Engine. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports5 fire reports2 injury reports

Seats complaints

1 reports

Clear category filter

Mileage unknown · Jan 11, 2023

SeatsInjury

Read full complaint

On Friday, December 9, 2022, the heating element in the driver side seat burned through the cushion, burned a hole in my coat, and burned my right leg. Yes, it is available for inspection upon request. Thursday, January 5, 2023, the service department at Kia confirmed the heated seat element had gotten too hot and burned through the seat. Service personnel said the part that needed to be replaced was not under warranty and quoted prices ranging from $600-$1,700 to have it repaired. Other than the service department at Lithia Kia of Anchorage, no other inspection has been done. There were no warning lights or messages prior to the failure. In fact the car had been in the shop the week prior and had a courtesy vehicle inspection.

NHTSA ODI #11501264

Official recalls

23V534000 · Power Train:automatic Transmission:internal:clutches/bands:actuators/solenoids

Jul 31, 2023

Kia America, Inc. (Kia) is recalling certain 2017-2022 Niro and 2018-2022 Niro Plug-in Hybrid vehicles. Fluid may leak into the printed circuit board inside the hydraulic clutch actuator, which can result in an engine compartment fire.

Consequence & remedy

Consequence: A fire increases the risk of injury.

Remedy: Dealers will inspect and replace the hydraulic clutch actuator as necessary and install a new fuse, free of charge. Owner notification letters were mailed December 29, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC276.

22V836000 · Hybrid Propulsion System

Nov 11, 2022

Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles previously recalled under recall 18V-666. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance, which can overheat the rear seats.

Consequence & remedy

Consequence: Overheated rear seats increase the risk of a fire.

Remedy: Dealers will inspect the PRA and replace either the PRA or the Main Relay, as necessary, free of charge. Owner notification letters were mailed January 9, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC256. This recall supersedes NHTSA recall number 18V-666. Vehicles already repaired under the previous recall will need to have the new remedy completed.

18V666000 · Hybrid Propulsion System

Sep 25, 2018

Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance.

Consequence & remedy

Consequence: The increased electrical resistance can overheat the rear seat which is above the PRA, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will inspect the Power Relay Assembly (PRA) for damage. If no damage is found, the main relay will be replaced. If damage is found, the PRA will be replaced. These repairs will be performed free of charge. The recall began November 23, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC168.

18V257000 · Hybrid Propulsion System

Apr 20, 2018

Kia Motors America (Kia) is recalling certain 2017 Kia Niro vehicles. The Hydraulic Clutch Actuator (HCA) inner oil seal may leak, allowing oil to accumulate in the cap area, possibly resulting in an electrical short.

Consequence & remedy

Consequence: An electrical short can increase the risk of a fire.

Remedy: Kia will notify owners, and dealers will inspect the HCA caps for leaked oil and replace the HCA assembly if needed, or replace the HCA cap with additional sealant. These repairs will be performed free of charge. The recall is expected to begin June 15, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC163.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.