NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
10 reportsClear category filterMileage unknown · May 13, 2025
Structure
The amount of rust that has been exposed is absolutely insane. My adjuster found the initial section of rust when we had the Yukon in for repairs from a storm. In the past 2 months, the rust has caused a massive hole underneath the rear passenger's side door and we have had no choice but to get it repaired. The initial estimate …
Read full complaint
The amount of rust that has been exposed is absolutely insane. My adjuster found the initial section of rust when we had the Yukon in for repairs from a storm. In the past 2 months, the rust has caused a massive hole underneath the rear passenger's side door and we have had no choice but to get it repaired. The initial estimate for this single repair is going to be over $3400. This rust easily could've broken down further and gotten into the brakes and other components right behind it as it sits very close to the wheel well. This is an absolutely dangerous issue and should be addressed.
NHTSA ODI #11660673
122,376 miles · Feb 12, 2021
StructureUnknown Or OtherWheels
WHEN DRIVING BETWEEN 40-70 MILES AN HOUR. I FEEL A VIBRATION SOMEWHERE IN THE VEHICLE. THE VIBRATION FEELS LIKE U ARE ROLLING OVER RUMBLE STRIPS. THIS HAPPENS TIME AND TIME AGAIN ON THE HIGHWAY, WHILE IN MOTION ONLY.
NHTSA ODI #11395903
Mileage unknown · Aug 19, 2020
Structure
THE CLEAR COAT ON MY HOOD AND ROOF IS COMPLETELY GONE. I NOTICED THE HOOD LOOKED A LITTLE DULL ABOUT 6 MONTHS AGO AND IT PROGRESSIVELY GOT WORSE. NOW THE PAIN IS STARTING TO CHIP. THIS VEHICLE IS ONLY 5 YEARS OLD, THERE'S NO WAY THE CLEAR COAT SHOULD BE COMPLETELY GONE.
NHTSA ODI #11350220
66,000 miles · May 19, 2020
Air BagsElectrical SystemStructure
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. THE CONTACT STATED THAT WATER LEAKED INTO THE ROOF OF THE VEHICLE AND SATURATED THE AIR BAG AND THE MAIN FUSE BOX. THE CONTACT STATED THAT THERE WAS A TSB FOR THE FAILURE. THE VEHICLE WAS TAKEN TO RENO BUICK GMC CADILLAC DEALER, LOCATED AT 900 KIETZKE LANE, RENO, NV 89502, (775)-815-7660…
Read full complaint
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. THE CONTACT STATED THAT WATER LEAKED INTO THE ROOF OF THE VEHICLE AND SATURATED THE AIR BAG AND THE MAIN FUSE BOX. THE CONTACT STATED THAT THERE WAS A TSB FOR THE FAILURE. THE VEHICLE WAS TAKEN TO RENO BUICK GMC CADILLAC DEALER, LOCATED AT 900 KIETZKE LANE, RENO, NV 89502, (775)-815-7660, WHERE IT WAS STATED THAT THE FAILURE WAS A FACTORY DEFECT. THE TECHNICIAN REACHED OUT TO THE MANUFACTURER AND, THE MANUFACTURER AGREED TO COVER TEN PERCENT OF THE REPAIR COST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000.
NHTSA ODI #11325204
Mileage unknown · Sep 10, 2019
Exterior LightingStructure
ALL THE RUBBER WINDOW MOLDINGS ARE CURLING OUT UNDER PLASTIC TRIM BOTH TAIL LIGHTS WORK INTERMEDIATELY
NHTSA ODI #11254387
50,000 miles · Aug 4, 2019
Electrical SystemStructure
AFTER GETTING PULLED OVER BY THE POLICE FOR A TAIL LIGHT THAT WAS OUT,I WAS IN MOTION AND THIS IS WHEN I STARTED MY RESEARCH. RIGHT TAIL LIGHT IS OUT, FAULTY PARTS. CHECKED ALL FUSE AND WIRE CONNECTION FOR CORROSION, BUT THER WAS NO SIGN OF DAMAGE. GMC WANTS TO CHARGE $1,500 TO FIX. THE NEXT ISSUE IS THE PAINT JOB. I AM AT 50,…
Read full complaint
AFTER GETTING PULLED OVER BY THE POLICE FOR A TAIL LIGHT THAT WAS OUT,I WAS IN MOTION AND THIS IS WHEN I STARTED MY RESEARCH. RIGHT TAIL LIGHT IS OUT, FAULTY PARTS. CHECKED ALL FUSE AND WIRE CONNECTION FOR CORROSION, BUT THER WAS NO SIGN OF DAMAGE. GMC WANTS TO CHARGE $1,500 TO FIX. THE NEXT ISSUE IS THE PAINT JOB. I AM AT 50,000 MILES AND THE PAINT IS ALREADY FADING. THE CLEAR COAT WAS SUPER THIN AND CHEAPLY DONE. GMC SAID THEY WOULD COVER ONLEY 25% OF A $6000 - $12,000 PAINT JOB
NHTSA ODI #11241631
18,500 miles · Oct 30, 2017
StructureSuspensionUnknown Or Other
MY VEHICLE HAS A SIGNIFICANT VIBRATION WHEN TRAVELING 40MPH AND ABOVE WITH A REAR WINDOW DOWN. THE VIBRATION IS ALSO ACCOMPANIED BY INCREASED CABIN PRESSURE. THESE ISSUES ARE CAUSING HEADACHES, NAUSEA, AND DIZZINESS. DEALERSHIP CONFIRMS ISSUE AND TRIED TO REPAIR, BUT UNABLE TO. THE VIBRATION STARTED RIGHT AFTER WE TOOK DELIVERY…
Read full complaint
MY VEHICLE HAS A SIGNIFICANT VIBRATION WHEN TRAVELING 40MPH AND ABOVE WITH A REAR WINDOW DOWN. THE VIBRATION IS ALSO ACCOMPANIED BY INCREASED CABIN PRESSURE. THESE ISSUES ARE CAUSING HEADACHES, NAUSEA, AND DIZZINESS. DEALERSHIP CONFIRMS ISSUE AND TRIED TO REPAIR, BUT UNABLE TO. THE VIBRATION STARTED RIGHT AFTER WE TOOK DELIVERY OF THE CAR AND HAS ONLY GOTTEN WORSE. WE BOUGHT THE CAR IN OCTOBER 2015 AND THE ISSUE CONTINUES UNFIXED TO THIS DAY AFTER 5 VISITS.
NHTSA ODI #11041421
5,000 miles · Mar 1, 2016
StructureUnknown Or Other
MY 2015 GMC YUKON XL WITH 5000 MILES EXHIBITS A BUFFETING / PRESSURE SENSATION THAT CAN BE FELT PREDOMINATELY IN THE EARS BETWEEN 30 AND 70 MPH WHEN ONLY THE REAR PASSENGER WINDOWS ARE DOWN . AFTER A SHORT AMOUNT OF TIME IT BEGINS TO CAUSE DIZZINESS, EAR PAIN, AND HEADACHES. SOMETHING IS VERY WRONG AND MUST BE FIXED
NHTSA ODI #10839172
Mileage unknown · Jan 26, 2016
Power TrainStructureUnknown Or Other
WITH ALL WINDOWS UP, VEHICLE EXHIBITS A BUFFETING / PRESSURE SENSATION THAT CAN BE FELT PREDOMINATELY IN THE EARS BETWEEN 30 AND 50 MPH. SIMILAR TO WHEN ONLY THE REAR PASSENGER WINDOWS ARE DOWN IN MANY VEHICLES. I SECOND THE FACT THAT AFTER ANY AMOUNT OF TIME AT THESE SUSTAINED SPEEDS IT BEGINS TO CAUSE DIZZINESS, EAR PAIN, AND …
Read full complaint
WITH ALL WINDOWS UP, VEHICLE EXHIBITS A BUFFETING / PRESSURE SENSATION THAT CAN BE FELT PREDOMINATELY IN THE EARS BETWEEN 30 AND 50 MPH. SIMILAR TO WHEN ONLY THE REAR PASSENGER WINDOWS ARE DOWN IN MANY VEHICLES. I SECOND THE FACT THAT AFTER ANY AMOUNT OF TIME AT THESE SUSTAINED SPEEDS IT BEGINS TO CAUSE DIZZINESS, EAR PAIN, AND HEADACHES. GM FORUMS ARE FLOODED WITH COMPLAINTS. THIS VEHICLE OBVIOUSLY WAS MANUFACTURED WITH A SIGNIFICANT, KNOWN FLAW THAT THEY CANNOT CURRENTLY FIX. THIS SHOULD ABSOLUTELY BE A SAFETY ISSUE STRICTLY BASED UPON THE PHYSICAL SYMPTOMS ONSET BY THE FEELING WITHIN THE VEHICLE.
NHTSA ODI #10822332
200 miles · Dec 13, 2015
Power TrainStructureUnknown Or Other
VEHICLE EXHIBITS A "BUFFETTING" OR PRESSURE SENSATION THAT CAN BE FELT PRIMARILY IN THE EARS BETWEEN 40 AND 50 MPH. AFTER ANY AMOUNT OF TIME AT THESE SUSTAINED SPEEDS IT BEGINS TO CAUSE DIZZINESS, EAR PAIN, AND HEADACHES. THIS CONDITION WAS CONFIRMED BY THE DEALER WITH 3 SEPARATE DRIVERS INCLUDING A TECH, THE SALES MANAGER, AN…
Read full complaint
VEHICLE EXHIBITS A "BUFFETTING" OR PRESSURE SENSATION THAT CAN BE FELT PRIMARILY IN THE EARS BETWEEN 40 AND 50 MPH. AFTER ANY AMOUNT OF TIME AT THESE SUSTAINED SPEEDS IT BEGINS TO CAUSE DIZZINESS, EAR PAIN, AND HEADACHES. THIS CONDITION WAS CONFIRMED BY THE DEALER WITH 3 SEPARATE DRIVERS INCLUDING A TECH, THE SALES MANAGER, AND THE OWNER. GM HAS A TECHNICAL PI ISSUED, AS THE PROBLEM IS APPARENTLY RELATIVELY COMMON IN THESE VEHICLES. SUGGESTED REPAIRS INCLUDE RE-BONDING THE ROOF SHEET METAL TO THE FRAME, REPAIR/REPLACEMENT OF THE REAR DIFFERENTIAL, REPLACEMENT OF THE PROPSHAFT, REPAIR/REPLACEMENT OF WHEELS AND TIRES, REMOVAL AND "RELAXING" OF THE EXHAUST SYSTEM, AND MORE. NONE OF WHICH APPEARS TO SOLVE THE ISSUE. A QUICK INTERNET SEARCH TURNED UP DOZENS OF CASES WITH THIS ISSUE IN JUST ONE WEBSITE. GM HAS MANUFACTURED A VEHICLE WITH A SIGNIFICANT, KNOWN FLAW THAT THEY CANNOT CURRENTLY FIX. THIS FLAW SHOULD BE CONSIDERED A SAFETY ISSUE STRICTLY BASED UPON THE PHYSICAL SYMPTOMS TRIGGERED BY THE SENSATION WITHIN THE VEHICLE.
NHTSA ODI #10809923
Official recalls
2Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration