IllustrationCPSC#I1230221A. 2004 KIA SEDONA. CONSUMER STATED HE WAS HAVING DIFFICULTY IN STARTING THE VEHICLE DUE TO STALLING. THE VEHICLE WILL SHUT OFF WHILE IDLING AND WHILE DRIVING. LOSS OF POWER RESULTS IN DIFFICULTY IN STEERING THE VEHICLE. *LN THE CONSUMER STATED NONE OF THE REPAIRS, HAVE FIXED THE STALLING ISSUE.
2004 Kia Sedona
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Kia Sedona do not stand out strongly from the model-year median of 120.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sedona years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1625–50K
1850–75K
2175–100K
16100–150K
7150K+
129 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports13 fire reports8 injury reports
Engine And Engine Cooling complaints
24 reportsVAN WAS MAKING A HIGH-PITCHED WHINING SOUND. TOOK IT IN AND FOUND THAT THE WATER PUMP NEEDED REPLACEMENT. THEY TESTED IT AND IT WAS STILL NOT RUNNING PROPERLY SO THEY DUG A LITTLE DEEPER AND FOUND THAT THE COILS AND WIRING NEEDED TO BE REPLACED. GOT THE VAN BACK IN WORKING CONDITION AND LESS THAN TWO DAYS LATER, THE CHECK ENGINE…
Read full complaint
VAN WAS MAKING A HIGH-PITCHED WHINING SOUND. TOOK IT IN AND FOUND THAT THE WATER PUMP NEEDED REPLACEMENT. THEY TESTED IT AND IT WAS STILL NOT RUNNING PROPERLY SO THEY DUG A LITTLE DEEPER AND FOUND THAT THE COILS AND WIRING NEEDED TO BE REPLACED. GOT THE VAN BACK IN WORKING CONDITION AND LESS THAN TWO DAYS LATER, THE CHECK ENGINE LIGHT COMES ON. TOOK IT BACK AND THEY SAID IT NEEDED A NEW CATALYTIC CONVERTER. THANKS TO LAWS IN THE STATE OF CALIFORNIA, WE CANNOT REPLACE WITH AN AFTERMARKET ($200); INSTEAD WE WERE QUOTED $1K, AND THAT APPARENTLY IS ON THE CHEAP SIDE. THE GOV.'T HAS A WARRANTY PROGRAM TO REPLACE CATALYTIC CONVERTERS ON VEHICLES 80,000 MILES OR LESS. WE WERE JUST OUT OF THAT LIMIT. TOO BAD FOR US. WE'RE TRADING IT IN. *TR
I OWN A 2004 KIA SEDONA 3.5L THAT I PURCHASED ON 08-31-2010 WITH 53638 MILES ON IT. ON 01-25-2011 AS I WAS DRIVING I HEARD A RATTLING FROM THE ENGINE COMPARTMENT. I STOPPED TO OPEN THE HOOD AND CONFIRM THAT IT WAS COMING FROM THE ENGINE, IT WAS. I DROVE TO THE NEAREST AUTO MECHANIC AND HAD IT DIAGNOSED TO BE TOLD THAT I HAD A…
Read full complaint
I OWN A 2004 KIA SEDONA 3.5L THAT I PURCHASED ON 08-31-2010 WITH 53638 MILES ON IT. ON 01-25-2011 AS I WAS DRIVING I HEARD A RATTLING FROM THE ENGINE COMPARTMENT. I STOPPED TO OPEN THE HOOD AND CONFIRM THAT IT WAS COMING FROM THE ENGINE, IT WAS. I DROVE TO THE NEAREST AUTO MECHANIC AND HAD IT DIAGNOSED TO BE TOLD THAT I HAD A BLOWN ENGINE AND IT WOULD HAVE TO BE REPLACED. I HAD IT TOWED TO HE LOCAL KIA DEALERSHIP TO BE LOOKED AT FURTHER. THE ENGINE WAS OPENED UP TO BE INSPECTED. I WAS TOLD THAT THE #6 CYLINDER WAS COMING APART AND THAT I WOULD HAVE TO REPLACE THE ENGINE. THE VAN CURRENTLY HA ONLY 59430 MILES ON IT. IT IS UNDER THE 60000 MILE WARRANTY MARK BUT OVER THE 5 YEAR PORTION. I HAVE BEEN MADE AWARE THAT THERE WAS A KIA SERVICE BULLETIN THAT MENTIONED THAT THE 2004 KIA SEDONA 3.5L ENGINE HAD SCORING ON THE #6 CYLINDER FROM THE MANUFACTURING PROCESS WHICH ALSO RESULTED IN A GASKET DEFECT OR MALFUNCTION. THIS CLEARLY SHOULD BE COVERED UNDER WARRANTY SERVICE. THIS IS NOT THE ONLY CASE OF THIS SPECIFIC PROBLEM WITH THE #6 CYLINDER. *TR
I HAVE A 2004 KIA SEDONA THE REAR COOLANT LINES HAVE FAILED AND NOW I AM LEAKING COOLANT AND IT WILL COST $1000 TO FIX. IT HAPPENED ALL OF A SUDDEN. NOW I CAN'T DRIVE MY CAR SAFELY. *TR
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING AT SPEEDS OF 70 MPH THE VEHICLE WOULD CONTINUOUSLY MAKE A JERKING MOTION AND STALL WITHOUT WARNING; HOWEVER, THE PROBLEM WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY COULD NOT DUPLICATE THE FAILURES AND RELEASED THE VEHICLE BACK TO THE OWNER. THE …
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING AT SPEEDS OF 70 MPH THE VEHICLE WOULD CONTINUOUSLY MAKE A JERKING MOTION AND STALL WITHOUT WARNING; HOWEVER, THE PROBLEM WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY COULD NOT DUPLICATE THE FAILURES AND RELEASED THE VEHICLE BACK TO THE OWNER. THE VEHICLE CONTINUED TO STALL INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN BACK TO THE DEALER A SECOND TIME AND AGAIN THEY COULD NOT DUPLICATE THE FAILURE. HE THEN TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO ALSO COULD NOT DETERMINE THE CAUSE OF THE FAILURE. ON THE THIRD ATTEMPT, A SPECIALIST AT THE DEALERSHIP STATED THAT THE EMISSIONS SENSOR AND THE THROTTLE VALVE WERE REPLACED; HOWEVER, THE FAILURE PERSISTED. THERE WERE NO ADDITIONAL REPAIRS PERFORMED AND THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000 AND THE CURRENT MILEAGE WAS 98,000.
TL*THE CONTACT OWNS A 2004 KIA SEDONA. IN JUNE OF 2007, WHILE BACKING OUT OF THE DRIVEWAY AT AN UNKNOWN SPEED, THE VEHICLE STALLED. THE FAILURE DATES WERE AUGUST 20, 2007 AT 74,200 MILES AND SEPTEMBER 9, 2007 AT 77,450 MILES. WHEN THE CONTACT APPROACHED A TRAFFIC LIGHT, THE BRAKES WERE DEPRESSED AND THE VEHICLE STALLED ON MAR…
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. IN JUNE OF 2007, WHILE BACKING OUT OF THE DRIVEWAY AT AN UNKNOWN SPEED, THE VEHICLE STALLED. THE FAILURE DATES WERE AUGUST 20, 2007 AT 74,200 MILES AND SEPTEMBER 9, 2007 AT 77,450 MILES. WHEN THE CONTACT APPROACHED A TRAFFIC LIGHT, THE BRAKES WERE DEPRESSED AND THE VEHICLE STALLED ON MARCH 28, 2008. WHILE DRIVING 50 MPH, THE VEHICLE STALLED AGAIN AT 83,000 MILES. THE CONTACT WAS NEAR A NAPA AUTO PARTS STORE AND PULLED INTO THE PARKING LOT. A MECHANIC INSPECTED THE VEHICLE TO IDENTIFY THE CAUSE OF THE FAILURE, BUT WAS UNSUCCESSFUL. THE CONTACT CALLED TWO DIFFERENT KIA DEALERS TO ATTEMPT TO DIAGNOSE THE FAILURE, BUT THEY WERE ALSO UNSUCCESSFUL. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 83,400. UPDATED 04/29/08 *BF
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE STOPPED, THE VEHICLE STALLS. THE VEHICLE CAN BE RESTARTED AFTER THE FAILURE. THE CONTACT HAS NOT TAKEN THE VEHICLE TO A DEALER; HOWEVER, A LOCAL MECHANIC COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. THE VEHICLE HAS STALLED FOUR TIMES. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MI…
Read full complaint
TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE STOPPED, THE VEHICLE STALLS. THE VEHICLE CAN BE RESTARTED AFTER THE FAILURE. THE CONTACT HAS NOT TAKEN THE VEHICLE TO A DEALER; HOWEVER, A LOCAL MECHANIC COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. THE VEHICLE HAS STALLED FOUR TIMES. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 83,000.
I HAVE REPAIR PAPERWORK FROM THE TWO PAST OWNERS. THE KIA SADONA ENGINE DIES FOR NO REASON WHAT SO EVER. THIS HAS BEEN AN ON GOING ISSUE WITH THIS VEHICLE. TODAY, IT ALMOST GOT MY FAMILY KILLED BECAUSE IT STALLED AT AN INTERSECTION THEY WERE CROSSING THROUGH. *TR
THIS VAN HAS BRAKE PROBLEMS SQUEAKING AND WEARING OUT PADS WAY TOO FAST. I WAS TOLD NOTHING IS WRONG WITH THE BRAKE SYSTEM BUT WHEN TAKING IT TO A BRAKE SHOP I WAS TOLD THE CALIPERS ARE BAD, KIA HAS NOT FIXED THEM AND DENIES THAT THEY'RE BAD. THE CHECK ENGINE LIGHT CAME ON AND I WAS TOLD THAT A SPARK PLUG HAD MISFIRED, THAT WA…
Read full complaint
THIS VAN HAS BRAKE PROBLEMS SQUEAKING AND WEARING OUT PADS WAY TOO FAST. I WAS TOLD NOTHING IS WRONG WITH THE BRAKE SYSTEM BUT WHEN TAKING IT TO A BRAKE SHOP I WAS TOLD THE CALIPERS ARE BAD, KIA HAS NOT FIXED THEM AND DENIES THAT THEY'RE BAD. THE CHECK ENGINE LIGHT CAME ON AND I WAS TOLD THAT A SPARK PLUG HAD MISFIRED, THAT WAS FIXED UNDER WARRANTY AND THEN ANOTHER SPARK PLUG MISFIRED AND WAS FIXED UNDER WARRANTY. THE OIL LEVEL WAS GETTING LOW BUT I HAD NO LEAK AND I WAS TOLD THAT THE OIL FILTER WAS SIMPLY LOOSE SO THEY SAID THEY FIXED IT. I ASKED IF I SHOULD BRING THE VAN BACK IN A WEEK TO HAVE THE OIL LEVEL CHECKED AND WE WERE ASSURED THERE WAS NO LEAK. CHECK ENGINE LIGHT CAME ON AGAIN AND THE OIL LIGHT FLICKERED, DID NOT STAY ILLUMINATED, SO WE TOOK IT TO THE DEALERSHIP IMMEDIATELY, AS THE OWNERS MANUAL AND THE MECHANIC HAD STATED. THEN WE'RE TOLD THAT THERE'S SLUDGE IN THE ENGINE AND THAT IT WILL BE 2,000 DOLLARS TO TAKE IT APART AND CHECK THE DAMAGE THAT WE CAUSED FROM CONTINUING TO DRIVE IT. THEY NEVER TOLD US THERE WAS ANY REASON TO NOT DRIVE IT NOR DID THEY MENTION SLUDGE PREVIOUSLY. THE VAN WILL BE TOWED BACK TO KIA TOMORROW. *TR
CAR BUCKING AND SHIFTING PROBLEMS. KIA HAS HAD MANY PROBLEMS WITH THE SEDONA AND FUEL PROBLEMS THAT THEY ARE WELL AWARE OF BUT REFUSE TO DO ANYTHING ABOUT THEM. THE CAR STALLS ON THE FREE WAY IT BUCK VIOLENTLY AND THERE ARE NUMEROUS OWNERS THAT ARE HAVING THE SAME PROBLEMS THAT WE ARE FACING. *JB
Official recalls
205V329000 · Vehicle Speed Control:cables
Jul 20, 2005
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Consequence & remedy
Consequence: THIS CAN CAUSE THE CABLE TO STICK, THUS PREVENTING THE ENGINE FROM RETURNING TO IDLE AND CAUSING THE VEHICLE TO MAINTAIN SPEED OR ACCELERATE. SUCH AN EVENT CAN OCCUR WITHOUT WARNING AND COULD CAUSE A CRASH.
Remedy: DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
05V232000 · Wheels
May 19, 2005
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Consequence & remedy
Consequence: WHEEL BEARING FAILURE MAY OCCUR WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA08017 · Steering Intermediate Shaft Binding
Opened Aug 28, 2008 · Closed Jul 1, 2009
Status: closed (inferred from source dates) · Steering
ODIS ANALYSIS OF WARRANTY DATA SHOWS THAT THE ALLEGED DEFECT HAS OCCURRED AT A RELATIVELY HIGH FREQUENCY IN SALT-BELT STATES (5.9 PERCENT).HOWEVER, THE TESTS CONDUCTED BY ODI AND KIA HAVE SHOWN THAT THE ALLEGED DEFECT HAS A MINIMAL EFFECT ON STEERING EFFORTS.IN ADDITION, ODI INTERVIEWS OF OWNERS WHO EXPERIENCED THE ALLEGED DEFECT SHOWED THAT IN MOST CASES THE PROBLEM WAS PRECEDED BY MONTHS OR YEARS OF NOISE OR A GRADUAL INCREASE IN STEERING EFFORTS AND WAS MORE OF A NUISANCE CONCERN. THERE HAS BEEN ONE ALLEGATION OF A MINOR CRASH RELATED TO THE ALLEGED DEFECT, INVOLVING A MY 2003 KIA SEDONA WITH 59,900 MILES.THE VEHICLE HAD BEEN CHECKED TWICE IN THE PREVIOUS NINE MONTHS BY A DEALER FOR COMPLAINTS OF STIFF STEERING AND THAT THE VEHICLE FELT LIKE IT WAS INTERMITTENTLY LOSING POWER ASSIST.THE CRASH OCCURRED AS THE DRIVER WAS ATTEMPTING TO MAKE A LEFT TURN WHILE TRAVELING AT APPROXIMATELY 20 MILES PER HOUR AND STRUCK A VEHICLE PARKED ON THE RIGHT SIDE OF THE STREET THAT THE VEHICLE WAS TURNING INTO. THE CRASH RESULTED IN MINOR INJURIES TO THE DRIVER. AFTER THE CRASH, IT WAS DETERMINED THAT THE INTERMEDIATE SHAFT WAS EXHIBITING SOME BINDING OF THE STEERING INTERMEDIATE SHAFT BEARINGS.WHILE THE ABSENCE OF ADDITIONAL CRASHES OR INJURIES DOES NOT MEAN THAT THERE IS NOT A SAFETY-RELATED DEFECT, THERE HAVE BEEN NO REPORTED ADDITIONAL CRASHES CAUSED BY THE ALLEGED DEFECT IN THE PAST THREE YEARS. THE RELEASE OF THE TECHNICAL SERVICE BULLETIN SHOULD ASSIST SERVICE PERSONAL IN DIAGNOSING THIS POTENTIAL PROBLEM LONG BEFORE IT BECOMES POTENTIALLY DANGEROUS.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-017 CLOSING REPORT.
PE08033 · Steering Binding
Opened Apr 28, 2008 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Steering
ON APRIL 28, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION PE08-033 TO INVESTIGATE COMPLAINTS ALLEGING STEERING BINDING IN MODEL YEAR 2002 THROUGH 2004 KIA SEDONA MINIVANS.KIA'S RESPONSE TO ODI'S REQUEST FOR INFORMATION IN PE08-033 INDICATED THAT CONCERNS WITH BINDING OF THE STEERING INTERMEDIATE SHAFT WERE FIRST IDENTIFIED AND INVESTIGATED IN AUGUST 2002, IN VEHICLES SOLD IN INDONESIA.THIS INVESTIGATION RESULTED IN THE ADDITION OF A STIFFENING RIB TO THE BEARING CAP SEAL.IN JUNE 2003, KIA AGAIN INVESTIGATED OWNER COMPLAINTS OF STEERING NOISE AND HIGHER THAN NORMAL STEERING RESISTANCE AND IN OCTOBER AND NOVEMBER OF 2003 DESIGN CHANGES TO THE SHAFT UNIVERSAL JOINT BEARINGS WERE MADE TO IMPROVE LUBRICANT RETENTION AND ELIMINATE WATER INTRUSION THAT COULD LEAD TO EARLY BEARING FAILURE.ACCORDING TO KIA, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE CHANGE IN STEERING EFFORT THAT SHOULD BE APPARENT TO THE DRIVER THROUGH NOISE AND GRADUAL CHANGES IN STEERING STIFFNESS LONG BEFORE THE CONDITION COULD BECOME DANGEROUS. ODI'S ANALYSES OF COMPLAINT AND WARRANTY DATA RELATING TO THE ALLEGED DEFECT SHOW THAT THE CONDITION IS OCCURRING AT SIGNIFICANTLY HIGHER RATES IN SALT-BELT STATES (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).THE WARRANTY RATE FOR REPLACEMENT OF THE STEERING INTERMEDIATE SHAFT IS 5.5% FOR VEHICLES SOLD IN THE SALT BELT AND 0.5% FOR THE REST OF THE UNITED STATES.THE COMPLAINT RATE FOR THE ALLEGED DEFECT IS 186.8 PER 100,000 VEHICLES IN THE SALT BELT AND 29.4 PER 1000,000 VEHICLES FOR THE REST OF THE UNITED STATES.THERE IS ONE ALLEGATION OF A CRASH RELATED TO THE ALLEGED DEFECT.A SUBJECT VEHICLE STRUCK TWO PARKED CARS WHILE ATTEMPTING TO MAKE A LEFT TURN, ALLEGEDLY RESULTING IN MINOR INJURIES TO THE DRIVER. ODI HAS UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS (EA08-017) COVERING MY 2002 THROUGH 2004 KIA SEDONA VEHICLES SOLD OR CURRENTLY REGISTERED IN SALT BELT STATES TO ASSESS THE FREQUENCY AND TREND OF THE ALLEGED DEFECT AND ITS EFFECT ON STEERING EFFORT.
PE04067 · Throttle Cable Binding
Opened Sep 24, 2004 · Closed Jan 27, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Additional source detail variants (6)
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:cables
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.
Vehicle Speed Control:linkages
KIA PROVIDED INFORMATION DESCRIBING A WATER ENTRY POINT AT THE RUBBER SEALING BOOT LOCATED AT THE THROTTLE BODY END OF THE THROTTLE CABLE, ADVISING THAT WATER COULD ENTER THE CABLE SHEATH DURING NORMAL VEHICLE OPERATION.IN LOW TEMPERATURES, THE WATER FREEZES AND MAY IMPEDE THE MOVEMENT OF THE THROTTLE CABLE THEREBY PREVENTING AN OPEN THROTTLE FROM RETURNING TO THE CLOSED POSITION.A STUCK THROTTLE COULD INCREASE THE RISK OF A CRASH.TO PREVENT WATER INGRESS, KIA INCREASED THE CRIMPING FORCE OF THE CLAMP INSTALLED ON THE RUBBER BOOT FROM 2 TO 5 KILOGRAMS FORCE.THE ACTION TOOK PLACE IN APRIL 2004 AND OCCURRED IN CONNECTION WITH OTHER CHANGES TO THE THROTTLE CABLE SYSTEM.TO REMEDY THE VEHICLES BUILT BEFORE THIS DATE (ALL OF MY 2002 AND PART OF 2003), KIA WILL CONDUCT A SAFETY RECALL TO REPLACE THE DEFECTIVE CABLE WITH AN IMPROVED COMPONENT.CERTAIN RECALLED VEHICLES WILL ALSO HAVE AN ADDITIONAL CLIP INSTALLED TO ADDRESS A POTENTIAL CABLE DISENGAGEMENT CONCERN.SEE KIA'S JANUARY 17, 2005 PART 573 LETTER FOR NHTSA RECALL 05V013 (KIA RECALL SC-042) FOR FURTHER INFORMATION.NO ACTION IS BEING TAKEN ON VEHICLES BUILT AFTER APRIL 4, 2004.