NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
38 reportsClear category filterMileage unknown · Sep 16, 2026
Electrical SystemEngineUnknown Or Other
Engine idle stop function failed to restart automatically while i was stopped at a stop light. I was at a complete stop at a four way intersection with vehicles behind me and my vehicle did not restart after light turned green and i released brake and stepped on accelerator. error message flashed stating to press brake and push …
Read full complaint
Engine idle stop function failed to restart automatically while i was stopped at a stop light. I was at a complete stop at a four way intersection with vehicles behind me and my vehicle did not restart after light turned green and i released brake and stepped on accelerator. error message flashed stating to press brake and push start button. Vehicles behine me honked for me to proceed but i could not move. i turned on my hazards and attempted to restart engine. i stepped on brake and pushed start button. Vehicle did not start, i repeated stepping on brake and start button again and did not start. I did it a third time and vehcile started. A police car behind me pulled up and asked if i was ok just as i started my vehicle and pulled away. This is the second time this has happended but i did not report it and thought it was me not stepping on the brake hard enough. the first time was about six months ago in a similiar situation at a four way traffic light.
NHTSA ODI #11764707
80,000 miles · Aug 27, 2026
Engine
The contact owns a 2020 Honda Ridgeline. The contact stated that while driving at an undisclosed speed, an abnormal knocking sound was heard, and smoke emerged from under the hood. No warning lights illuminated, and the engine failed. The vehicle was towed to a dealer, but was not inspected. The vehicle was then towed to another…
Read full complaint
The contact owns a 2020 Honda Ridgeline. The contact stated that while driving at an undisclosed speed, an abnormal knocking sound was heard, and smoke emerged from under the hood. No warning lights illuminated, and the engine failed. The vehicle was towed to a dealer, but was not inspected. The vehicle was then towed to another dealer, where it was diagnosed with a failed engine. The dealer informed the contact that a piston went through the engine and advised that the engine needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The dealer offered to replace the engine with a salvaged engine and cover the repair under warranty; however, the contact declined the repair and requested a new engine, which was denied. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 80,000.
NHTSA ODI #11759933
Mileage unknown · Aug 4, 2026
Electrical SystemEngine
The vehicle's Auto-Idle Stop (AIS) feature is defective and creates a severe safety hazard. While stopped at a busy road intersection, the feature engaged and shut the engine off normally. However, when releasing the brake pedal to proceed, the engine glitched and completely failed to restart, leaving the vehicle completely stal…
Read full complaint
The vehicle's Auto-Idle Stop (AIS) feature is defective and creates a severe safety hazard. While stopped at a busy road intersection, the feature engaged and shut the engine off normally. However, when releasing the brake pedal to proceed, the engine glitched and completely failed to restart, leaving the vehicle completely stalled, unpowered, and stranded in live traffic. The vehicle became a sitting duck in the intersection. This is a recurring issue that requires a complete ignition power cycle to recover, posing an immediate risk of a rear-end or side-impact collision. It happens most often under heavy load. Hot day with AC on, or Cold day with Heater on and seat warmers. Dealer ignored or failed to re-create at first because it was intermittent. I've been through SOFTWARE UPDATE, STARTER, RELAY REPLACEMENT AND VALVE ADJUSTMENTS (twice) and a new BATTERY over several years and it still stalls. It's dangerous and terrifying to be immobilized in traffic when it won't start.
NHTSA ODI #11754865
118,000 miles · Jul 23, 2026
Engine
The contact owns a 2020 Honda Ridgeline. The contact stated that while driving 65 MPH, there was a misfire coming from the engine with the check engine warning light illuminated. The contact pulled over to the side of the road and, upon inspection, the contact determined that one of the ignition coils had failed. The contact pur…
Read full complaint
The contact owns a 2020 Honda Ridgeline. The contact stated that while driving 65 MPH, there was a misfire coming from the engine with the check engine warning light illuminated. The contact pulled over to the side of the road and, upon inspection, the contact determined that one of the ignition coils had failed. The contact purchased a new ignition coil, replaced the part, and resumed driving; however, the vehicle made an abnormal rattling sound while driving. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the engine had failed due to a loosened connecting rod and needed to be replaced. The contact ordered a new engine. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was approximately 118,000.
NHTSA ODI #11752401
Mileage unknown · Apr 11, 2026
Electrical SystemEnginePower Train
While stopped in heavy traffic at a traffic signal, the engine stopped and would not restart. This was due to the AIS system. The car became disabled in heavy traffic. I was only a few feet from the entrance to a gas station, however due to the interlock system that locks the transmission in Park, the truck could not be pushed o…
Read full complaint
While stopped in heavy traffic at a traffic signal, the engine stopped and would not restart. This was due to the AIS system. The car became disabled in heavy traffic. I was only a few feet from the entrance to a gas station, however due to the interlock system that locks the transmission in Park, the truck could not be pushed out of traffic. Honda, unlike other manufacturers the use the same transmission, does NOT supply an emergency over ride to get the transmission out of park ( hazard). After a few minutes of sitting in heavy traffic and nearly. wing hit by fast moving cars, the engine did restart. This is not the first time this has happened. The dealership is over 100 miles drive to have to checked (r/t).
NHTSA ODI #11730561
Mileage unknown · Feb 7, 2026
Engine
Connecting rod/bearing failure.
NHTSA ODI #11716446
Mileage unknown · Feb 6, 2026
EngineUnknown Or Other
After parking on the roadside with engine off for about 10 minutes, the truck would not start. I tried to start twice; the dash lights came on, I could hear the starter try to engage, felt a slight forward lurch from the vehicle, then nothing. The starter seemed to disengage' the dash lights stayed on, and the electric system w…
Read full complaint
After parking on the roadside with engine off for about 10 minutes, the truck would not start. I tried to start twice; the dash lights came on, I could hear the starter try to engage, felt a slight forward lurch from the vehicle, then nothing. The starter seemed to disengage' the dash lights stayed on, and the electric system went into ACC mode. I tried twice with same result. I attempted to put the shift selector in neutral, but it stayed in Park. I was seated in truck, seat belt on, foot pressing on brake pedal. After waiting a few minutes, it cranked and started normally. No further issues the rest of the day. The weather was mild, sunny, temperatures in the mid-60’s fahrenheit.
NHTSA ODI #11716114
Mileage unknown · Jan 18, 2026
Engine
Stranded in traffic unable to start almost got rearend because the start-stop died and to cycle to park to get it started. This has happen on more than one time.
NHTSA ODI #11711752
Mileage unknown · Dec 5, 2025
Engine
Spun Rod Bearing at 70,000 miles. Truck will need a new Short Block. Truck has been at the dealer for all recommended service and oil changes.
NHTSA ODI #11703371
140,000 miles · Oct 31, 2025
Engine
The contact owns a 2020 Honda Ridgeline. The contact stated that while the vehicle was parked or while driving, there was a loud knocking sound coming from the engine compartment. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that three rod bearings and that cylinders #3, #…
Read full complaint
The contact owns a 2020 Honda Ridgeline. The contact stated that while the vehicle was parked or while driving, there was a loud knocking sound coming from the engine compartment. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that three rod bearings and that cylinders #3, #5, and #6 had failed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 140,000.
NHTSA ODI #11696828
Official recalls
8Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
May 9, 2024
Honda (America Honda Motor Co) is recalling certain 2020-2024 Ridgeline vehicles. The rearview camera (RVC) tailgate wire harness may fatigue and break, which can prevent the rearview camera image from displaying.
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will replace the RVC tailgate wire harness, free of charge. Owner letters were mailed November 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's number for this recall is YI7.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 29, 2023
Honda (American Honda Motor Co.) is recalling certain 2020-2021 Civic, 2020-2023 Ridgeline, 2021-2023 Passport, 2021-2022 Pilot, and 2020 Acura MDX vehicles. The tie rod fastener that connects the brake booster and the brake master cylinder may have been improperly assembled during manufacturing, which can cause the brake master cylinder to separate from the booster assembly.
Consequence & remedy
Consequence: Brake master cylinder separation can cause a loss of brake function and increase the risk of a crash.
Remedy: Dealers will inspect and repair the brake booster assembly as necessary, free of charge. Owner notification letters were mailed August 7, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are VEU, AEV, and ZET.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Nov 29, 2021
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence & remedy
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Structure:body:hood
Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.
Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.
Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24004 · Rear-View Camera Failure
Opened Feb 13, 2024 · Closed Aug 5, 2024
Status: closed (inferred from source dates) · Back Over Prevention
On February 13, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24004 to assess alleged failures of the rear-view camera (RVC) in 2020-2023 Model Year (MY) Honda Ridgeline vehicles. At this time, ODI has received a total of 50 complaints with allegations of the RVC image failing to display when the vehicle was in reverse. The RVC wire harness is routed near the hinge in the tailgate, in a location where frequent opening and closing of the tailgate causes bending stress on the harness. Honda determined the wire harness was manufactured with a material which is permeable to water and salt, which when it freezes and thaws, combined with tailgate usage, ultimately leads to breakage of the wiring in the tailgate harness. This results in a failure to display the RVC image. On May 9, 2024, Honda filed a Part 573 Safety Recall Report recalling all 2020-2024 MY Honda Ridgeline vehicles. The dealer will replace the RVC tailgate harness with a wire harness that is manufactured by a new supplier and has improved material properties to withstand wear from bending. In view of Honda filing recall 24V-321 addressing the subject of this investigation, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration