← New search

2018 Honda HR-V

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2018 Honda HR-V do not stand out strongly from the model-year median of 97.

About this comparison →

How this year compares

Owner complaints by model year

Other model years Selected year
Compare all HR-V years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

All reported categories

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

49 reports with mileage · 107 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports0 fire reports5 injury reports

Structure complaints

11 reports
Clear category filter
Mileage unknown · Aug 30, 2026
Structure

The white paint on this vehicle is peeling off. It may come off in a large amount driving down the highway which could cause a safety issue for any vehicle nearby. Honda is aware of this defective paint and should be made to repaint this vehicle no matter when the grace period ranout.

NHTSA ODI #11760743

Mileage unknown · Aug 17, 2026
Structure

Car paint is White Orchid Pearl and had been issued NHTSA complaint about it. The manufacturer lately issued warranty for the paint limited to 7 years (Mar/2025). Car paint started to chip off firstly on the driver side door as a small spot in 2022 and when notified the dealer, they did not pay much attention. Later on it was p…

Read full complaint

Car paint is White Orchid Pearl and had been issued NHTSA complaint about it. The manufacturer lately issued warranty for the paint limited to 7 years (Mar/2025). Car paint started to chip off firstly on the driver side door as a small spot in 2022 and when notified the dealer, they did not pay much attention. Later on it was peeling off on the windshield on the passenger side. By the time I brought it to dealer's attention during a routine maintenance in Apr/2025, it was pass the manufacturer warranty and was told they cannot do anything about. Suddenly on Jun/2026 the car paint on the roof started to peel off in sheets exposing several inches at once. And the spots that were already damaged are now very wide spread. It surely indicate a manufacturing defect and when contact American Honda for assistance they claim it passed the warranty and now the responsibility if the customer. I find this not acceptable and why I should be bearing the fault of the manufacturer and that happen right after their limited warranty ending make me to think that of a hoax and ingenuine.

NHTSA ODI #11757340

Mileage unknown · Jul 6, 2026
Electrical SystemStructureUnknown Or Other

I am filing a formal complaint regarding two critical manufacturing defects on my 2018 Honda HR-V that pose immediate safety risks and financial losses: 1. CRITICAL SAFETY ISSUE (Instrument Gauge Failure): The digital display gauge on the right side of the driver's dashboard consistently blinks out and displays entirely unreadab…

Read full complaint

I am filing a formal complaint regarding two critical manufacturing defects on my 2018 Honda HR-V that pose immediate safety risks and financial losses: 1. CRITICAL SAFETY ISSUE (Instrument Gauge Failure): The digital display gauge on the right side of the driver's dashboard consistently blinks out and displays entirely unreadable, corrupted characters. This failure makes it impossible to monitor the fuel gauge or know how much gasoline remains in the vehicle. This defect is highly temperature-dependent, becoming severely worse during colder months. Not being able to read the fuel gauge creates an immediate, dangerous safety hazard, risking sudden, unexpected engine stalling on active highways or getting stranded in hazardous conditions. 2. MANUFACTURING DEFECT (Paint Delamination): The vehicle is exhibiting severe paint peeling and flaking on the roof in four distinct places. The exterior clear coat and base coat are actively separating from the underlying primer due to an inherent manufacturing adhesion failure. The vehicle features the White Orchid Pearl color (Paint Code: NH-788P). American Honda Motor Co. previously acknowledged this exact production defect by issuing a Warranty Extension under Technical Service Bulletin (TSB) 19-064, extending coverage for 2016–2018 HR-Vs for 7 years. However, because this premature failure is only now manifesting on my vehicle, Honda Corporate and local dealerships are refusing to cover the thousands of dollars in necessary repair costs, claiming the 7-year window has expired. Limiting the remedy to an arbitrary timeframe for an inherent manufacturing defect leaves consumers with a structurally degrading vehicle (exposure to rust and metal deterioration) & zero recourse. Respectfully request that the Office of Defects Investigation compel American Honda to address the dashboard electrical failures and expand or reopen the remedy for known White Pearl paint peeling defect to ensure consumer safety& manufacturer accountability

NHTSA ODI #11748651

Mileage unknown · Mar 31, 2026
Structure

Roof and pillar paint peeling

NHTSA ODI #11728268

Mileage unknown · Jul 13, 2025
Structure

I am writing to report a serious issue with the paint on my white pearl Honda HR-V. The roof paint began peeling in 2023, and I initially attempted a minor repair using a paint pen from AutoZone. However, the problem has worsened significantly over the past six months. Recently, I took the vehicle to Maaco for an estimate, and …

Read full complaint

I am writing to report a serious issue with the paint on my white pearl Honda HR-V. The roof paint began peeling in 2023, and I initially attempted a minor repair using a paint pen from AutoZone. However, the problem has worsened significantly over the past six months. Recently, I took the vehicle to Maaco for an estimate, and they quoted approximately $2,400 to repaint the roof and side panels. I also contacted the dealership where I purchased the vehicle, and they confirmed that I had purchased an extended warranty which expired in October 2024. After researching the issue, I discovered that paint peeling is a common and widely reported problem for white pearl Honda models. I spoke with both American Honda and the dealership on July 2025, and while the Honda representative acknowledged that they are receiving many similar complaints, they stated that the company is still investigating the root cause and does not currently offer compensation. They classified the issue as normal wear and tear. I keep my vehicle well maintained, and it is only 8 years old. I strongly believe this is a manufacturing defect, not a result of neglect or environmental wear. I would like to formally file a complaint and request that Honda take responsibility for this issue. Thank you for your time and attention. I can provide additional photographs, repair estimates, and additional documentation upon request.

NHTSA ODI #11673199

Mileage unknown · Feb 24, 2024
StructureUnknown Or OtherCrash

*How was your safety or the safety of others put at risk? -YES. [XXX] Burbank, CA, intersection [XXX] and [XXX] [XXX] ) There was a huge rainfall this evening. I was heading east on [XXX] and was about to make a "U" going back opposite direction. Making sure there is no on going or opposite traffic, safely i made a "U" turn …

Read full complaint

*How was your safety or the safety of others put at risk? -YES. [XXX] Burbank, CA, intersection [XXX] and [XXX] [XXX] ) There was a huge rainfall this evening. I was heading east on [XXX] and was about to make a "U" going back opposite direction. Making sure there is no on going or opposite traffic, safely i made a "U" turn on a parking lot, the first parking spot..and some of a sudden i realised that my car was touched some obstacle. It was a street light pole but from that pole there was a supporting 45 degrees angle metal wire going across a parking spot! I was not able to see a metal wire because of a light reflection and working windshield wipers.! This metal wire went through my front of a car and cracked the front bumper, left fender i was not able to open my driver door. My speed by doing "U" turn was about 5 miles per hour.. I called to my insurance took a picture of an incident location they came up to me with an estimate $1.553.00... This is insane and might be definitely dangerous for motorcycles and scooters. I have all the pictures, and video as well. Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11573733

Mileage unknown · Jul 30, 2021
Structure

The paint on my car has started to chip away and will eventually result in rust. I have contacted Honda multiple times and have heard back zero times.

NHTSA ODI #11427192

Mileage unknown · Apr 21, 2021
Air BagsStructureCrashInjury

I TRIED TO SWERVE TO AVOID HITTING THE CAR IN FRONT OF ME

NHTSA ODI #11413256

35,000 miles · Nov 5, 2020
Structure

THE PAINT ON MY 2018 HONDA HR-V IS CHIPPING ON ALMOST EVERY SURFACE OF THE VEHICLE. IT STARTED ON THE ROOF, WHICH HAS TURNED INTO ABOUT A 2FT IN LENGTH SURFACE, AND IT IS NOW PEELING ON ALL 4 DOORS.

NHTSA ODI #11373149

17,000 miles · Oct 31, 2019
Structure

TL* THE CONTACT OWNS A 2018 HONDA HR-V. THE CONTACT STATED THAT WATER LEAKED INTO THE TRUNK OF THE VEHICLE WHENEVER IT RAINED OR WHEN SNOW MELTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000.

NHTSA ODI #11277244

Official recalls

3

23V858000 · Fuel System, Gasoline:delivery:fuel Pump

Dec 18, 2023

Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.

Consequence & remedy

Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.

Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.

20V314000 · Fuel System, Gasoline:delivery:fuel Pump

May 28, 2020

Honda (American Honda Motor Co.) is recalling certain 2018-2019 Acura NSX, 2019 Acura RDX, RLX and RLX Sport Hybrid, 2018-2019 Honda Accord, Civic Hatchback, Civic Type R and HR-V, 2019-2020 Insight and 2019 Fit vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Consequence & remedy

Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy: Honda will notify owners and dealers will replace the fuel pump assembly, free of charge. The recall began July 22, 2020. Owners may contact Honda customer service at 1-888-234-2138.

18V777000 · Service Brakes, Hydraulic:foundation Components:disc:caliper

Nov 1, 2018

Honda (American Honda Motor Co.) is recalling certain 2017-2019 Acura MDX, 2017-2018 Acura MDX Sport Hybrid, 2018-2019 Honda HR-V and Honda Odyssey, and 2016 Honda HR-V vehicles. The rear brake caliper pistons may have an insufficient coating, causing gas pockets to form, reducing brake performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."

Consequence & remedy

Consequence: A reduction of braking performance increases the risk of a crash.

Remedy: Owners will be notified, and Honda or Acura dealers will bleed the brakes, free of charge. The recall began December 11, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are C31 and L30.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE22011 · Rear Differential Seizure

Opened Nov 28, 2022 · Closed Jul 22, 2024

Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:axle Assembly:axle Shaft:seal; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals  prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential.  Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport.  Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: ·       Information regarding field failures does not indicate hazardous outcomes ·       The failures are occurring early in the life of the vehicle ·       Repairs are covered under the manufacturer’s warranty ·       The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.

Additional source detail variants (6)

Power Train:axle Assembly:axle Shaft

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals  prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential.  Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport.  Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: ·       Information regarding field failures does not indicate hazardous outcomes ·       The failures are occurring early in the life of the vehicle ·       Repairs are covered under the manufacturer’s warranty ·       The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.

Power Train:axle Assembly:axle Shaft:seal

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals  prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential.  Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport.  Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: ·       Information regarding field failures does not indicate hazardous outcomes ·       The failures are occurring early in the life of the vehicle ·       Repairs are covered under the manufacturer’s warranty ·       The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.

Power Train:axle Assembly

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals  prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential.  Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport.  Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: ·       Information regarding field failures does not indicate hazardous outcomes ·       The failures are occurring early in the life of the vehicle ·       Repairs are covered under the manufacturer’s warranty ·       The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.

Power Train:driveline:differential Unit

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals  prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential.  Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport.  Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: ·       Information regarding field failures does not indicate hazardous outcomes ·       The failures are occurring early in the life of the vehicle ·       Repairs are covered under the manufacturer’s warranty ·       The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.

Power Train:driveline:driveshaft

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals  prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential.  Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport.  Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: ·       Information regarding field failures does not indicate hazardous outcomes ·       The failures are occurring early in the life of the vehicle ·       Repairs are covered under the manufacturer’s warranty ·       The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.

Power Train

On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals  prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential.  Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport.  Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: ·       Information regarding field failures does not indicate hazardous outcomes ·       The failures are occurring early in the life of the vehicle ·       Repairs are covered under the manufacturer’s warranty ·       The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.