Structure. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Structure complaints

3 reports

Clear category filter

Mileage unknown · Oct 15, 2013

StructureTires

Read full complaint

TIRES ARE APPROXIMATELY 1.5 YEARS OF AGE BASED ON "0111" DOT CODE AND HAVE APPROXIMATELY 2000 MILES OF USE (NO SIGNS OF DRY ROT OR OTHER FAILURE PRIOR TO TREAD SEPARATION 1ST INCIDENT MAY 24TH 2013 WHILE TRAVELING APPROXIMATELY 60 MPH ON A FARM TO MARKET ROAD I HAD A POWERKING TOWMAX ST235/80R16 TIRES BLOWOUT AND TREAD SEPARATION. REPLACED TIRE AND RETURNED HOME (~150 MILES) CONTACTED DYNAMIC TIRE CORPORATION AND AFTER SHIPPING THEM THE TIRE THEY FOUND NO APPARENT DEFECT TO THE TIRE AND PAID FOR THE REPLACEMENT TIRE AND THE REPAIRS TO MY TRAILER. (~$2000 IN DAMAGES) HOWEVER DID NOT PAY TO REPLACE THE OTHER 3 REMAINING TIRES. 2ND INCIDENT AUGUST 14TH 2013 UPON PICKING UP THE UNIT AFTER REPAIRS WERE MADE, I DROVE APPROXIMATELY 9 MILES FROM THE DEALERSHIP AND HAD A SECOND BLOWOUT ON THE POWERKING TOWMAX TIRES AGAIN APPROX SPEED 60 MPH... THIS TIRE HAD THE SAME DOT CODE OF 0111 RESULTING IN ANOTHER $2000 IN DAMAGE. SHIPPED THE FAILED TIRE PLUS THE OTHER 2 UN-FAILED TIRES TO DYNAMIC TIRE IN BRAMPTON ON, CANADA ... THEY ARE NOW TELLING ME THIS IS CAUSED BY POSSIBLE UNDER INFLATION, SO ONE TIRE OF THE 4 HAS NO SIGNS OF WHY IT SHOULD FAIL. ... YET ~159 MILES LATER THE OTHER FAILED TIRE PLUS THE REMAINING 2 UN-FAILED TIRES "EXHIBIT SIGNS OF UNEVEN TREAD WEAR AND OVER DEFLECTION" TIRES WERE CONSISTENTLY MAINTAINED AT 80PSI SO UNDER-INFLATION WAS NOT THE CASE. AND THESE ARE THE OE TIRES FROM KEYSTONE ... SO THEY SHOULD BE RATED FOR THAT TRAILERS WEIGHT. *TR

NHTSA ODI #10547975

Mileage unknown · Oct 22, 2012

Structure

Read full complaint

2011 COUGAR 26 SAB. CONSUMER WRITES IN REGARDS TO REAR BUMPER FAILURE AND RECALL THAT WAS ISSUED. RECALL # 12V355000. *TGW THE CONSUMER STATED A PASSERBY INFORMED HIM, THAT HIS REAR BUMPER WAS ABOUT TO FALL OUT. THE CONSUMER STATED THE METAL WAS EXTREMELY THIN, AND HE WANTED THE BUMPER REPLACED WITH A HEAVY DUTY BUMPER. THE DEALER INFORMED THE CONSUMER, THE BUMPER WOULD HAVE TOE BE REPLACED WITH THE SAME BUMPER AS BEFORE. THE CONSUMER THEN WENT TO A WELDING SHOP AND HAD SOME BRACES PUT ON. THE WELDING SHOP, INFORMED THE CONSUMER IT MAY BREAK AGAIN, DUE TO THE THIN METAL.

NHTSA ODI #10481801

11,250 miles · Feb 8, 2012

Structure

THE 2011 KEYSTONE COUGAR XLITE 26SAB BUMPER IS SEPARATING FROM THE RV FRAME ALONG THE WELD JOINTS ON BOTH SIDES OF THE RV CREATING THE POTENTIAL FOR THE BUMPER, SPARE TIRE CARRIER, AND SPARE TIRE TO SEPARATE ENTIRELY THE FRAME. THE BUMPER IS USED ONLY FOR THE SPARE TIRE AND IT'S MOUNTING BRACKET. UPDATED 06/27/12 *BF RECEIVED…

Read full complaint

NHTSA ODI #10447628

Official recalls

17V755000 · Equipment

Nov 22, 2017

Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.

12V355000 · Equipment; Structure:body:bumpers; Tires:temporary/emergency Spare Tire

Jul 26, 2012

Keystone RV Company (Keystone) is recalling certain model year 2010-2012 Cougar 26SAB and 29RES recreational vehicles manufactured from October 5, 2009, through October 24, 2011. The rear bumper, which holds the spare tire assembly, may experience metal fatigue causing the spare tire to separate from the vehicle.

Consequence & remedy

Consequence: Over time, the bumper may fail and/or separate from the vehicle, increasing the risk of personal injury and property damage.

Remedy: Keystone will notify owners, and dealers will install a reinforcement kit free of charge. The safety recall began on September 28, 2012. Owners may contact Keystone at 1-866-425-4369.

Additional source detail variants (3)

Equipment

Consequence: Over time, the bumper may fail and/or separate from the vehicle, increasing the risk of personal injury and property damage.

Remedy: Keystone will notify owners, and dealers will install a reinforcement kit free of charge. The safety recall began on September 28, 2012. Owners may contact Keystone at 1-866-425-4369.

Tires:temporary/emergency Spare Tire

Consequence: Over time, the bumper may fail and/or separate from the vehicle, increasing the risk of personal injury and property damage.

Remedy: Keystone will notify owners, and dealers will install a reinforcement kit free of charge. The safety recall began on September 28, 2012. Owners may contact Keystone at 1-866-425-4369.

Structure:body:bumpers

Consequence: Over time, the bumper may fail and/or separate from the vehicle, increasing the risk of personal injury and property damage.

Remedy: Keystone will notify owners, and dealers will install a reinforcement kit free of charge. The safety recall began on September 28, 2012. Owners may contact Keystone at 1-866-425-4369.

11V094000 · Power Train:axle Assembly

Feb 10, 2011

KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 COUGAR AND LAREDO TRAVEL TRAILERS. THE AXLES ARE INSTALLED BACKWARDS CAUSING A SLIGHT REDUCTION IN BRAKING TORQUE AND SHORTENED BRAKE LINING SERVICE LIFE.

Consequence & remedy

Consequence: OVER TIME DIMINISHED BRAKING CAPACITY COULD LEAD TO AN INCREASED RISK OF PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT THE AXLES TO VERIFY THE BRAKE WIRES ARE ON THE OFF-DOOR SIDE. IF THEY ARE NOT, THE AXLES WILL BE REMOVED AND REVERSED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.

11V002000 · Trailer Hitches

Jan 4, 2011

KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2010-2011 COUGAR, LAREDO AND OUTBACK TRAVEL TRAILERS EQUIPPED WITH LIPPERT COMPONENT HITCH COUPLERS FOR LACK OF INDENTATION ON THE FORWARD EDGE OF THE COUPLER.

Consequence & remedy

Consequence: IF THE COUPLER IS LACKING THE INDENT IT WILL LEAD TO AN INCREASED RISK OF TRAILER SEPARATION FROM THE HITCH BALL WHILE TOWING RESULTING IN PROPERTY DAMAGE AND/OR VEHICLE CRASH.

Remedy: OWNERS ARE ASKED TO INSPECT THE HITCH COUPLER FOR THE CORRECT STAMPING. IF THE HITCH COUPLER IS NOT FORMED CORRECTLY ARRANGEMENTS WILL BE MADE TO REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 24, 2011. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.

10V606000 · Electrical System:wiring:fuses And Circuit Breakers

Dec 1, 2010

KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 SPRINTER, COUGAR AND FUZION TRAVEL TRAILERS EQUIPPED WITH SIEMENS AND MURRAY ONE INCH PLUG-IN CIRCUIT BREAKERS. THE "SPRING CLIP" PLUG-IN ASSEMBLY MAY BREAK OR FAIL TO PROVIDE SUFFICIENT FORCE TO MAINTAIN A PROPER ELECTRICAL CONNECTION IN THE PANEL BOARD.

Consequence & remedy

Consequence: THIS COULD LEAD TO EXCESSIVE TEMPERATURE, ARCING OR THERMAL DAMAGE AT THE CONNECTION POINT AND POTENTIAL DAMAGE TO THE PANEL BOARD'S ELECTRICAL INSULATION WHICH COULD LEAD TO FIRE, PROPERTY DAMAGE, OR PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT THE BREAKERS AND REPLACE AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.

10V597000 · Wheels

Nov 23, 2010

KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 TRAVEL TRAILERS EQUIPPED WITH 15" X 6" WHITE SPOKE OR MODULAR DESIGN STEEL WHEELS WITH A SIX HOLE BOLT PATTERN. SOME OF THE WHEELS MAY HAVE INADEQUATE WELD PENETRATION BETWEEN THE OUTER RING AND THE CENTER PLATE DUE TO IMPROPER PLATE ALIGNMENT.

Consequence & remedy

Consequence: THERE COULD BE A POTENTIAL WHEEL FAILURE AND WHEEL LOSS INCREASING THE RISK OF A CRASH, OR PERSONAL INJURY.

Remedy: KEYSTONE WILL REPLACE THE WHEELS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2010. OWNERS MAY CONTACT KEYSTONE AT 1-866-425-4369.

10V478000 · Equipment

Oct 5, 2010

KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 RECREATIONAL VEHICLES EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Consequence & remedy

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy: DEALERS WILL ISOLATE AND PERFORM A DROP PRESSURE TEST ON THE OVEN SUPPLY TUBE AND IF THE TUBE LEAKS IT WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2010. OWNER MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.