPEARED TO SLIGHTLY LESSEN STEERING EFFORT. *TR
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT STATED THAT WHILE ATTEMPTING A LEFT TURN, THE STEERING WHEEL LOCKED MAKING IT DIFFICULT FOR THE CONTACT TO TURN THE WHEEL. THE CONTACT TAPPED ON THE BRAKES AND THEN THE ACCELERATOR IN ORDER FOR THE STEERING WHEEL TO UNLOCK. THE DEALER WAS NOTIFIED OF THE FAILURE BUT THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2004 KIA SEDONA. THE CONTACT STATED THAT WHILE ATTEMPTING A LEFT TURN, THE STEERING WHEEL LOCKED MAKING IT DIFFICULT FOR THE CONTACT TO TURN THE WHEEL. THE CONTACT TAPPED ON THE BRAKES AND THEN THE ACCELERATOR IN ORDER FOR THE STEERING WHEEL TO UNLOCK. THE DEALER WAS NOTIFIED OF THE FAILURE BUT THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 61,000. THE CONSUMER ALSO STATED THE VEHICLE JERKS AND THE POWER STEERING PROBLEM HAS WORSENED SIGNIFICANTLY. UPDATED 07/19/11
THE STEERING IN MY 2004 KIA SEDONA IS MALFUCTIONING. WHEN TURNING THE STEERING WHEEL IT NOW TAKES A GREAT AMOUNT OF EFFORT SOME OF THE TIME. IT COMES AND GOES. AS YOU TURN THE WHEEL IT GOES FROM EASY TO VERY DIFFICULT AND YOU NEVER KNOW WHEN IT WILL HAPPEN. AFTER A TURN YOU MUST TURN THE WHEEL BACK TO GO STRAIGHT OR IT WILL CONT…
Read full complaint
THE STEERING IN MY 2004 KIA SEDONA IS MALFUCTIONING. WHEN TURNING THE STEERING WHEEL IT NOW TAKES A GREAT AMOUNT OF EFFORT SOME OF THE TIME. IT COMES AND GOES. AS YOU TURN THE WHEEL IT GOES FROM EASY TO VERY DIFFICULT AND YOU NEVER KNOW WHEN IT WILL HAPPEN. AFTER A TURN YOU MUST TURN THE WHEEL BACK TO GO STRAIGHT OR IT WILL CONTINUE TO TURN. THESE 2 PROBLEMS ARE VERY DANGEROUS AS I COULD CAUSE AN ACCIDENT JUST BY MAKING A TURN. *TR
STEERING BINDING. WAS TOLD AT THE KIA DEALERSHIP THAT THEY HAVE HAD PROBLEMS WITH STEERING IN SEDONAS NOW I AM PAYING A HIGH PRICE TO GET VEHICLE FIXED. I ASKED WHY ISNT IT ON RECALL LIST THEY SAID THEY DONT HAVE ANYTHING TO DO WITH IT. I AM LEASING A 2004 KIASEDONA. I HAVE HAD PROBLEM WITH TURNING THE STEERING WHEEL TO THE LEFT…
Read full complaint
STEERING BINDING. WAS TOLD AT THE KIA DEALERSHIP THAT THEY HAVE HAD PROBLEMS WITH STEERING IN SEDONAS NOW I AM PAYING A HIGH PRICE TO GET VEHICLE FIXED. I ASKED WHY ISNT IT ON RECALL LIST THEY SAID THEY DONT HAVE ANYTHING TO DO WITH IT. I AM LEASING A 2004 KIASEDONA. I HAVE HAD PROBLEM WITH TURNING THE STEERING WHEEL TO THE LEFT AS FOUND IN OTHER COMPLAINTS AND WAS TOLD THE RACK AND PINION STEERING NEEDED TO BE FIXED. *TR
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.