Electrical SystemEngine And Engine CoolingParking Brake
DT: THE CONSUMER PURCHASED TWO 2002 KIA RIOS, THE FIRST VEHICLE WAS FINE. THE OTHER VEHICLE WITHIN 30 DAYS OF PURCHASE AT APPROXIMATELY 100 MILES, DIED. THIS DID NOT HAPPEN AT ANY CERTAIN SPEED. THE VEHICLE HAS BEEN TAKEN INTO THE DEALERSHIP OVER 14 TIMES AND THEY HAVE NOT REPLACED ANYTHING . THEY HAVE REPROGRAMMED THE COM…
Read full complaint
DT: THE CONSUMER PURCHASED TWO 2002 KIA RIOS, THE FIRST VEHICLE WAS FINE. THE OTHER VEHICLE WITHIN 30 DAYS OF PURCHASE AT APPROXIMATELY 100 MILES, DIED. THIS DID NOT HAPPEN AT ANY CERTAIN SPEED. THE VEHICLE HAS BEEN TAKEN INTO THE DEALERSHIP OVER 14 TIMES AND THEY HAVE NOT REPLACED ANYTHING . THEY HAVE REPROGRAMMED THE COMPUTER NUMEROUS TIMES. THE VEHICLE WILL WORK FOR AWHILE, NO SPECIFIC TIME, AND THEN DIE AGAIN. CONSUMER'S DAUGHTER ACTUALLY DROVE VEHICLE WHICH WAS LOCATED IN SOUTH CAROLINA.*AK THE VISOR WAS REPLACED. THE INTERIOR LIGHT WOULD NOT GO OFF, THE DEALER STATED IT WAS A PINCHED WIRE. THE LIFTGATE LATCH WAS REPLACED AND THE PARKING BRAKE WAS ADJUSTED. *JB
ON CERTAIN PASSENGER VEHICLES, THE FUEL INTAKE NIPPLE OF THE FUEL DISTRIBUTOR IS SUBJECT TO FRACTURE OR CRACKING DURING REMOVAL OF THE QUICK CONNECT COUPLING SECURING THE MAIN FUEL TUBE ASSEMBLY TO THE FUEL INTAKE NIPPLE, OR WHEN FORCE IS ACCIDENTALLY APPLIED TO THE INTAKE NIPPLE DURING THE VEHICLE ASSEMBLY PROCESS OR DURING ENGINE COMPARTMENT REPAIRS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL DISTRIBUTOR AND MAIN FUEL TUBE ASSEMBLIES. THE RECALL BEGAN JUNE 18, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA02009 · Air Bag Non Deploy
Opened Jul 2, 2002 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags
THIS INVESTIGATION IDENTIFIED A TOTAL OF 82 REPORTS ALLEGING NON-DEPLOYMENT OF THE DUAL FRONT AIR BAGS.OF THE 82 REPORTS, ONLY ONE INCIDENT, THE FATAL CRASH THAT WAS THE BASIS FOR OPENING THE INVESTIGATION, HAS BEEN IDENTIFIED AS A MODERATE TO SEVERE CRASH IN WHICH THE AUTOMOTIVE RESTRAINT CONTROLLER ISSUED A COMMAND TO DEPLOY BUT THE AIR BAGS DID NOT DEPLOY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED SUMMARY REPORT
2002 Kia Rio Problems, Complaints & Recalls | Skip That Year
Illustration