TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THAT THE DRIVER SIDE DOOR FAILED AND COULD NOT BE OPENED AUTOMATICALLY OR MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHICH LOCATED THE FAILURE AT THE DOOR ACTUATOR. THE MANUFACTURER WAS CONTACTED BUT DENIED ASSISTANCE WITH THE REPAIR BECAUSE THE WA…
Read full complaint
TL* THE CONTACT OWNS A 2003 KIA RIO. THE CONTACT STATED THAT THE DRIVER SIDE DOOR FAILED AND COULD NOT BE OPENED AUTOMATICALLY OR MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHICH LOCATED THE FAILURE AT THE DOOR ACTUATOR. THE MANUFACTURER WAS CONTACTED BUT DENIED ASSISTANCE WITH THE REPAIR BECAUSE THE WARRANTY WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 35,000.
NHTSA ODI #10432621
74,800 miles · Sep 13, 2007
Structure
TL*THE CONTACT OWNS A 2003 KIA RIO. AFTER PARKING THE VEHICLE, THE PASSENGER SIDE DOOR FAILED TO OPEN AND THE CONTACT WAS TRAPPED INSIDE. THE DOOR WAS ABLE TO BE OPENED FROM THE OUTSIDE. THE DEALER STATED THAT THE FAILURE WAS UNRECOGNIZABLE. A FEW DAYS LATER, THE DRIVER SIDE DOOR FAILED AS WELL. NO REPAIRS WERE MADE ON THE …
Read full complaint
TL*THE CONTACT OWNS A 2003 KIA RIO. AFTER PARKING THE VEHICLE, THE PASSENGER SIDE DOOR FAILED TO OPEN AND THE CONTACT WAS TRAPPED INSIDE. THE DOOR WAS ABLE TO BE OPENED FROM THE OUTSIDE. THE DEALER STATED THAT THE FAILURE WAS UNRECOGNIZABLE. A FEW DAYS LATER, THE DRIVER SIDE DOOR FAILED AS WELL. NO REPAIRS WERE MADE ON THE DOORS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 74,800.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT ASSEMBLIES MAY DISENGAGE.
Consequence & remedy
Consequence: IF A CHILD SEAT IS NOT PROPERLY SECURED, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH REAR OUTBOARD SEATBELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2006. OWNERS MAY CONTACT HYUNDAI-KIA AT 1-800-333-4542.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02009 · Air Bag Non Deploy
Opened Jul 2, 2002 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags
THIS INVESTIGATION IDENTIFIED A TOTAL OF 82 REPORTS ALLEGING NON-DEPLOYMENT OF THE DUAL FRONT AIR BAGS.OF THE 82 REPORTS, ONLY ONE INCIDENT, THE FATAL CRASH THAT WAS THE BASIS FOR OPENING THE INVESTIGATION, HAS BEEN IDENTIFIED AS A MODERATE TO SEVERE CRASH IN WHICH THE AUTOMOTIVE RESTRAINT CONTROLLER ISSUED A COMMAND TO DEPLOY BUT THE AIR BAGS DID NOT DEPLOY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED SUMMARY REPORT
2003 Kia Rio Problems, Complaints & Recalls | Skip That Year
Illustration