I am submitting this complaint to report what I believe to be a manufacturing or design defect involving the sunroof of my Jeep Grand Cherokee. On or around December 1, 2025, I discovered a severe water leak originating from the sunroof area during normal rainfall. Water entered the vehicle interior without warning and caused s…
Read full complaint
I am submitting this complaint to report what I believe to be a manufacturing or design defect involving the sunroof of my Jeep Grand Cherokee. On or around December 1, 2025, I discovered a severe water leak originating from the sunroof area during normal rainfall. Water entered the vehicle interior without warning and caused substantial damage to the headliner, interior trim, and other interior components. The amount of water intrusion was significant and far beyond what would be expected from normal wear. The vehicle has only around 45,000 miles and is regularly maintained. The leak occurred without any visible damage to the sunroof glass and without prior indication of a problem. The sunroof was fully closed at the time. This suggests a defect related to the sunroof sealing system, drainage system, or overall design rather than misuse or external damage. This defect presents a serious safety concern. Water intrusion inside the vehicle creates the risk of: Electrical system damage or failure, Mold and health hazards, Impaired visibility due to water dripping near the windshield, Distraction to the driver while operating the vehicle. In heavy rain conditions, this defect could reasonably occur while driving, creating a dangerous situation for the driver and passengers. As a result of this defect, my vehicle sustained significant interior damage, requiring repairs. I believe this issue reflects a broader defect in the sunroof design or drainage system rather than an isolated incident. I am concerned that other Jeep Grand Cherokee owners may be experiencing similar failures. I am requesting that NHTSA investigate this issue for potential safety-related defects involving sunroof leakage in Jeep Grand Cherokee vehicles. The severity of the water intrusion and resulting damage indicates a defect that could pose a risk to vehicle safety and occupant well-being.
NHTSA ODI #11705108
58,900 miles · Sep 24, 2024
Structure
The contact owns a 2022 Jeep Grand Cherokee. The contact stated that while driving at approximately 55 - 70 MPH, there was a message that the driver’s side front headlight sensor had failed. The vehicle was taken to a body shop where the contact was informed that the driver’s and passenger’s side bumper bracket clips had slightl…
Read full complaint
The contact owns a 2022 Jeep Grand Cherokee. The contact stated that while driving at approximately 55 - 70 MPH, there was a message that the driver’s side front headlight sensor had failed. The vehicle was taken to a body shop where the contact was informed that the driver’s and passenger’s side bumper bracket clips had slightly detached and was protruding outwardly at high speeds. The contact was able to push the clips and bumpers inwardly; however, the bumper and the clips failed to remain secured. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The manufacturer was informed of the failure. The failure mileage was 58,900.
NHTSA ODI #11616200
Mileage unknown · Apr 22, 2024
Structure
Glass sunroof panel shattered while driving on empty highway at 60 MPH. No explainable cause, e.g. no driving range nearby. The sunroof was rarely opened and was closed during the incident. There was no prior indication of failure. Noise resembled a LOUD bang. Shade prevented glass from raining down onto occupants. The…
Read full complaint
Glass sunroof panel shattered while driving on empty highway at 60 MPH. No explainable cause, e.g. no driving range nearby. The sunroof was rarely opened and was closed during the incident. There was no prior indication of failure. Noise resembled a LOUD bang. Shade prevented glass from raining down onto occupants. The noise was sudden and startled driver. Since road was empty, the incident did not cause the driver to loose control. No car behind, when chunks of glass blew off. After driving 15 miles, examination showed about 1/3 of the glass was missing. The much of the remaining glass was removed to reduce occupant risk. Shattered glass was vacuumed and can be examined but not as a pane. Next car will be driven to dealer. And possibly to insurance agent.
NHTSA ODI #11584402
Mileage unknown · Feb 7, 2024
Structure
While driving going about 40mph, I pressed cruise control to 75. Once my car picked up speed, no other cars around, no overpass, etc. my moon roof exploded out of no where. My 8 month old was in the backseat right under where it busted.
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Grand Cherokee L, 2022-2023 Jeep Grand Cherokee, and Jeep Grand Cherokee 4XE vehicles. The rear coil springs may be incorrectly installed and detach from the vehicle while driving.
Consequence & remedy
Consequence: Rear coil springs that detach from the vehicle while driving increase the risk of a crash.
Remedy: Dealers will replace the rear coil spring lower isolators, free of charge. Interim notification letters, notifying owners of the safety risk, are expected to be mailed September 29, 2026. Additional letters will be sent once the final remedy is available. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 89D. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on September 9, 2026. This recall replaces NHTSA recall numbers 26V051 and 23V413. Vehicles already repaired under the previous recalls will need to have the new remedy completed.
Chrysler (FCA US, LLC) is recalling certain 2022-2024 Jeep Grand Cherokee, 2023 Jeep Wagoneer, 2024 Jeep Grand Cherokee L, and Jeep Wagoneer L vehicles. A software error may cause the transmission gear selection indicator not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission shift lever sequence, starter interlock, and transmission braking effect."
Consequence & remedy
Consequence: A missing gear selection indicator may lead to unintended vehicle movement or a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the shifter module software, free of charge. Owner notification letters were mailed August 20, 2026. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 30D. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 9, 2026.
Chrysler (FCA US, LLC) is recalling certain 2022-2026 Jeep Grand Cherokee and 2023-2025 Jeep Grand Cherokee L vehicles. A software error in the occupant restraint controller module may cause the delayed deployment of the side air bags during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: Delayed air bag deployment during a crash increases the risk of injury.
Remedy: Dealers will update the occupant restraint controller module software, free of charge. Some owner notification letters are expected to be mailed June 18, 2026. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 01D. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on May 28, 2026.
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Grand Cherokee L and 2022-2023 Jeep Grand Cherokee vehicles. The rear coil springs may be incorrectly installed and detach from the vehicle while driving.
Consequence & remedy
Consequence: Rear coil springs that detach from the vehicle while driving increase the risk of a crash.
Remedy: Dealers will inspect and repair the rear coil spring assembly, as necessary, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed February 12, 2026. Additional letters will be sent once the final remedy is available, anticipated in March 2026. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 20D. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 30, 2026. This recall replaces NHTSA recall number 23V413. Vehicles already repaired under the previous recall will need to have the new remedy completed.
Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.
Chrysler (FCA US, LLC) is recalling certain 2022-2026 Jeep Grand Cherokee Plug-In Hybrid Electric (PHEV) vehicles. A software error within the hybrid control processor may result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the hybrid control processer software, free of charge. Owner notification letters were mailed October 14, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 73C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 11, 2025.
Chrysler (FCA US, LLC) is recalling certain 2022 Jeep Grand Cherokee and 2021-2022 Jeep Grand Cherokee L vehicles. The center stack upper display (DCSD) contains a transistor that may overheat and prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display reduces the driver's visibility, increasing the risk of a crash.
Remedy: Dealers replaced the DCSD, free of charge. All affected vehicles have been repaired. Owner notification letters were mailed February 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 11C.
Chrysler (FCA US, LLC) is recalling certain 2022 Jeep Grand Cherokee and 2021-2022 Jeep Grand Cherokee L vehicles. The center stack upper display (DCSD) contains a transistor that may overheat and prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A rearview image that does not display reduces the driver's visibility, increasing the risk of a crash.
Remedy: Dealers replaced the DCSD, free of charge. All affected vehicles have been repaired. Owner notification letters were mailed February 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 11C.
Back Over Prevention:display Function
Chrysler (FCA US, LLC) is recalling certain 2022 Jeep Grand Cherokee and 2021-2022 Jeep Grand Cherokee L vehicles. The center stack upper display (DCSD) contains a transistor that may overheat and prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A rearview image that does not display reduces the driver's visibility, increasing the risk of a crash.
Remedy: Dealers replaced the DCSD, free of charge. All affected vehicles have been repaired. Owner notification letters were mailed February 27, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 11C.
Chrysler (FCA US, LLC) is recalling certain 2022-2024 Jeep Grand Cherokee and 2021-2024 Jeep Grand Cherokee L vehicles. An improperly secured connector for the front seat side air bags (SAB) may prevent the air bags from deploying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: An air bag that does not deploy during a crash increases the risk of injury.
Remedy: Dealers secured the connector, free of charge. All affected vehicles have been remedied. Owner notification letters were mailed December 17, 2024. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is B3B.
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Grand Cherokee and 2023-2024 Jeep Grand Cherokee L vehicles. An improperly connected coaxial cable may prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of injury or crash.
Remedy: Dealers will secure the coaxial cable connection, free of charge. All affected vehicles have been remedied. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 40B.
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Grand Cherokee L and 2022-2023 Jeep Grand Cherokee vehicles. The upper control arm ball joint and steering knuckle may separate and cause the wheel to fall outward, resulting in a loss of vehicle control.
Consequence & remedy
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will replace the upper control arm pinch bolts, free of charge. Owner notification letters were mailed April 2, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA's number for this recall is 10B.
Additional source detail variants (2)
Suspension:front:control Arm:upper Ball Joint
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Grand Cherokee L and 2022-2023 Jeep Grand Cherokee vehicles. The upper control arm ball joint and steering knuckle may separate and cause the wheel to fall outward, resulting in a loss of vehicle control.
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will replace the upper control arm pinch bolts, free of charge. Owner notification letters were mailed April 2, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA's number for this recall is 10B.
Steering:linkages:knuckle:spindle:arm
Chrysler (FCA US, LLC) is recalling certain 2021-2023 Jeep Grand Cherokee L and 2022-2023 Jeep Grand Cherokee vehicles. The upper control arm ball joint and steering knuckle may separate and cause the wheel to fall outward, resulting in a loss of vehicle control.
Consequence: A loss of vehicle control increases the risk of a crash.
Remedy: Dealers will replace the upper control arm pinch bolts, free of charge. Owner notification letters were mailed April 2, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA's number for this recall is 10B.
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Jeep Wrangler and 2022-2024 Jeep Grand Cherokee vehicles. A hybrid control processor (HCP) software error may cause the defrosting and defogging system to be inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the HCP software, free of charge. Owner notification letters were mailed February 29, 2024. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is 04B.
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Jeep Grand Cherokee, 2021-2023 Jeep Grand Cherokee L, and 2022-2024 Jeep Wagoneer and Grand Wagoneer vehicles. The Central Vision Park Assist module (CVPAM) software may prevent the rearview image from displaying when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display while in reverse decreases the driver's visibility of the rear view, increasing the risk of injury or crash.
Remedy: Dealers will update the Central Vision Park Assist Module software, free of charge. Owner notification letters were mailed August 31, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 56A.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ25005 · Recall 23V-413 Post Remedy Failures
Opened Dec 11, 2025 · No close date supplied
Status: open (inferred from source dates) · Suspension:rear:springs:coil Springs
On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly installed rear coil spring may detach while the vehicle is in motion, creating a road hazard that can increase the risk of a crash for following motorists and may result in injury to other road users. Since the filing of Recall 23V-413, the National Highway Traffic Safety Administration (NHTSA) has received twenty (20) unique consumer complaints alleging rear coil spring detachments occurring after the recall remedy was performed. These reports raise concerns regarding the effectiveness of the recall remedy and suggest the possibility of additional factors not addressed by the original recall campaign. Accordingly, the Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to assess the adequacy of FCA’s remedy procedure under Recall 23V-413 and to evaluate the root cause(s) of post-remedy coil spring detachments. ODI will review complaint data, field reports, and FCA’s technical analysis to determine whether further action is warranted. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, visit NHTSA.gov.
Additional source detail variants (2)
Suspension:rear:springs:coil Springs
On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly installed rear coil spring may detach while the vehicle is in motion, creating a road hazard that can increase the risk of a crash for following motorists and may result in injury to other road users. Since the filing of Recall 23V-413, the National Highway Traffic Safety Administration (NHTSA) has received twenty (20) unique consumer complaints alleging rear coil spring detachments occurring after the recall remedy was performed. These reports raise concerns regarding the effectiveness of the recall remedy and suggest the possibility of additional factors not addressed by the original recall campaign. Accordingly, the Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to assess the adequacy of FCA’s remedy procedure under Recall 23V-413 and to evaluate the root cause(s) of post-remedy coil spring detachments. ODI will review complaint data, field reports, and FCA’s technical analysis to determine whether further action is warranted. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, visit NHTSA.gov.
Suspension:rear:springs:coil Springs
On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly installed rear coil spring may detach while the vehicle is in motion, creating a road hazard that can increase the risk of a crash for following motorists and may result in injury to other road users. Since the filing of Recall 23V-413, the National Highway Traffic Safety Administration (NHTSA) has received twenty (20) unique consumer complaints alleging rear coil spring detachments occurring after the recall remedy was performed. These reports raise concerns regarding the effectiveness of the recall remedy and suggest the possibility of additional factors not addressed by the original recall campaign. Accordingly, the Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to assess the adequacy of FCA’s remedy procedure under Recall 23V-413 and to evaluate the root cause(s) of post-remedy coil spring detachments. ODI will review complaint data, field reports, and FCA’s technical analysis to determine whether further action is warranted. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, visit NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration