IllustrationI HAVE A 2004 KIA SENDONA LX VAN AND THE WHEEL BARRINGS ARE BAD I FIXED IT ONCE ALREADY A MONTH AGO AND IT IS ALREADY BROKEN AGAIN BOTH TIMES IT COMPLETELY FELL APART IN TO LITTLE PEICES WHEN I TOOK THE WHEEL OFF.
2004 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
Wheels complaints
32 reportsTHE WHEEL BEARINGS DISINTEGRATED AND CAUSED THE WHOLE HUB TO COME OFF. LUCKILY WE WERE RIGHT AROUND THE CORNER FROM OUR DESTINATION AND WEREN'T GOING VERY FAST. *TR
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A LOUD CRACKING NOISE. A FEW MOMENTS LATER, HE HEARD A LOUD EXPLOSION. THE CONTACT PULLED OVER AND NOTICED THAT THERE WAS A HOLE IN THE REAR PASSENGER SIDE HUB AND THE BEARING WAS MISSING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WH…
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A LOUD CRACKING NOISE. A FEW MOMENTS LATER, HE HEARD A LOUD EXPLOSION. THE CONTACT PULLED OVER AND NOTICED THAT THERE WAS A HOLE IN THE REAR PASSENGER SIDE HUB AND THE BEARING WAS MISSING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 05V232000 (WHEELS). THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 97,000.
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 45 MPH SHE HEARD A ROARING NOISE COMING FROM THE WHEELS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE SHE WAS INFORMED SHE NEEDED NEW WHEEL BEARINGS ON ALL FOUR WHEELS. THE MANUFACTURER WAS NOTIFIED AND SHE WAS INFORMED HER VEHICLE WAS NOT INCLUDED IN …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 45 MPH SHE HEARD A ROARING NOISE COMING FROM THE WHEELS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE SHE WAS INFORMED SHE NEEDED NEW WHEEL BEARINGS ON ALL FOUR WHEELS. THE MANUFACTURER WAS NOTIFIED AND SHE WAS INFORMED HER VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V232000, WHEELS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 90,000.
I HAD THE FRONT WHEEL BEARINGS AND HUBS REPLACED AT 65,000 MILES ON MY 2004 KIA SEDONA UNDER WARRANTY DUE TO PLAY IN THE HUB. LAST MONTH DURING A BRAKE INSPECTION I WAS INFORMED THAT THEY ARE BAD AGAIN THE VEHICLE NOW HAS 106,000 MILES. THIS IS A POTENTIAL HAZARD AS WHEN THEY FAIL COMPLETELY THE WHEEL WILL FALL OFF POTENTIALLY…
Read full complaint
I HAD THE FRONT WHEEL BEARINGS AND HUBS REPLACED AT 65,000 MILES ON MY 2004 KIA SEDONA UNDER WARRANTY DUE TO PLAY IN THE HUB. LAST MONTH DURING A BRAKE INSPECTION I WAS INFORMED THAT THEY ARE BAD AGAIN THE VEHICLE NOW HAS 106,000 MILES. THIS IS A POTENTIAL HAZARD AS WHEN THEY FAIL COMPLETELY THE WHEEL WILL FALL OFF POTENTIALLY CAUSING A SERIOUS ACCIDENT. I BELIEVE THIS TO BE A DESIGN FLAW SINCE THIS ONLY VEHICLE I HAVE OWNED IN 30 YEARS THAT NEEDED BEARINGS REPLACED EVEN ONCE MUCH LESS TWICE IN 100,000 MILES. JUST TO LET YOU KNOW THE REAR BEARING WERE REPLACED TWICE ALREADY UNDER WARRANTY ONE TIME UNDER A RECALL AND ANOTHER TIME AS A RESULT OF ANOTHER BRAKE INSPECTION. *TR
WHILE DRIVING AT 10 MPH ,MY DAUGHTER AND I HEARD A CLUNK IN THE REAR OF OUR 2004 KIA SEDONA LX. I WAS HEADING FOR A REPAIR SHOP AS A RESULT AND HEARD A SECOND CLUNK AND PULLED OFF ON A SIDE STREET AND DROVE 200 FEET WHEN THE WHEEL BEARING ASSEMBLY CAME APART AND THE WHOLE WHEEL FLEW OFF THE VAN. *TR
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING BETWEEN 45-55 MPH, THE CONTACT NOTICED A LOUD ROARING NOISE AND VIBRATION IN THE VEHICLE. SHE PULLED THE VEHICLE OVER AND CALLED THE MECHANIC. THE MECHANIC ADVISED HER TO CHECK THE LUGS TO SEE IF THE WHEELS WERE ON TIGHT. SHE DROVE TO THE NEXT TOWN AND STOPPED AT A REPAIR …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING BETWEEN 45-55 MPH, THE CONTACT NOTICED A LOUD ROARING NOISE AND VIBRATION IN THE VEHICLE. SHE PULLED THE VEHICLE OVER AND CALLED THE MECHANIC. THE MECHANIC ADVISED HER TO CHECK THE LUGS TO SEE IF THE WHEELS WERE ON TIGHT. SHE DROVE TO THE NEXT TOWN AND STOPPED AT A REPAIR SHOP. THE MECHANIC DROVE AROUND THE BLOCK AND STATED THAT THE WHEEL BEARING APPEARED TO BE DEFECTIVE. THE DEALER STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V232000 (WHEELS). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 77,000.
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING 60 MPH, THE CONTACT HEARD A LOUD THUMPING SOUND. AFTER SHE INSPECTED THE VEHICLE, SHE NOTICED THE WHEEL AND TIRE DETACHED. THE VEHICLE WAS TOWED TO THE DEALER HOWEVER; THEY WERE UNABLE TO DIAGNOSE THE FAILURE. AS OF MARCH 25, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING 60 MPH, THE CONTACT HEARD A LOUD THUMPING SOUND. AFTER SHE INSPECTED THE VEHICLE, SHE NOTICED THE WHEEL AND TIRE DETACHED. THE VEHICLE WAS TOWED TO THE DEALER HOWEVER; THEY WERE UNABLE TO DIAGNOSE THE FAILURE. AS OF MARCH 25, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 83,000 AND FAILURE MILEAGE WAS 82,000.
KIA SEDONA REAR OUTER BEARINGS AND/OR HUB ASSEMBLY NEEDING REPLACED. *TS WHEN THE CONSUMER ARRIVED AT THE DEALERSHIP, SHE INFORMED THE REPRESENTATIVE THE LEFT REAR SEAT WOULD NOT COME OUT AND THE AIR BAG LIGHT WAS ON. WHEN THE CONSUMER WENT TO PICK UP THE VAN AND AFTER GOING OVER THE PAPERWORK, SHE NOTICED ONLY THE AIR BAG LIGH…
Read full complaint
KIA SEDONA REAR OUTER BEARINGS AND/OR HUB ASSEMBLY NEEDING REPLACED. *TS WHEN THE CONSUMER ARRIVED AT THE DEALERSHIP, SHE INFORMED THE REPRESENTATIVE THE LEFT REAR SEAT WOULD NOT COME OUT AND THE AIR BAG LIGHT WAS ON. WHEN THE CONSUMER WENT TO PICK UP THE VAN AND AFTER GOING OVER THE PAPERWORK, SHE NOTICED ONLY THE AIR BAG LIGHT WAS FIXED AND EVERYTHING ELSE THE PARTS WERE ON ORDER. AFTER GETTING ANOTHER APPOINTMENT, THE CONSUMER THEN TOLD THE DEALER SHE WAS EXPERIENCING A PULSATION WHEN IN THE BRAKES. THE DEALER TOLD THE CONSUMER THE BRAKES WERE NOT A PART OF THE WARRANTY, HOWEVER THEY WOULD TAKE THE RESPONSIBILITY FOR THE ROTORS, BUT THE CONSUMER WOULD HAVE TO PAY FOR THE BRAKE PADS. THE CONSUMER STATED THE PULSATION PROBLEM HAD NEVER BEEN FIXED. THE CONSUMER WAS TOLD NOW THE REAR BRAKES WERE PULSATING. *JB
WE TOOK OR 2004 SEDONDA EX. TO WESTON PONTIAC FOR A RECALL ON THE THROTTLE CABLE, MY WIFE ALSO SHOWED THEM THE LETTER FOR THE RECALL ON THE ALLOY WHEELS ASKED FOR THEM TO CHECK REAR BEARINGS FOR MOISTURE IN FEAR OF A CRASH. AFTER 3 HRS SHE WAS SENT HOME SAID IT WAS GOOD AND THEY WOULD ORDER PARTS. SOMETHING DIDN'T SEEM RIGHT SO …
Read full complaint
WE TOOK OR 2004 SEDONDA EX. TO WESTON PONTIAC FOR A RECALL ON THE THROTTLE CABLE, MY WIFE ALSO SHOWED THEM THE LETTER FOR THE RECALL ON THE ALLOY WHEELS ASKED FOR THEM TO CHECK REAR BEARINGS FOR MOISTURE IN FEAR OF A CRASH. AFTER 3 HRS SHE WAS SENT HOME SAID IT WAS GOOD AND THEY WOULD ORDER PARTS. SOMETHING DIDN'T SEEM RIGHT SO I HAD HER TAKE IT TO BE CHECKED BY OTHER TECH. HIS FINDINGS WAS MOISTURE AND WAS CORRODED WITH RUST. LATER WHEN I WAS TALKING TO KIA'S CAC THEY GOT WESTON PONTIAC ON THE PHONE THE SHOP SAID THEY NEVER HAD TIME TO CHECK REAR BEARINGS WE WERE LUCKY THAT NO ONE WAS INJURED OR DEATHS WE HAVE GOTTEN A RUN AROUND FROM THEM LIES AND ONLY FIXING 1/2 THE PROBLEM. SAYING OUR PARTS ARE IN AND THEY DID NOT EVEN HAVE THEM JUST THAT KIA HAS CALLED AND WANTED TO GET THEM OFF THEIR BACKS. WE WERE ALSO TOLD TO KEEP CHECKING FOR MOISTURE IN THE BEARINGS AND JUST BRING IT WHEN WE DO. ITS LIKE SAYING DRIVE WITH YOUR EYES CLOSED YOU NEVER KNOW WHEN YOU MAY CRASH, AS THE RECALL SAYS I DON'T LIKE THAT ODDS WITH MY WIFE & GRANDCHILDREN LIVES AT HAND. KIA( KARRIE) IS WHO I SPOKE TO & GAVE ME THIS # K1016279 TO REFER TO MY COMPLAINT SAID WELL YOUR VAN IS FIXED AND NO ONE GOT HURT I DON'T SEE WHAT YOUR PROBLEM IS. THE LIE TO MY WIFE SAYING OR VAN WAS OK WHEN NEVER CHECK AND WAS NOT THE RISK THEY PUT MY LOVED ONES IN WITH NO CONCERN FOR THEIR LIVES AND THAT THEY NEVER FIXED IT THEY PUT A BANDAID ON IT JUST TO GET US AND THIS RECALL OFF THEM. I KNOW THE RECALL WAS NOT ON THE RENTAL BUT IT WAS NOT SAFE TO BE OUT ON THE ROAD THE TIRES WERE BOLD AND WAS OUT OF ALIGNMENT THAT IT PULLED SO HARD TO THE RIGHT. THE ONLY THING THEY COULD SAY WAS NO ONE TOLD US. SO THEY PUT US FROM ONE DANGER RIGHT INTO ANOTHER. PLEASE SOMETHING NEEDS TO BE DONE TO STOP THEM HOW MANY OTHERS HAVE THEY SENT OFF SAYING THEIR VEHICLE IS OK AND NOT. THANK-YOU FOR YOUR TIME AND CONCERN IN THIS MATER ALBERT SMITH . *JB
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.