IllustrationWHEN TURNING THE STEERING WHEEL AT AN UNDETERMINED SPEED STEERING WHEEL MADE A KNOCKING NOISE. CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION AND MECHANIC DETERMINED THAT STEERING COLUMN BOLT SNAPPED. *AK
2003 Kia Rio
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Kia Rio do not stand out strongly from the model-year median of 38.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rio years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
525–50K
950–75K
775–100K
4100–150K
1150K+
49 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports2 fire reports4 injury reports
Steering complaints
4 reportsI PURCHASED A 2003 KIA RIO IN MAY OF 2003 AND IN A MONTH I HAD HARD PULLING TO THE RIGHT EVERY TIME I WENT LEFT TOOK IN TO DEALER AND THEY ROTATED THE TIRES AND SAID THAT THIS HAPPENS ON THE TRIP OVER. WE LEFT AND IT WAS STILL PULLING A LITTLE, WITH IN A WEEK IT WAS THE SAME. VERY HARD TO HANDLE THIS PULL TO THE RIGHT WHEN GOING…
Read full complaint
I PURCHASED A 2003 KIA RIO IN MAY OF 2003 AND IN A MONTH I HAD HARD PULLING TO THE RIGHT EVERY TIME I WENT LEFT TOOK IN TO DEALER AND THEY ROTATED THE TIRES AND SAID THAT THIS HAPPENS ON THE TRIP OVER. WE LEFT AND IT WAS STILL PULLING A LITTLE, WITH IN A WEEK IT WAS THE SAME. VERY HARD TO HANDLE THIS PULL TO THE RIGHT WHEN GOING LEFT,AND I HAVE HAD BAD GAS MILEAGE AND HARD STARTS FROM THE BEGINNING,AND HAVE HAD MY HEADLINER REPLACED AFTER A FEW MONTHS OF OWNING THIS CAR . IT GOES BACK IN TOMORROW HOPE THEY FIX THE PROBLEMS, *CB
MY NEW 2003 KIA RIO WAGON WAS LEAKING POWER STEERING FLUID FROM DAY ONE, AND THE DEALER TRIED TO FIX IT,ITS STILL NOT FIXED BUT NOW EVERY TIME I TURN THE STEERING WHEEL THE ENGINE REV UP. *AK I CAN ACTUALLY FEEL THE CAR ACCELERATE. ITS MORE NOTICEABLE WHEN SLOWLY PULLING OUT OF PARKING SPOTS. I AM GOING TO TRY ANOTHER DE…
Read full complaint
MY NEW 2003 KIA RIO WAGON WAS LEAKING POWER STEERING FLUID FROM DAY ONE, AND THE DEALER TRIED TO FIX IT,ITS STILL NOT FIXED BUT NOW EVERY TIME I TURN THE STEERING WHEEL THE ENGINE REV UP. *AK I CAN ACTUALLY FEEL THE CAR ACCELERATE. ITS MORE NOTICEABLE WHEN SLOWLY PULLING OUT OF PARKING SPOTS. I AM GOING TO TRY ANOTHER DEALER, BUT IS THERE AN ISSUE WITH THESE CARS AND THEIR STEARING, REPORTED AND HAVE THER BEEN ANY RECALLS ?? PLEASE LET ME KNOW
I PURCHASED MY VEHICLE IN JANUARY 2003, FIRST PROBLEM WAS THAT WHILE DRIVING WITH MY 4 MONTH OLD DAUGHTER THE STEERING WHHEL WENT OUT ON ME. I TRIED TO TURN THE CAR WHILE GETTING ON THE EXPRESSWAY AND THE STEERING WHEEL KEPT SPINNING BUT I DID NOT TURN AND ALMOST HIT A CEMENT VIDUCT. NEXT ABOUT 1 MONTH LATER MY CAR BEGAN TO NO…
Read full complaint
I PURCHASED MY VEHICLE IN JANUARY 2003, FIRST PROBLEM WAS THAT WHILE DRIVING WITH MY 4 MONTH OLD DAUGHTER THE STEERING WHHEL WENT OUT ON ME. I TRIED TO TURN THE CAR WHILE GETTING ON THE EXPRESSWAY AND THE STEERING WHEEL KEPT SPINNING BUT I DID NOT TURN AND ALMOST HIT A CEMENT VIDUCT. NEXT ABOUT 1 MONTH LATER MY CAR BEGAN TO NOT START OR CUT OFF ON ME WHEN I WOULD FIRST START DRIVING AND THE CHIME WILLNOT GO OFF. THE DEALER TOLD ME THAT THEY HAVE BEEN HAVING THIS PROBLEM WITH THEM AND HE WILL CONTACT ME WHEN THE MANUFACTURER TELLS THEM HOW TO FIX THE PROBLEM.
Official recalls
306V294000 · Seat Belts:rear/other
Aug 4, 2006
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." WHEN USED WITH CERTAIN CHILD SEATS, THE AUTOMATIC LOCKING RETRACTOR (ALR) FUNCTION IN THE REAR OUTBOARD SEATBELT ASSEMBLIES MAY DISENGAGE.
Consequence & remedy
Consequence: IF A CHILD SEAT IS NOT PROPERLY SECURED, THERE IS AN INCREASED RISK OF INJURY TO THE SEAT OCCUPANT IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH REAR OUTBOARD SEATBELT ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 15, 2006. OWNERS MAY CONTACT HYUNDAI-KIA AT 1-800-333-4542.
05V557000 · Child Seat
Dec 12, 2005
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
04V179000 · Fuel System, Gasoline:delivery
Apr 9, 2004
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02009 · Air Bag Non Deploy
Opened Jul 2, 2002 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags
THIS INVESTIGATION IDENTIFIED A TOTAL OF 82 REPORTS ALLEGING NON-DEPLOYMENT OF THE DUAL FRONT AIR BAGS.OF THE 82 REPORTS, ONLY ONE INCIDENT, THE FATAL CRASH THAT WAS THE BASIS FOR OPENING THE INVESTIGATION, HAS BEEN IDENTIFIED AS A MODERATE TO SEVERE CRASH IN WHICH THE AUTOMOTIVE RESTRAINT CONTROLLER ISSUED A COMMAND TO DEPLOY BUT THE AIR BAGS DID NOT DEPLOY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED SUMMARY REPORT