-The right knuckle sheared upon wheel impact with a curb at approximately 35 mph. At the time the vehicle was pushed northward by 46mph gust as the driver attempted a left hand turn onto a westbound lane from a northbound road. The part is still attached to the vehicle which is currently at the collision repair center. -Failu…
Read full complaint
-The right knuckle sheared upon wheel impact with a curb at approximately 35 mph. At the time the vehicle was pushed northward by 46mph gust as the driver attempted a left hand turn onto a westbound lane from a northbound road. The part is still attached to the vehicle which is currently at the collision repair center. -Failure of the part left the driver stranded and the vehicle unmovable making it a traffic hazard. -Both the tow truck driver and the policeman who called him looked at the part and expressed they had never seen that failure before. No technical inspection of the component has taken place. A retired mechanical engineer who used to perform tests at Eaton Corporation looked at the pictures and the details of the accident and indicated that the part should have survived such an impact. -No symptoms were noticed prior to this failure.
Hyundai Motor America (Hyundai) is recalling certain 2024-2025 Kona Electric and 2024-2026 Kona vehicles. The seat belt buckle in the rear center seat may fail to properly restrain an occupant during a crash.
Consequence & remedy
Consequence: A seat belt buckle that fails to properly restrain an occupant in a crash increases the risk of injury.
Remedy: Passengers are advised not to use the rear center seat until the recall remedy is performed. Dealers will replace the seat belt buckle assembly, free of charge. Owner notification letters were mailed September 2, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 306. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 15, 2026.
Hyundai Motor America (Hyundai) is recalling certain 2024 Elantra, Venue, and Kona vehicles. An electrical short circuit may occur in the exhaust gas recirculation (EGR) valve assembly, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the exhaust gas recirculation valve assembly, free of charge. Owner notification letters were mailed June 28, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 260.
Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The 12-Volt battery cables may chafe against the engine control module bracket and short circuit during a crash.
Consequence & remedy
Consequence: A short circuit increases the risk of an engine compartment fire.
Remedy: Dealers will install sheathing over the wiring, free of charge. Owner notification letters were mailed February 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 252.
Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The seat belt assemblies in the right and left rear seats may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupation Crash Protection" and 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: A seat belt that does not function properly may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the seat belt retractor as necessary, free of charge. Owner notification letters were mailed November 21, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 250.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2024 Hyundai Kona Problems, Complaints & Recalls | Skip That Year
Illustration